Igloo IGW 400 Bedienungsanleitung
IGW 400 - 4 BURNER STAINLESS STEELGAS GRILL (BB10514A)
ASSEMBLYAND OPERATING INSTRUCTIONS
50,000 BTUs with
10,000 BTUs Side Burner
Igloo® is a trademark of Igloo Products Corp. Registered in the United States Patent and Trademark Office. All Rights Reserved.
1
FOR YOUR SAFETY
If you smell gas:
1. Shut off gas to the appliance.
2. Extinguish any open flame.
3. Open hood.
4. If odor continues, immediatel
y
call
y
our
g
as supplier or
y
our fire
department.
FOR YOUR SAFETY
1. Do not store or use
g
asoline or
other flammable vapors or liquids
in the vicinit
y
of this or an
y
other
appliance.
2. An LP cylinder not connected for
use shall not be stored in the
vicinit
y
of this or an
y
other
appliance.
zFor outdoor use onl
y
. Not for commercial use.
zRead instructions before usin
g
the appliance. Failure to
follow instructions could result in death, serious bodil
y
injury, and/or property loss.
zWarnin
g
: accessible parts ma
y
be ver
y
hot. Keep
y
oun
g
children away.
zDo not move the appliance during use.
zTurn off the gas supply at the gas cylinder after use.
zAny modification of the appliance may be dangerous.
zThis grill can NOT be converted to natural gas.
zInstaller to leave instructions with the consumer and
consumer to retain them for future reference.
WARNING
zCONTACT 1-866-NAO-GRILL(1-866-626-4745) FOR ASSISTANCE
zDO NOT RETURN TO PLACE O
F
PURCHASE
WARNINGS
PLEASE READ THESE INSTRUCTIONS CAREFULLY BEFORE ASSEMBLY AND USE.
FAILURE TO FOLLOW THESE INSTRUCTIONS COULD RESULT IN DEATH, SERIOUS
BODILY INJURY, AND/OR PROPERTY LOSS. READ AND FOLLOW ALL INSTRUCTIONS
CAREFULLY BEFOREASSEMBLY OR USE OF THIS OUTDOOR GAS GRILL.
*WARNING! Read and follow all instructions. Retain these instructions for future reference.
zInstallation must conform with local codes, or in the absence of local codes, with either the National
Fuel Gas Code, ANSI Z223.1/NFPA 54, or CAN/CGA-B149.1, Natural Gas and Propane
Installation code.
zThis outdoor gas grill is for use only outdoors. DO NOT use inside a building, garage, or any other
enclosed area.
zThis outdoor gas grill is not intended to be installed in or on recreational vehicles and/or boats.
zThis outdoor gas grill should not be located under overhead combustible construction and proper
clearances must be maintained at all times from combustible construction and/or materials, with
MINIMUM clearances as follows:
From Sides – 24 in. (61 cm)
From back – 24 in. (61 cm)
zPlace in a well-ventilated area.
zInspect the hose before each use. If there is evidence of excessive abrasion or wear, or the hose is
cut, do not operate grill. Use only the pressure regulator and hose supplied with this grill.
Contact Customer Service for assistance - 1-866-626-4745 or www.americancustomerservice.com.
z*WARNING! If your outdoor gas grill catches on fire, use an ABC fire extinguisher to extinguish
the fire. Never attempt to extinguish a grease fire with water or other liquids. Turn off all control
knobs on outdoor gas grill and LP cylinder valve if they can be reached safely. If you cannot safely
reach the control knobs or LP cylinder valve to stop the flow of gas that can feed the fire, evacuate
the area and call the fire department
zThis gas grill is not designed to be used with natural gas. Conversion to natural gas should NOT be
attempted as it will create an unsafe situation.
zThis gas grill should not be connected to any gas supply other than a Type 1 compatible propane gas
cylinder. Connection to home gas lines will result in poor performance of the grill and may result
in an unsafe condition.
zAny LP gas supply cylinder used with this grill must be approximately 12 in. (30.5 cm) diameter
and 18 in. (45.7 cm) high. The maximum fuel capacity is 80 percent and is approximately 20
pounds (9 kg) of propane. The maximum weight of a properly filled cylinder is approximately 38
pounds (17.2 kg)<47.7 lbs. (21.6kg) nominal water capacity>. The LP cylinder must have a shut-off
valve terminating in a Type 1 LP gas cylinder valve outlet.
zAny LP gas cylinder used with this gas grill must be constructed and marked in accordance with the
specifications for LP gas cylinders of the U.S. Department of Transportation (DOT) or the National
Standard of Canada, CAN/CSA-B339, Cylinder, Spheres and Tubes for Transportation of
Dangerous Goods; and Commission, as appliance; and must be provided with a listed overfilling
prevention device.
zThe LP gas cylinder must be a Type 1 compatible cylinder with a Type 1 cylinder valve that has a
back-check valve, which does not permit gas flow, until a positive seal has been obtained.
2
3
zThe cylinder must be arranged for vapor withdrawal. It must also include a collar to protect the
cylinder valve. A safety relief device having direct communication with the vapor space of
cylinder must be provided. This will expel high-pressure gas if the cylinder is overfilled or
overheated which could result in fire or explosion.
zThe gas must be turned off at the cylinder when the outdoor gas grill is not in use.
zDo not store this gas grill indoors unless cylinder is disconnected and removed from the appliance.
zCylinders must always be stored outdoors out of the reach of children and must not be stored in a
building, garage, or any other enclosed area.
*WARNING! Do not store a spare LP gas cylinder under or near this appliance. Never fill the cylinder
beyond 80 percent full. If these installationsinstructions are not followed exactly, a fire causing death or
serious injury may occur.
zNever use this gas grill without the drip pan in place.
z*WARNING! If you see grease or other hot material dripping from the grill onto valve, hose or
regulator, turn off gas supply immediately. After the grill has cooled, determine the source and
correct it.
zCheck the LP gas grill for gas leaks and burner obstructions before each use. *WARNING! Do not
use a flame to check for gas leaks. See
Leak Test Instruction section of this manual for correct
leak test procedures. A clogged burner tube can cause a fire inside or beneath the grill.
z*DANGER! If you see, smell, or hear, escaping gas from the LPcylinder, evacuate the area
and call the fire department.
z*WARNING! Never light the gas grill before lifting the lid, to prevent an explosion from gas
build-up.
zExercise care when using this gas cooking appliance. Never leave gas grill unattended during
operation or cleaning.
zNever allow children to operate or play near this or any gas grill.
z*WARNING! Do not move a gas grill when in operation or hot.
z*WARNING! Never touch hot surfaces. Use heat resistant gloves. The gas grill will become
very hot.
zUse of this gas grill other than for the intended use, or alteration of gas grill in any way may not be
safe, and could result in death, serious bodily injury and/or property loss.
zNever attempt to repair the gas grill or LP cylinder yourself. Contact the manufacturer for
information regarding repairs to your gas grill. Contact your local Liquefied Petroleum supplier
for information regarding repairs to you LP gas cylinder.
z*WARNING! Do not use aerosols or store flammable liquids or materials near this gas grill.
z*WARNING! Do not wear loose clothing around any gas grill while in use or hot.
zNever store an LP gas cylinder indoors (empty or filled). If storing the gas grill indoors,
disconnect the LP gas cylinder and store it outdoors, out of the reach of children.
zNever leave an LP cylinder inside a vehicle, which may become overheated by the sun.
zDo not attempt to disconnect any gas fitting while your gas grill is in operation.
zYour gas grill should be cleaned regularly.
zThis gas grill should never be used with more than 50% of the cooking area as a solid plate (griddle).
Full coverage of plates will cause excessive heat and could damage the grill.
zAny alteration to the design of the grill will void any and all warranties and may result in an unsafe
condition.
Parts List For Grill -- BB10514A
For parts please call us at 1-866-626-4745 M-F, 8:30am to 5:30pm EST
ITEM DESCRIPTION PART Replacement
Part # QTY
INCLUDED
1 Frame
--preassembled
G200
1
2 Brass Burners
--preassembled
G233 4
3 Cross Support
G202 1
4 Back Panel
G203 1
5 Left Door
G204 1
6 Right Door
G205
1
7 Warming Rack
G206 1
8 Body
G207
Not
Replaceable
1
9 Left Shelf
G208 1
10 Right Shelf
G209 1
4
11 Side burner knob
G128 1
12 Knob base
G129 1
13
Cooking Grids
G210 2
14
Flame Diffusers
G211 4
15 Cylinder lock line
G127 1
16 Drip pan
G212 1
17 Cylinder Support
G213 1
18 S Hooks
G214 5
19 Rotisserie Motor
G215 1
20 Motor Pole A
(Handle Side) G216 1
21 Motor Pole B
(Motor Side) G217 1
22 Motor Support
G218 1
23 Forks
G219 2
24 Wing Nut / Thumb
Screws--preassembled G220 3
5
25 Motor Pole Handle
(Plastic)
--preassembled
G221 1
26 Motor Pole Coupling
--preassembled
G222 1
27 Pole Restrictor
--preassembled
G223 1
28 Snap-In Thermostat
--preassembled
G130 1
29 Side Shelf Handle --
preassembled G131 1
30 Door Handle –
preassembled G132 2
31 Door Spring Latch
--preassembled
G133 2
32 Tank Support Shelf
Lock --preassembled
G134 1
33 Burner Insect Cover
--preassembled
G135 5
34 Match Holder with
chain - preassembled
G136 1
35 Dual Regulator and
Hose - preassembled
G224 1
36 Side Burner Valve
–preassembled
G225 1
37 Rubber Bumper (lid)
--preassembled
H11A 2
38 Hood --preassembled
G226 1
39 Hood Handle
--preassembled G227 1
40 Hood Handle Bracket
(Left) --preassembled
G228 1
41 Hood Handle Bracket
(Right) --preassembled
G229 1
6
7
42 Side Burner Trivet
--preassembled
G230 1
43 Hood Pin & Cotter Pin
--preassembled G231 2
44 Door Magnet w/
screws --preassembled
G140 4
45 Igniter Cover
--preassembled
G141 1
46 Rear Cross Support w/
screws --preassembled
G232 1
47 Fixed Castors
G201 2
48 Swivel Castors
G234 2
Hardware Pack H240 1
A M6x10 Bolts H610 2
B M6x12 Bolts H612 4
C M6x16 Bolts H616 35
D M6x20 Bolts H620 4
E M5X12 Bolts H512 2
F M4X8 Bolts H651
2
G D6 Washers
H416 29
H D6 Spring Washers
H426 19
I D5 Washers
H415 2
J D5 Spring Washers
H425 2
K D4 Washers H411 2
L M5 Nuts
H515 2
M Battery
H011 1
ASSEMBLY INSTRUCTIONS
Before You Start
zWhen you are ready to start, make sure that you have the right tools at hand, plenty of space and a
clean dry area for assembly.
Assembly – Note: Two People Required forAssembly
zUsing knife or box cutter, cut open carton.
zLay out all bolts and check lengths before assembly. It is recommended that the carton is cut open
and spread out on the floor and used as a protective surface during assembly. Refer to the assembly
diagrams as necessary.
zRemove all packaged parts from the inside of the grill body before assembling.
zThis product is for OUTDOOR USE ONLY.
zNEVER use indoor, in an enclosed area or below ground level.
zNEVER use an adjustable regulator with this grill. Use only the pressure regulator and hose
supplied.
8
STEP – 1:
Unpack and inspect all parts listed. If you
believe you have missing parts, please
check all boxes parts of the grill. Some
parts are shipped in place or pre-assembled.
If you have damaged or missing parts, do
not return to the store. Please contact
American Customer Service toll free at
1-866-626-4745 or visit us on the web at
www.americancustomerservice.com.
Please have your model number
(BB10514A) and the Replaceable Part #
available.
STEP – 2:
Turn Frame (1) up-side down, screw Fixed
Castor (47) into frame (1) using six Bolts (C),
two Bolts (A), eight Spring Washers (H), and
eight Washers (G), as shown..
Screw Swivel Castor (48) into frame (1) using
seven Bolts (C), seven Spring Washers (H), and
seven Washers (G), as shown.
Please lock all casters before continuing with
assembly.
1
C
H
G
48
47 C
A
Note : had to increase size of drawing
so the hardware parts are visible.
Also we changed your wording on #of
pieces so it is not confusing to the
consumer.
9
4CG1
STEP – 3:
Attach Back Panel (4) to Frame (1) with
Bolts (C), Washers (G), as shown.
17
C
1
STEP – 4:
Attach Cylinder Support (17) to frame
(1) with Bolts (C), as shown.
STEP – 5:
Attach Cross Support (3) to Frame (1)
with Bolts (C), Spring Washers (H)
and Washers (G), as shown.
Note: The two “tabs” of the Cross
Support (3) will be oriented UP for
assembly.
CHG31
10
Andere Handbücher für IGW 400
1
Dieses Handbuch passt für folgende Modelle
1
Inhaltsverzeichnis
Andere Igloo Grill Handbücher
