JVC KS-AX4700 Bedienungsanleitung

SERVICE MANUAL

KS-AX4700KS-AX4700

No. 49621

Apr. 2001

KS-AX4700

POWER AMPLIFIER

Printed in Japan

200104(S)

(No. 49621)

VICTOR COMPANY OF JAPAN, LIMITED

MOBILE ELECTRONICS DIVISION

PERSONAL & MOBILE NETWORK B.U. 10-1,1Chome,Ohwatari-machi,Maebashi-city,Japan

Caution

If electricity is connected during disassembly, it must be a no load current. If it is load

current, be sure to attach a heat sink to the power-amp IC. This will be damaged if the

above precautions are not followed, as it does not have a sub heat sink attached to it.

Contents

Safety precaution

Location of main parts

Removal of main parts

Test method

Description of major ICs

1-2

1-3

1-5

1-7

1-8

Area Suffix

Continental Europe

Northern America

TEL 13942296513 QQ 376315150 892498299

http://www.xiaoyu163.com

KS-AX4700

1-2

CAUTION

Burrs formed during molding may be left over on some parts of the chassis. Therefore,

pay attention to such burrs in the case of preforming repair of this system.

TEL 13942296513 QQ 376315150 892498299

http://www.xiaoyu163.com

KS-AX4700

1-3

Location of main parts

REAR PANEL

HEAT SINK

INPUT for POWER FUSE OUTPUT TERMINAL (L/R)

FRONT PANEL

LOW INPUT (L)

HEAT SINK

LOW INPUT (R)

CONTROL PANEL

HEAT SINK

SWITCH KNOB

VOLUME KNOB

TEL 13942296513 QQ 376315150 892498299

http://www.xiaoyu163.com

KS-AX4700

1-4

GND wire

MAIN PCB

DIODE

SUB PCB

HEAT SINK

(Bottom view)

POWER TRANSISTER

POWER FET

POWER TRANSISTER

TEL 13942296513 QQ 376315150 892498299

http://www.xiaoyu163.com

KS-AX4700

1-5

From the bottom side of the main unit, remove the 4

screws A retaining the bottom cover.

Then remove the 6 screws B retaining the bottom

cover.

Remove the bottom cover.

Removal of main parts

Removing the bottom cover (see Fig. 1)

Remove the bottom cover from the main unit.

Loosen and remove the 2 screws C retaining the top

plate on the main unit. (Stoppers are attached to the

backs of the C screws so that they cannot be

removed easily.)

Remove the 6 volume knobs on top of the control

panel. If it cannot be pulled out easily, insert a rope

or wire between the base of the volume knob and the

control panel so that the volume knob is raised a little

above the surface and then remove it.

(Be careful when inserting a lever etc. not to

scratch the surface of the control panel).

Remove the 4 screws D retaining the control panel.

Then detach the control panel and the switch knobs.

Removing the MAIN PCB

(see Fig. 2 to 8)

(Side view)

Rope or wire

Volume knob

Control panel

Bottom cover

Fig. 1

Fig. 3

Fig. 2

Fig. 4

If electricity is connected during disassembly,

it must be a no load current. If it is load

current, be sure to attach a heat sink to the

power-amp IC. This will be damaged if the

above precautions are not followed, as it

does not have a sub heat sink attached to it.

CAUTION:

Top panel

Switch knob Control panel

D D

Volume knob

TEL 13942296513 QQ 376315150 892498299

http://www.xiaoyu163.com

KS-AX4700

1-6

Remove the 13 screws E retaining the panels on

both sides of the main unit.

Remove the MAIN PCB by lift up the arrow mark.7.

Remove the 14 screws F attaching the MAIN PCB to

the bottom of the main unit.

Fig. 7

Fig. 5

Fig. 6

Front panel

Fig. 8

Rear panel

MAIN PCB

(Side view)

TEL 13942296513 QQ 376315150 892498299

http://www.xiaoyu163.com

KS-AX4700

1-7

Test method

Check the voltage and frequency of the secondary

toroidal coil.

Measure the secondary toroidal coil, if the standard

frequency value of 36.0 kHz ± 50 Hz is not attained,

measure the R60 terminal, then adjust the SV01 so

that the R60 terminal becomes 36.0 kHz ± 50Hz.

Note:

TEST SET

FREQUENCY COUNTER

MAIN PCB

(+)

(

)

POWER SUPPLY

14.4V

75Vp-p

±2.5V

DC/DC CONVERTER SECOND GENERATOR SWITCHING

TEST ITEM

VOLTAGE TEST

FREQUENCY CHECK

75Vp-p±2.5V

36.0KHz±50Hz

OSCILLOSCOPE

VOLT/DIV: 10

TIME/DIV: 10mcec

SPECIFICATION CONDITION

FREQUENCY:36.0kHz ± 50Hz

VOLTAGE VALUE:75Vp-p ± 2.5V

When measuring, adjust and apply power

with no signal or load on each board.

R01

R60

R03

C01

J09

Q01

C31

C68

Measuring

Points

MAIN PCB

TEL 13942296513 QQ 376315150 892498299

http://www.xiaoyu163.com

KS-AX4700

1-8

PIN CONNECTIONS

(TOP View)

Noninv

Input

Inv

Input

Compen/PWN

Comp Input

Dead Time

Control

Ground

Noninv

Input

Inv

Input

Vref

Output

Control

VCC

Dead-Time

Comparator

Lockout

PWM

Comparator

Oscillator

Ck Q

Flip-

Flop

Reference

Regulator

0.7mA

0.7V

0.12V

3.5V

4.9V

7141615321

TL494

Description of major ICs

TEL 13942296513 QQ 376315150 892498299

http://www.xiaoyu163.com

SERVICE MANUAL

KS-AX4700KS-AX4700

No. 49621

Apr. 2001

KS-AX4700

POWER AMPLIFIER

Printed in Japan

200104(S)

(No. 49621)

VICTOR COMPANY OF JAPAN, LIMITED

MOBILE ELECTRONICS DIVISION

PERSONAL & MOBILE NETWORK B.U. 10-1,1Chome,Ohwatari-machi,Maebashi-city,Japan

Caution

If electricity is connected during disassembly, it must be a no load current. If it is load

current, be sure to attach a heat sink to the power-amp IC. This will be damaged if the

above precautions are not followed, as it does not have a sub heat sink attached to it.

Contents

Safety precaution

Location of main parts

Removal of main parts

Test method

Description of major ICs

1-2

1-3

1-5

1-7

1-8

Area Suffix

Continental Europe

Nothem America

TEL 13942296513 QQ 376315150 892498299

http://www.xiaoyu163.com

KS-AX4700

2-1

Circuit block diagram

Q112,Q212

Q113,Q213

POWER

INPUT

+12V

D.C.

REM

F01

SV01

MUTE

CONTROL

+/- 15V

VCC

VEE

Q80

Q05

~Q08

Q01

Q02

TRANS

T01

PROTECT

Q40,Q41

Q45,Q46

Q55,Q56

POWER

REGULATOR

POWER

CONTROL

U701

FRONT

R-IN

INPUT

AMP

POWER

AMP

Q100

Q200

FRONT

R-OUT

L-OUT

VR101A

U101

-A

U102

-A

VR102A

U103

-A

U104

-A

U104

-B

BASS BOOST

50Hz 0~12dB VARIABLE

CROSS OVER

80Hz 12dB/OCT FIXED

LPF

OFF

HPF

Q101~

Q111

L-IN

VR101B

U101

-B

U102

-B

VR102B

U105

-A

U106

-A

U106

-B

LPF

OFF

HPF

Q201~

Q211

TEL 13942296513 QQ 376315150 892498299

http://www.xiaoyu163.com

Inhaltsverzeichnis

Andere JVC Verstärker Handbücher

JVC

JVC KS-AX7300 Bedienungsanleitung

JVC

JVC KS-AX6700 Bedienungsanleitung

JVC

JVC A-X3 Bedienungsanleitung

JVC

JVC A-K11 Bedienungsanleitung

JVC

JVC KS-AX3500 - Amplifier Bedienungsanleitung

JVC

JVC KS-AX201 Bedienungsanleitung

JVC

JVC AX-330BK Bedienungsanleitung

JVC

JVC AX-A661TN Bedienungsanleitung

JVC

JVC A-K11 Bedienungsanleitung

JVC

JVC M-7050 Bedienungsanleitung

JVC

JVC KS-DR3004 Bedienungsanleitung

JVC

JVC KSAX3002 - Compact Power Amplifier Bedienungsanleitung

JVC

JVC KS-AR8002D Bedienungsanleitung

JVC

JVC KS-AX6700 Bedienungsanleitung

JVC

JVC KS-AX3300 Bedienungsanleitung

JVC

JVC KS-AX3300 Administratorhandbuch

JVC

JVC KS-DR1004D Bedienungsanleitung

JVC

JVC KS-AX3205D Bedienungsanleitung

JVC

JVC KS-AX4500 Bedienungsanleitung

JVC

JVC KS-DR3005D Bedienungsanleitung

JVC

JVC KS-AX3004 Bedienungsanleitung

JVC

JVC JA-S22 Bedienungsanleitung

JVC

JVC AX-V55BK Bedienungsanleitung

JVC

JVC KS-DR3001D Bedienungsanleitung

Beliebte Verstärker Handbücher anderer Marken

ASTRO

ASTRO HVO V40 P Bedienungsanleitung

Marantz

Marantz SUPERSCOPE BLA-545 Montageanleitung

NAD

NAD CI980 Bedienungsanleitung

Technics

Technics SE-CH770 Bedienungsanleitung

Harman Kardon

Harman Kardon HK6300 Bedienungsanleitung

NAD

NAD T975 Bedienungsanleitung

McIntosh

McIntosh MA6850 Bedienungsanleitung

Electro-Harmonix

Electro-Harmonix ENGLISH MUFF’N Bedienungsanleitung

Viatron

Viatron Autrix Bedienungsanleitung

GME

GME GA9800 Bedienungsanleitung

Atlas

Atlas CP700 Bedienungsanleitung

Roland

Roland KC-1000 Bedienungsanleitung

Pyle

Pyle PFMRA350BW Bedienungsanleitung

Advantage

Advantage S-250 Bedienungsanleitung

IRT Electronics

IRT Electronics DVA-3007 Bedienungsanleitung

Dimavery

Dimavery BA-100 Series Bedienungsanleitung

Sony

Sony XM-S400D Bedienungsanleitung

Schertler

Schertler ROY X Bedienungsanleitung