KEBCO C6 P34 PANEL Bedienungsanleitung

EMBEDDED IPCS

INSTRUCTIONS FOR USE | C6 P34 PANEL

Original manual

Document 20199071 EN 01

PREFACE

Preface

The described hard- and software are developments of the KEB Automation KG. The

enclosed documents correspond to conditions valid at printing. Misprint, mistakes and

technical changes reserved.

Signal words and symbols

Certain operations can cause hazards during the installation, operation or thereafter.

There are safety informations in the documentation in front of these operations. Security

signs are located on the device or machine. A warning contains signal words which are

explained in the following table:

DANGER Dangerous situation, which will cause death or serious injury in case of

non-observance of this safety instruction.

WARNING Dangerous situation, which may cause death or serious injury in case of

non-observance of this safety instruction.

CAUTION Dangerous situation, which may cause minor injury in case of non-ob-

servance of this safety instruction.

NOTICE Situation, which can cause damage to property in case of non-obser-

vance.

RESTRICTION

Is used when certain conditions must meet the validity of statements or the result is

limited to a certain validity range.

Is used when the result will be better, more economic or trouble-free by following

these procedures.

More symbols

► Thisarrowstartsanactionstep.

• / - Enumerations are marked with dots or indents.

=> Cross reference to another chapter or another page.

Note to further documentation.

www.keb.de/service/downloads

PREFACE

Laws and guidelines

KEB Automation KGconrmswiththeECdeclarationofconformityandtheCEmarkon

the device nameplate that it complies with the essential safety requirements.

The EC declaration of conformity can be downloaded on demand via our website. Fur-

therinformationisprovidedinchapter"Certication".

Warranty and liability

The warranty and liability on design, material or workmanship for the acquired device is

given in the general sales conditions.

Hereyouwillndourgeneralsalesconditions.

www.keb.de/terms-and-conditions

Furtheragreementsorspecicationsrequireawrittenconrmation.

Support

Through multiple applications not every imaginable case has been taken into ac-

count. If you require further information or if problems occur which are not treated de-

tailed in the documentation, you can request the necessary information via the local

KEB Automation KG agency.

The use of our units in the target products is outside of our control and therefore

lies exclusively in the area of responsibility of the customer.

Theinformationcontainedinthetechnicaldocumentation,aswellasanyuser-specic

advice in spoken and written and through tests, are made to best of our knowledge and

information about the intended use. However, they are regarded as being only informal

and changes are expressly reserved, in particular due to technical changes. This also

applies to any violation of industrial property rights of a third-party. Selection of our units

in view of their suitability for the intended use must be done generally by the user.

Tests can only be done within the intended end use of the product (application) by

the customer. They must be repeated, even if only parts of hardware, software or

the unit adjustment are modied.

The customer may use the instructions for use as well as further documents or parts

from it for internal purposes. Copyrights are with KEB Automation KG and remain valid

in its entirety.

This KEB product or parts thereof may contain third-party software, including free and/

or open source software. If applicable, the license terms of this software are contained

in the instructions for use. The instructions for use are already available to you, can be

downloaded free of charge from the KEB website or can be requested from the respec-

tive KEB contact person.

Other wordmarks or/and logos are trademarks (™) or registered trademarks (®) of their

respective owners.

TABLE OF CONTENTS

Table of Contents

Preface ....................................................................................................................................................3

Signal words and symbols .............................................................................................................3

More symbols.................................................................................................................................3

Laws and guidelines.......................................................................................................................4

Warranty and liability......................................................................................................................4

Support ........................................................................................................................................4

Copyright........................................................................................................................................4

Table of Contents ...................................................................................................................................5

List of Figures.........................................................................................................................................9

List of Tables ........................................................................................................................................12

Glossary ................................................................................................................................................13

Standards for control & automation...................................................................................................14

1 Basic Safety Instructions............................................ 16

1.1 Target Group ..................................................................................................................................16

1.2 Transport, storage and proper use .............................................................................................. 17

1.3 Installation......................................................................................................................................17

1.4 Electrical connection ....................................................................................................................18

1.5 Start-up and operation ..................................................................................................................18

1.6 Maintenance...................................................................................................................................18

1.8 Repair .............................................................................................................................................19

1.7 Disposal..........................................................................................................................................19

2 System Description ..................................................... 20

2.1 Key features ...................................................................................................................................20

2.2 Supported Operating Systems.....................................................................................................20

2.3 KEB Standards ..............................................................................................................................20

2.3.1 Front Panel in different variants .........................................................................................21

2.3.1.1 Power supply with galvanic isolation...............................................................................21

2.3.1.2 Key system identity .........................................................................................................22

2.3.2 Fanless...............................................................................................................................22

2.3.3 LCD LED backlight.............................................................................................................22

2.3.4 Mass Storage .....................................................................................................................22

2.3.5 Extension slot & add-on .....................................................................................................22

2.4 Package ..........................................................................................................................................23

2.5 Front panels ...................................................................................................................................24

2.6 Resistive front panel .....................................................................................................................24

2.6.1 Capacitive front panel.........................................................................................................26

2.6.2 Front USB 2.0.....................................................................................................................28

2.6.3 Opening the cover..............................................................................................................28

2.6.4 LCD aspect ratio.................................................................................................................29

2.7 Rear panel areas............................................................................................................................ 30

TABLE OF CONTENTS

2.7.1 Power supply area..............................................................................................................31

2.7.2 Buttons / LEDs area ...........................................................................................................32

2.7.3 Connectors area.................................................................................................................33

2.7.4 Extension area ...................................................................................................................34

2.7.5 RVL / LAN area ..................................................................................................................34

2.7.6 Micro-UPS..........................................................................................................................35

2.7.7 KEB Version..................................................................................................................36

2.7.7.1 Marking label...................................................................................................................36

2.7.7.2 Connectors label .............................................................................................................37

2.8 Rear view........................................................................................................................................ 37

2.9 Side view ........................................................................................................................................38

2.10 Touchscreen ................................................................................................................................38

2.10.1 Standard tecnology ..........................................................................................................38

2.10.2 Multi Touch tecnology.......................................................................................................39

3 Installation and connection ........................................ 40

3.1 Preparation for installation...........................................................................................................40

3.1.1 Select the mounting location ..............................................................................................40

3.2 Checking the package contents...................................................................................................40

3.3 Checking the operating conditions ............................................................................................. 40

3.4 Mounting position .........................................................................................................................40

3.5 Damage due to overheating .........................................................................................................41

3.6 Checking installation distances................................................................................................... 42

3.7 Preparing the mounting cut-out...................................................................................................43

3.7.1 Degrees of protection........................................................................................................43

3.8 Dimensions ....................................................................................................................................44

3.8.1 C6 P34 Panel resistive.......................................................................................................44

3.9 Mounting the divece (Panel version) ...........................................................................................45

3.9.1 Position of the mounting clamps ........................................................................................45

3.9.2 Tools to tighten the mounting clamps .................................................................................46

3.9.3 Prodecure...........................................................................................................................46

3.9.4 Grounding and bonding......................................................................................................47

3.9.5 Power supply insolation......................................................................................................49

3.9.6 Power supply connection ...................................................................................................49

3.9.7 Power connector assembly ................................................................................................50

3.9.8 Power on ............................................................................................................................52

3.9.8.1 Power Supply LED ..........................................................................................................54

3.9.8.2 Front On / Off / Standby - Rear On / Off / Standby LED .................................................54

3.9.8.3 Front On / Off / Standby - Rear On / Off / Standby LED .................................................54

4 Operating Systems...................................................... 55

4.1 KEB Windows Images (Windows Embedded Standard 7 / Windows 10).................................55

4.1.1 Introduction.........................................................................................................................55

TABLE OF CONTENTS

4.1.2 User Accounts ....................................................................................................................55

4.1.3 Ethernet Address................................................................................................................55

4.1.4 Usage of storage memories ...............................................................................................56

4.1.5 Firewall...............................................................................................................................57

4.1.6 eGalax Touch Driver...........................................................................................................58

4.2 Windows Updates..........................................................................................................................59

4.3 EWF implementation in the Windows Embedded Standard 7 images .....................................60

4.4 KEB Write Filter Manager (KEB-WF_MGR) .................................................................................60

4.4.1 Introduction.........................................................................................................................60

4.4.2 How EWF works.................................................................................................................61

4.4.3 Protectable Volumes ..........................................................................................................61

4.4.4 KEBEWFconguration......................................................................................................61

4.4.5 Delivery state of EWF on KEB devices ..............................................................................62

4.4.6 Using KEB_WF_Mgr ..........................................................................................................62

4.4.7 Dependent Volumes (typically E:\) .....................................................................................64

4.4.8 Leave the KEB_WF_Mgr....................................................................................................65

4.5 KEB UWF Manager ........................................................................................................................66

4.5.1 Introduction.........................................................................................................................66

4.5.2 Functioning of the UWF .....................................................................................................66

4.5.3 KEBUWFCongurationandusage...................................................................................66

4.6 KEB Linux Image ...........................................................................................................................68

4.6.1 Introduction.........................................................................................................................68

4.6.2 Service User Accounts ......................................................................................................68

4.6.3 Change password for service user.....................................................................................69

4.6.4 Ethernet IP Address ...........................................................................................................70

4.6.5 Usage of storage memories ...............................................................................................70

4.7 Common (Windows and Linux)....................................................................................................71

4.7.1 Micro-UPS Handling...........................................................................................................71

4.7.2 Ip-Scan...............................................................................................................................72

4.7.3 Serial interface ...................................................................................................................73

5 Mass Storage & Expansions....................................... 74

5.1 Mass storage..................................................................................................................................74

5.1.1 CFast..................................................................................................................................74

5.1.2 SSD mSATA .......................................................................................................................75

6 Maintenance and service ............................................ 76

6.1 Removing the rear cover ..............................................................................................................76

6.2 Backup battery replacement (CR2032 3V) ..................................................................................77

6.3 RAM installation / removal............................................................................................................78

6.4 CFast installation / removal.......................................................................................................... 79

6.4.1 Installation ..........................................................................................................................79

6.4.2 Removal .............................................................................................................................80

TABLE OF CONTENTS

6.5 Touchscreen ..................................................................................................................................81

6.5.1 Identicationoftheinstalledtouchscreen ..........................................................................81

6.5.2 Settings for a system with a resistive touchscreen.............................................................81

6.5.3 Setting of a system with capacitive touchscreen................................................................82

6.5.4 Touchscreen Application Tips .............................................................................................82

6.5.4.1 Use large buttons and a simple interface .......................................................................82

6.5.4.2 Give the user feedback as soon as the screen is touched..............................................83

6.5.4.3 Turn the cursor off ...........................................................................................................83

6.5.4.4 Run your application full screen ......................................................................................83

6.5.4.5 Avoid using a black background......................................................................................83

6.6 Maintaining & cleaning .................................................................................................................83

6.6.1 Procedure...........................................................................................................................83

6.7 Recycling and disposal.................................................................................................................83

7 Technical specications ............................................. 84

7.1 Block Diagram ...............................................................................................................................84

7.1.1 LCD characteristics ............................................................................................................85

7.1.2 C6 P34 PANEL resistive technical data..............................................................................87

7.1.3 C6 P34 PANEL capacitive technical data...........................................................................88

7.1.4 Technicalspecications......................................................................................................89

7.2 Power consumption ......................................................................................................................90

7.2.1 Power supply technical data...............................................................................................90

7.2.2 Battery technical data.........................................................................................................90

7.2.3 Dimension Drawings ..........................................................................................................91

7.3 Technical support and repairs .....................................................................................................92

8 Certication.................................................................. 93

8.1 Mark of conformity ........................................................................................................................93

8.2 UL certications ............................................................................................................................95

9 Change history............................................................. 96

LIST OF FIGURES

List of Figures

Figure 1: Cut out .............................................................................................................................21

Figure 2: Isolated Power Supply .....................................................................................................21

Figure 3: Non-volatile memory........................................................................................................22

Figure 4: Mass storage ...................................................................................................................22

Figure 5: Add-on .............................................................................................................................23

Figure 6: Package...........................................................................................................................23

Figure 7: Full aluminium front panel detail ......................................................................................24

Figure 8: Capacitive front panel detail.............................................................................................24

Figure9: Fullaluminiumfrontpaneldetail(inthegureisshownasanexamplea15.0”display) 25

Figure 10: Front panel „Step“ detail ..................................................................................................25

Figure 11: Construction detail ...........................................................................................................26

Figure12: Detailsfrontpanelcapacitive-(inthegureisshownasanexapmplea15.6“display).26

Figure 13: Capacitive front panel „No step“ detail.............................................................................27

Figure 14: Features front panel capacitive........................................................................................27

Figure 15: Construction detail ...........................................................................................................27

Figure 16: Fontal USB detail.............................................................................................................28

Figure 17: Fontal USB detail ............................................................................................................28

Figure 18: 4:3 aspect ratio example..................................................................................................29

Figure 19: 5:4 aspect ratio example..................................................................................................29

Figure 20: 16:9 aspect ratio example................................................................................................29

Figure 21: 16:10 (Wide) aspect ratio example ..................................................................................30

Figure 22: Rear panel areas .............................................................................................................30

Figure 23: Power supply area ...........................................................................................................31

Figure 24: DC power supply detail....................................................................................................31

Figure 25: Buttons / LEDs area.........................................................................................................32

Figure 26: Buttons / LEDs area detail ...............................................................................................32

Figure 27: Connectors area ..............................................................................................................33

Figure 28: Connectors area detail ....................................................................................................33

Figure 29: Extension area.................................................................................................................34

Figure 30: RVL/LAN area..................................................................................................................34

Figure 31: Label positions detail .......................................................................................................36

Figure 32: Marking label detail..........................................................................................................36

Figure 33: Connectors label..............................................................................................................37

Figure 34: Rear view.........................................................................................................................37

Figure 35: Side view..........................................................................................................................38

Figure 36: Standard tecnology..........................................................................................................38

Figure 37: Capacitive front panel detail.............................................................................................39

Figure 38: Installation Panel distances .............................................................................................42

Figure 39: Installation Panel distances .............................................................................................42

Figure 40: Inclined Installation .........................................................................................................43

Figure 41: C6 P34 Panel resistive dimensions .................................................................................44

Figure 42: C6 P34 Panel capacitive dimensions...............................................................................44

Figure 43: Installation........................................................................................................................46

LIST OF FIGURES

Figure 44: Installation........................................................................................................................46

Figure 45: Installation........................................................................................................................47

Figure 46: Hex key detail ..................................................................................................................47

Figure 47: Installation........................................................................................................................47

Figure 48: Power supply diagram .....................................................................................................48

Figure 49: Grounding ........................................................................................................................48

Figure 50: Power supply connection detail .......................................................................................49

Figure 51: C6 P34 Panel DC detail...................................................................................................50

Figure 52: Power connector assembly..............................................................................................50

Figure 53: Power connector assembly..............................................................................................50

Figure 54: Power connector assembly..............................................................................................50

Figure 55: Power connector assembly..............................................................................................51

Figure 56: Power connector installation............................................................................................51

Figure 57: Power connector installation............................................................................................51

Figure 58: Power connector installation............................................................................................51

Figure 59: Power connector assembly..............................................................................................52

Figure 60: Power on DC....................................................................................................................52

Figure 61: Power on DC....................................................................................................................53

Figure 62: Power on DC....................................................................................................................53

Figure 63: CFast detail......................................................................................................................74

Figure 64: Slot for CFast...................................................................................................................74

Figure 65: CFast ...............................................................................................................................74

Figure 66: SSD detail........................................................................................................................75

Figure 67: SSD mSATA.....................................................................................................................75

Figure 68: Removing the rear cover..................................................................................................76

Figure 69: Removing the rear cover..................................................................................................76

Figure 70: Battery replacement.........................................................................................................77

Figure 71: Battery replacement.........................................................................................................77

Figure 72: Installation / removal RAM...............................................................................................78

Figure 73: Installation / removal RAM...............................................................................................78

Figure 74: Installation / removal RAM...............................................................................................78

Figure 75: CFast Slot detail...............................................................................................................79

Figure 76: CFast installation .............................................................................................................79

Figure 77: CFast removal..................................................................................................................80

Figure 78: CFast removal..................................................................................................................80

Figure 79: Calibration of the touchscreen .........................................................................................81

Figure 80: Calibration of the touchscreen .........................................................................................82

Figure 81: Calibration of the touchscreen .........................................................................................82

Figure 82: Block diagram ..................................................................................................................84

Figure 83: C6 P34 PANEL Technical data.........................................................................................87

Figure 84: C6 P34 PANEL Technical data.........................................................................................88

Figure85: C6P34PANELcapacitivetechnicalspecications..........................................................89

Figure 86: Power supply board .........................................................................................................90

Figure 87: Battery CR2032 detail......................................................................................................90

Figure 88: Battery performance ........................................................................................................91

Inhaltsverzeichnis

Andere KEBCO Touchscreen Handbücher

KEBCO

KEBCO C6 E22 BM-RVL Bedienungsanleitung

Beliebte Touchscreen Handbücher anderer Marken

FlowLine

FlowLine Data loop Bedienungsanleitung

ALPEX

ALPEX AEx-8 P Series Bedienungsanleitung

Ltech

Ltech E5S Bedienungsanleitung

Harman

Harman AMX MODERO S MSD-701-L2 Bedienungsanleitung

Acnodes

Acnodes PC 1150 Bedienungsanleitung

AIS

AIS IP10IA99 series Bedienungsanleitung

IBASE Technology

IBASE Technology ASTUT-152-RE1S Bedienungsanleitung

YASKAWA

YASKAWA TP 610C Bedienungsanleitung

B&R

B&R Power Panel C Series Bedienungsanleitung

Beijer Electronics

Beijer Electronics X2 control Bedienungsanleitung

AXIOMTEK

AXIOMTEK GOT321W-521 Bedienungsanleitung

TRIDONIC.ATCO

TRIDONIC.ATCO x-touchBOX Bedienungsanleitung

Qomo

Qomo QIT1386 Bedienungsanleitung

DFI

DFI KS104-CD Bedienungsanleitung

AMX

AMX AXP-PPC Leitfaden

Sartorius

Sartorius X3 PR 5410 Bedienungsanleitung

AMX

AMX Modero X Series Bedienungsanleitung

Advantech

Advantech TPC-30 Series Bedienungsanleitung