Kalee Lotus Exige S B00KD3G2DS Leitfaden

Assembly Manual & User’s Guide

Battery Operated Ride-On Vehicle

Item No.: B00KD3G2DS

(KL-7011-12V)

Lotus Exige S

Adult Assembly Required

This manual contains safety instructions and important information which will

help you assemble the unit. Please keep this manual for future purposes.

WARNING:

Please read this manual carefully before assembly and use.

Produced under licence from Group Lotus plc. LOTUS, the Lotus Roundel, car names and all

associated logos and distinctive designs are trademarks of Group Lotus plc

Produit sous licence de Group Lotus plc. L’emblême LOTUS, les noms des véhicules et tous

logos et formes distinctives associés sont des marques déposées de Group Lotus plc

Age: 3 years and up

Maximum Capacity: 30kgs / 66lbs

Max Speed: 3.5-4.5km/h / 2.2-2.8 mph

Battery Type: Sealed lead-acid rechargeable, 12 Volt 7Ah

Charging time: Always charge the battery for 8-10 hours before first use

and when recharging is needed. Never charge for more

than 20 hours.

Power input for Charger: A/C 100-240 Volts 60 Hz

Power output to Battery: DC 14 Volts, 1000mA

Vehicle / Battery Specifications:

WARNING:

Use the toy only on flat surfaces, such as sidewalks, driveways or

playgrounds. Do not ride the vehicle in dangerous places such as busy

streets, roads or highways.

Never use near swimming pools or other bodies of water.

Never ride the vehicle in muddy or sandy areas. Never ride in hilly

areas or on steep slopes. This vehicle was made to operate on dry

leveled ground.

Never ride in the dark or in dimly lit areas.

Clean the vehicle only with a damp cloth and never submerge vehicle

in water or spray with water directly from a hose.

Only one child should ride this vehicle at a time.

Do not exceed the recommended weight limit of 66lbs.

To avoid suffocation of children please destroy all plastic bags after

assembly of the vehicle.

If vehicle is equipped with a forward / reverse switch, never press

this switch while vehicle is in motion. Always stop the vehicle before

switching directions.

10. The charger used for the vehicle are to be regularly examined for

damage to the cord, plug, enclosure and other parts, and in the event

of such damage, they must not be used until that damage had been

repaired.

11. The toy should be used with caution since skill is required to avoid

falls or collisions causing injury to the user or third parties.

CHARGING CAUTIONS:

- The charger is not a toy. Do not allow children to play with the

charger or to recharge the battery.

- Turn the power switch to “OFF” when charging.

- Before the first use, you should charge the battery for 8-10 hours.

Do not charge the battery for more than 20 hours to avoid

overheating the charger.

- It is normal for the charger to feel warm during charging. If the

charger feels very hot, stop charging, unplug the charger and check

the battery and charger.

- Use the charger in dry locations only.

- Regularly check the charger, battery and their connectors for

excessive wear or damage each time you charge the battery. If

damage or excessive wear is detected, do not use the charger or the

battery until you have replaced the worn or damaged part.

- Only use the charger specified by the manufacturer.

WARNING - Risk of fire. Do not by pass fuse. Replace only

with the correct amperage fuse.

BATTERY SAFETY WARNING:

- Only use the battery and charger supplied by the manufacturer.

- Do not connect the battery terminals directly together. This will cause

the battery to short-circuit.

- Never short-circuit the battery terminals or modify the electrical system.

Alterations may cause a fire resulting in serious injuries.

- Do not mix old and new batteries or batteries of different types.

- Remove batteries during long periods of non-use. Always remove

batteries from the product. Dispose of batteries safely. Do not dispose

of batteries in fires. The batteries may explode or leak.

- If removable, rechargeable batteries are used, they are only to be

charged under adult supervision.

- Recharge the battery fully before storage, then charge it every 3

months to extend the life of the battery.

- Only use the battery specified by the manufacturer.

The ride on vehicle is equipped with a built-in thermal circuit breaker.

The thermal circuit breaker is a self-resetting safety device which

automatically “trips” and shuts down the operation of the vehicle if it is

overloaded or the driving conditions are too severe. Once the circuit

breaker has tripped it will automatically reset itself after approximately

25 seconds and allow the rider to resume normal operation.

Caution:

Part List:

Part No. Description Qty

10.

Body with Wheels

Steering Wheel

TM5x25x8 Screw

M5 Nut

TA4X12X7 Screw

Spoiler

Spoiler Bracket

Charger

Audio Line

Screwdriver

1 set

1pc

1 pc

2pc

1pc

1pair

1pc

(Prefixed on steering column)

(Prefixed on the rear bumper)

(not included)

How to assemble the vehicle:

Step 1:

screwdriver(not included).

Spoiler Brackets properly.

Step 2:

3) and M5

Nut ( 4).

steering wheel column.

column and the hole on the base of

the steering wheel.

3) and M5

Nut ( 4), then tighten with screwdriver.

Unscrew the prefixed screw on the

back of the seat with a screwdriver.

Remove the seat, connect the loose

red wire plug to the terminal of the

breaker box.

Install the seat again.

Step 3:

WARNING:

To reduce the risk of injury, adult supervision

is required.

Never use on roadways, near motor vehicles,

on or near steep inclines or steps, swimming

pools or other bodies of water. Always wear

shoes and never allow more than 1 rider.

WARNING:

Contains small parts, sharp points and

sharp edges. Adult assembly required.

WARNING:

Choking Hazard! Contains small

parts. Not for children under 3 years old! WARNING:

This toy is unsuitable for children under

3 years due to its maximum speed.

WARNING:

Not to be used in traffic.

Charging the Battery:

The socket for charging the battery is

located near the seat.

Connect the charger plug into the DC jack,

then plug the charger into a household outlet.

charge more than 20 hours.

When the battery is fully charged, unplug the

charger and store it in a cool and dry place.

Operation of the Vehicle:

F/R Switch

MP3 Insert

Pedal Switch

Power Switch

Power Switch: Controls the vehicle

· Press the power switch when using the

vehicle.

· Release the power switch when not using

the vehicle.

1. Make sure the battery is fully charged and the

red plug is connected to the battery plug

under the seat.

2. Locate the direction switch to the right of the

steering wheel. Push the direction switch to

“F” and press the accelerator pedal, vehicle

will move forward. Headlights come on while

vehicle is moving forward.

3. To stop the vehicle remove foot from

accelerator pedal. When stopped pull the

direction switch to “B”, then press the

accelerator pedal, vehicle will move backward.

The taillight will come on while moving backward.

5. MP3 Plug-in: Plug in MP3 to play music.

4. Steering Wheel: Press the 4 buttons in

the middle for different driving sounds.

BOM List:

1. Bonnet/Hood

2. Radiator of front bumper

(middle)

3. Windscreen

4. Dashboard

5. Side bumper(left)

6. Body

7. Seat

8. Side bumper(right)

9. Side accessory

10. Steering wheel

11. Rearview mirror(left & right)

12. Front bumper support

13. Radiator

14. Head light receptacle

15. Head light

16. Front wheel

17. Wheel cover

18. Rear wheel

19. Side bumper adornment

20. Rear bumper support

21. Rear bumper accessory

22. Trunk lid

23. Rear bumper

24. Spoiler

25. Backrest

26. Spoiler Bracket (left & right)

27. Rear light receptacle

28. Rear light

29. Middle line lid

30. Charge lid

31. Exhaust pipe lid

32. Exhaust pipe

33. Radiator of rear bumper

Maintaining your vehicle:

It is a parents responsibility to check main parts of the vehicle before

use. Regularly examine the vehicle for potential hazards, such as the

battery, charge cable, cord and plug. Ensure screws are tightened. If

there are any damages, the vehicle must not be used until these

damages have been properly repaired or replaced.

Occasionally use a lightweight oil to lubricate moving parts such as

the wheels and steering linkages.

Keep the vehicle in an upturned position, do not overturn or incline it.

It is recommended to store the vehicle indoors when not in use. If

stored outdoors, the vehicle needs to be covered by a tarp for

protection against weather elements.

This toy should be kept away from fire. Keep the vehicle away from

sources of heat, such as stoves and heaters. Plastic parts may melt.

While charging ensure all flammable liquids are well away from the

vehicle.

ADULTS ONLY to recharge the battery after each use. Recharge the

battery at least once a month when the vehicle is not being used.

Use a soft, dry cloth to clean vehicle.

DO NOT use any chemical liquids to clean the plastic surface of the

vehicle.

DO NOT wash the vehicle with soap and water.

DO NOT drive the vehicle in rainy or snowy weather. Water will

damage the motor, electric system and battery.

When not in use all electrical sources should be turned off. Press the

power switch to the "OFF" position to turn the power off. Also

disconnect the battery connection under the seat.

Please do not change the structure of this product and circuit system.

DO NOT use the vehicle for other purposes except riding.

Safety Precautions:

1. While riding, adult supervision is required at all times.

2. Always wear a helmet when riding.

3. Do not ride near roads or on the footpath.

4. It is not recommended to drive the vehicle on wet surfaces or on

slopes greater than 15 degrees.

5. It is recommended to ride this vehicle on smooth surfaces only.

6. Do not use this vehicle outdoors when it is raining.

7. Make sure you come to a complete stop before changing directions

from forward to reverse.

8. Don't allow children to operate the charger or play with the battery.

9. Clean the vehicle with a dry cloth only.

10. Please follow the correct weight and age limits allowed to driver

this vehicle.

11. It is prohibited to change the circuit or add other electric parts.

12. Adults must teach their children about safe driving procedures.

13. Please turn the power off when not in use.

14. Check the seat to ensure it has been fitted and secured with a bolt

before driving.

15. Inspect all wires and connections of the vehicle perodically.

16. Charging the battery should only be done by adults.

17. Charging plug is located the bottom of the vehicle.

18. In order to avoid accidents, please ensure the vehicle is safe before

driving.

19. Do not let any child touch the wheels or be near them when the

vehicle is moving.

Trouble Shooting Tips:

Problem: The vehicle does not turn on

If the car is not functioning at all please follow these troubleshooting steps listed below.

After each step, please put the car in forward gear and step on the pedal to see if the

car will move.

1. Charger: Unplug the charger completely from the car. The car will not work if the

charger is plugged in to the car.

2. Battery Connection: There is a battery cover that goes over the battery to hide the

positive and negative wires. Undo the bar that holds the battery down to release the

cover. Once the cover is loose, check the positive and negative wire to see if they are

properly connected. You may also pull lightly on each wire to see if they are

connected.

3. F/R Switch: Us a Phillip screw driver and undo the screws that hold down Forward

and Reverse switch. Pull the switch out and you should see wires running into the back

of the switch. Use your hand and push each individual wires into the socket.

4. Foot Pedal Switch: Turn the car on its side, and you will see a foot pedal cover

where the foot pedal switch is. There should be 3 screws holding down that cover.

Once the cover is off you will see wires leading into the F/R switch. Use your hands to

push each individual wires into the switch and see if it runs.

Problem: The motor turns but the car is not moving

If you can hear the motor turning but the car is not moving or you hear a grinding sound

coming from the gearbox, please contact Kalee Customer Service Support.

Problem: The vehicle runs slowly:

If the car is not functioning at its normal speed, please recharge the battery for another 8 to 10

hours. If it does not resolve the issue, please contact Kalee Customer Service Support.

Customer Service:

Made in China

You can help protect the environment! Please

non-working electrical equipments to an appriate

Manufactured by:

Kalee Children’s Products Co., Ltd. Quanzhou

Wuli Industrial Zone, Jinjiang, Fujian, China

www.kalee.com

If you have any missing or damaged parts or need assembly assistance,

please contact our service center directly. Do not return this product to the retailer,

they do not stock replacement parts.

Support Website: http://support.bigtoysusa.com

Support Phone: 715-955-4237

Andere Kalee Golfwagen Handbücher

Kalee

Kalee KL-7001 Bedienungsanleitung

Beliebte Golfwagen Handbücher anderer Marken

Yamaha

Yamaha YDRA Betriebsanleitung

Club Car

Club Car Tourall 1989 Bedienungsanleitung

ACG

ACG 39Roadster eGC 2013 Bedienungsanleitung

MGI

MGI ZIP X3 Bedienungsanleitung

MGI

MGI ZIP X1 Bedienungsanleitung

GEM

GEM E580 Bedienungsanleitung

Yukon Trail

Yukon Trail solar wing 350 Bedienungsanleitung

Sunrise Medical

Sunrise Medical TROPHY 20 Bedienungsanleitung

Club Car

Club Car Carryall 300 2021 Handbuch

Club Car

Club Car 1995 Golf Car Handbuch

Textron

Textron EZGO RXV 2016 Bedienungsanleitung

Cushman

Cushman 623526-H Bedienungsanleitung

Atomic

Atomic COUPE & TRUCK Bedienungsanleitung

GARIA

GARIA Golf Car Bedienungsanleitung

Giggo

Giggo GT00100 Bedienungsanleitung

Peg-Perego

Peg-Perego FIAT 500 Bedienungsanleitung

Columbia ParCar

Columbia ParCar Summit Bedienungsanleitung

CRICKET MINI GOLF CARTS

CRICKET MINI GOLF CARTS RX5 Bedienungsanleitung