HYOSUNG GT650 - PARTS CATALOGUE Bedienungsanleitung

Part No. 99011HN9110EI

APR. 2009.

Printed in KOREA

1st Ed.

This owner’s manual contains important safety information.

Please read it carefully.

WARNING

This manual should be considered a permanent part of the motorcycle and

should remain with the motorcycle when resold or otherwise transferred to

a new owner or operator. The manual contains important safety informa-

tion and instructions which should be read carefully before operating the

motorcycle.

1. BATTERY INITIAL CHARGING

Initial charging of the battery is first charging after filling electrolyte for improvement of the

battery durability.

2. BATTERY INSTALLATION

Fill the electrolyte to the battery.

Leave the battery for 30 minutes.

Charge the battery by standard charging necessarily.

Install the battery to the motorcycle.

󳛪STANDARD CHARGING TIME : 1.2 A for 10 hours󳛫

BATTERY INITIAL CHARGING

Do not use the battery without the battery initial charging.

Otherwise, the battery may be shortened service life.

CAUTION

The



are started as the battery ignition system.

Do not permit to start or operate the throttle grip after started without the battery caused

by damage to the electrical system.

Always start or ride these motorcycles with the battery.

WARNING

All information, illustrations photographs

and specifications contained in this manual

are based on the latest product information

available at the time of publication. Due to

improvements or other changes, there may

be some discrepancies in this manual.

Hyosung reserves the right to make

changes at any time.

Please note that this manual applies to all

specifications for all respective destinations

and explains all equipments. Therefore,

your model may have different standard

features than shown in this manual.

󳟈

FOREWORD

THANK YOU for choosing Hyosung

motorcycle. We at Hyosung have

designed, tested and produced these

motorcycles using the most modern tech-

nology available to provide you with much

happy, enjoyable, safe riding. Motorcycling

is one of the most exhilarating sports and

insure you to enjoy riding and you should

become thoroughly familiar with the infor-

mation presented in this Owner's Manual

before riding the motorcycle.

The proper care and maintenance that

your motorcycle requires are outlined in this

manual.

By following these instructions explicitly

you will insure a long trouble-free operating

life for your motorcycle. Your Hyosung

dealer has experienced technicians that are

trained to provide your machine with the

best possible service with the right tools and

equipment.

IMPORTANT

BREAK-IN INFORMATION FOR

YOUR MOTORCYCLE

The first 1,600 km (1,000 miles) are the

most important in the life of your motorcycle.

Proper break-in operation during this time

will help ensure maximum life and perfor-

mance from your new motorcycle.

Hyosung parts are manufactured of high

quality materials, and manufactured parts

are finished to close tolerances. Proper

break-in operation allows the machined sur-

faces to polish each other and mate

smoothly.

Motorcycle reliability and performance

depend on special care and restraint exer-

cise during the break-in period. It is espe-

cially important that you avoid operating the

engine in a manner which could expose the

engine parts to excessive heat.

Please refer to the BREAK-IN section for

specific break-in recommendations.

WARNING / CAUTION / NOTE

Please read this manual and follow its

instructions carefully.

To emphasize special information the

wordsWARNING,CAUTIONand

NOTEhave special meanings

Information following these signal words

should be carefully reviewed.

N O T E

This provides special information to

make maintenance easier or important

instructions clearer.

These instructions point out special ser-

vice procedures or precautions that

must be followed to avoid damaging the

machine.

CAUTION

The personal safety of the rider may be

involved. Disregarding this information

could result in injury to the rider.

WARNING

Noise Control System (muffler assembly)

TAMPERING WITH NOISE CONTROL SYSTEM PROHIBITED

Owners are warned that the law may prohibit :

(a) The removal or rendering inoperative by any person other than for the

purpose of maintenance, repair or replacement, of any device or ele-

ment of design incorporated into any new vehicle for the purpose of

noise control prior to its any sale or delivery to the ultimate purchaser or

while it is in use ; and

(b) The use of the vehicle after such device or element of design has been

removed or rendered inoperative by any person.

MAINTENANCE :

The exhaust system of this motorcycle requires no periodic maintenance.

The engine should be adjusted to the manufacture’ s specifications and the

spark plug should be kept in good condition. Running the engine with

incorrectly operating spark plug or misadjusted carburetor may cause per-

manent damage to the catalyst and to the noise control system.

WARNING

Motorcycle riding is great fun and an excit-

ing sport. Motorcycle riding also requires

he/she to take some extra precautions to

ensure the safety of the rider and passen-

ger. These precautions are :

Before first use of the

read this owner

’s manual carefully to become familiar

with these motorcycles’s features,

and safety and maintenance require-

ments. Review all instructions,

requirements and warnings. Keep the

owner’s manual in the owner’s manu-

al storage compartment located under

the rear seat.

Before the rider’s first use of the



, make sure that

he / she is familiar with the location

and operation of all controls, and has

been instructed in the proper opera-

tion of the motorcycle.

For first use of the



, find a level,

open area for the rider to use to

become familiar with the operation of

controls and the operating and han-

dling characteristics of these motor-

cycles.

WARNING

Before each use, perform daily

inspections with the rider. Specific

items to check are listed in the

INSPECTION BEFORE RIDING sec-

tion on page 59 of this owner’s manu-

al.

Make sure the rider wears a helmet,

eye protection, and protective cloth-

ing (gloves, leather or heavy cloth

pants, long sleeved shirt or jacket,

boots).

Permit use only by two-passenger.

These motorcycles are designed for

use only by two-passenger.

Do not permit anyone to operate the



under the influ-

ence of alcohol or other drugs

caused by damage to the motorcycle

or altered handling characteristics.

Observe periodic maintenance

requirements your authorized

HYOSUNG dealer is trained and

equipped to perform this service.

Drain gasoline from the fuel tank

prior to transporting the



Caution the rider and others near the



not to get close

to or touch any moving parts or any

heated areas such as the engine and

exhaust system.

Do not make any modifications to

the



Modifications may make the motorcy-

cle unsafe or illegal in your state.

WARNING

CONSUMER INFORMATION

SAFE RIDING RECOMMENDATION

FOR MOTORCYCLE RIDERS

The



are equipped

with the side stand ignition interlock

system.

If the transmission is in neutral or the

side stand up, you can only start the

engine with pulling the clutch lever.

This side stand ignition interlock system

prevents the motorcycle from being

started with side stand down.

Make sure that the side stand igintion

interlock system is working properly

before riding.

WARNING

Do not run the engine indoors or

where there is little or no ventilation.

Exhaust gases contain carbon

monoxide, a potentially lethal gas that

is colorless and odorless.

Never leave the motorcycle running

while unattended, even for a short

time.

WARNING

These motorcycles always come on the

head lamp, position lamp, meter lamp,

tail lamp and license plate lamp when

the ignition switch was turned to the

“ON” position.

CAUTION

While operating the



, the rider should

keep both feet on the footrests at all

times, or injuries resulting from acci-

dents. Moving the rider’s feet from the

footrests reduces the rider’s ability to

control the motorcycle, and could lead

to an accident.

WARNING

Keep both hands on the handgrips at all

times when riding. Removing your

hands from the handgrips reduces your

ability to control the motorcycle, and

could result in an accident.

WARNING

Always open the throttle gradually to

prevent front wheel lifting. Failure to

observe this precaution may result in

loss of control and an accident.

WARNING

WHEN KEEPING FOR LONG PERIOD :

1. Supply the enough fuel in the fuel

tank.

2. Remove the battery from the motorcy-

cle.

CAUTION

The trunk could be heated. Don’t

keep anything that doesn’t endure

heat.

Don’t keep the fragile.

Check if it is locked.

The unlocking of rear seat could

cause serious accident.

Don’t allow water to get inside the

trunk or it could damage.

Don’t keep the valuables in the trunk

when leaving unattended.

Loading limit of trunk : 1 (2.21 lbs)

CAUTION

Andere Handbücher für GT650 - PARTS CATALOGUE

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere HYOSUNG Motorrad Handbücher

HYOSUNG

HYOSUNG Aquila 650 FI Bedienungsanleitung

HYOSUNG

HYOSUNG GT 650 EFI Bedienungsanleitung

HYOSUNG

HYOSUNG RT125D - PARTS CATALOGUE Bedienungsanleitung

HYOSUNG

HYOSUNG Comet 250 R Bedienungsanleitung

HYOSUNG

HYOSUNG GF125 Bedienungsanleitung

HYOSUNG

HYOSUNG Aquila GT250 R Ej Bedienungsanleitung

HYOSUNG

HYOSUNG COMET GTR125 - CATALOGUE Bedienungsanleitung

HYOSUNG

HYOSUNG MS3 - CATALOGUE Bedienungsanleitung

HYOSUNG

HYOSUNG GT 650 Bedienungsanleitung

HYOSUNG

HYOSUNG Aquil GV650 Bedienungsanleitung

HYOSUNG

HYOSUNG RX 125 - Bedienungsanleitung

HYOSUNG

HYOSUNG COMET 125 - SERVICE Bedienungsanleitung

HYOSUNG

HYOSUNG GT250 REi Bedienungsanleitung

HYOSUNG

HYOSUNG GD250 Bedienungsanleitung

HYOSUNG

HYOSUNG GT650 EURO 3 - CATALOGUE Bedienungsanleitung

HYOSUNG

HYOSUNG RT125D - PARTS CATALOGUE Bedienungsanleitung

HYOSUNG

HYOSUNG GT650 R Ei Bedienungsanleitung

HYOSUNG

HYOSUNG GV 250 EFI Bedienungsanleitung

HYOSUNG

HYOSUNG GV250 AQUILA - Bedienungsanleitung

HYOSUNG

HYOSUNG GT 125 R Bedienungsanleitung

HYOSUNG

HYOSUNG XRX125sm Bedienungsanleitung

HYOSUNG

HYOSUNG Karion Bedienungsanleitung

HYOSUNG

HYOSUNG GT250 FI Bedienungsanleitung

HYOSUNG

HYOSUNG ST7 Bedienungsanleitung

Beliebte Motorrad Handbücher anderer Marken

OHVALE

OHVALE GP-0 Stücklistenhandbuch

Yamaha

Yamaha Star XV19CTSZ 2009 Bedienungsanleitung

KTM

KTM 350 XCF-W USA Bedienungsanleitung

Husqvarna

Husqvarna FC 250 2016 Bedienungsanleitung

Ducati

Ducati SCRAMBLER 800 Gebrauchsanweisung

APRILIA

APRILIA ETV MILLE CAPONORD - PART1 02-2001 Bedienungsanleitung

Yamaha

Yamaha 2006 YZF-R1V Bedienungsanleitung

KTM

KTM Freeride E-XC 2021 Bedienungsanleitung

Fantic

Fantic Enduro 125 Bedienungsanleitung

Ducati

Ducati Supersport 750 desmodue Bedienungsanleitung

MV Agusta

MV Agusta 2008 F4 312RR 1078 Gebrauchsanweisung

Yamaha

Yamaha XVS650A Bedienungsanleitung

Yamaha

Yamaha YZF-R6T(C) Handbuch

Ducati

Ducati 748 monoposto strada Bedienungsanleitung

ATK

ATK 1988 250 Bedienungsanleitung

Excelsior-HENDERSON

Excelsior-HENDERSON 1999 HCX Bedienungsanleitung

Triumph

Triumph Thunderbird Bedienungsanleitung

Yamaha

Yamaha 2006 FJR1300A Bedienungsanleitung