Kioti DK90 Bedienungsanleitung
Congratulations, and welcome to the fabulous world of DK90 ownership, where serious work is made fun
again!
This versatile tractor is a culmination of the entire tractor and diesel knowledge gained by the Daedong Indus-
trial Co.,LTD since 1947. It has been designed with the finest materials and under rigid quality control standards
set forth by the KIOTI Engineering Department.
Knowledge of tractor operation is essential for dependable service and reliability. To help new owner's familiar-
ize themselves with the KIOTI DK90, it is the policy of KIOTI tractor to provide an owner's manual which
includes helpful information about tractor safety, operation and maintenance. If the information you seek is not
found in this manual, your KIOTI tractor dealer will be happy to help you.
Please feel free to contact KIOTI with your questions/concerns.
FOREWORD
This manual includes information titled as WARNING, CAUTION, IMPORTANT
and NOTE. These titles indicate the following:
SAFETY AND VEHICLE DAMAGE WARNING
NOTE
This indicates that interesting or helpful information is being
provided.
CAUTION
!!
!!
!This indicates a situation that could result in damage to your
vehicle or its equipment if the caution is not heeded. Follow the
advice provided with the caution.
WARNING
This indicates a situation that could result in harm, serious in-
juryordeath toyouor otherpersonsif thewarningis not heeded.
Follow the advice provided with the warning.
!!
!!
!
Thismark indicates emphasison notablecharacteristics of work-
ing procedures, and information on about technology for easier
operation.
IMPORTANT
ABBREVIATION LIST
ABBREVIATIONS
4WD
API
ASAE
ASTM
fpm
Hi-Lo
HST
m/s
P.T.O
RH/LH
ROPS
m-1 (rpm)
S-1 (r/s)
SAE
SMV
DEFINITIONS
Four Wheel Drive
American Petroleum Institute
American Society of Agricultural Engineers, USA
American Society of Testing and Materials, USA
Feet Per Minute
High Speed-Low Speed
Hydrostatic Transmission
Meters Per Second
Power Take Off
Right-hand and Left-hand sides are determined by facing in the direction of forward travel
Roll-Over Protective Structures
Revolutions Per Minute
Revolutions Per Second
Society of Automotive Engineers, USA
Slow Moving Vehicle
Various universal symbols have been used on the instruments and controls of your KIOTI tractor. Below is a list
of the universal symbols and their meanings.
UNIVERSAL SYMBOLS
Fuel-level
Engine coolant-temperature
Parking brake
Battery charging condition
Engine oil-pressure
Turn signal
Power take-off clutch control-off
position
Power take-off clutch control-on
position
Differential lock
Position control-lowered position
Hazard warning lights
Headlight-low beam
Headlight-high beam
Four-wheel drive-on
Fast
Slow
Creep
High range
Middle range
Low range
Neutral position
Coolant
N
H
L
Preheat
QT lamp
H:High travel light
L:Low travel light
Auto draft work light
Auto level work light
Auto tilling depth work light
Turn up light
Back up light
Auto switch
Single brake light
SAFETY PRECAUTIONS..............................................
SERVICING OF TRACTOR .........................................
SPECIFICATIONS.........................................................
DESCRIPTION OF OPERATING SYSTEM ..............
OPERATION...................................................................
MAINTENANCE .............................................................
STORAGE.......................................................................
TROUBLESHOOTING ..................................................
INDEX ..............................................................................
TABLE OF CONTENTS
SECTION
1
2
3
4
5
6
7
8
9
1
BEFORE OPERATING THE TRACTOR .................... 1-2
OPERATING THE TRACTOR..................................... 1-5
DRIVING THE TRACTOR ........................................... 1-8
PARKING THE TRACTOR .......................................... 1-9
OPERATING THE P.T.O ........................................... 1-10
USING 3-POINT HITCH ............................................ 1-10
SERVICING THE TRACTOR .................................... 1-11
TRACTOR SAFETY LABELS ................................... 1-14
SAFETY PRECAUTIONS
1
DK90
1
-2
A careful operator is the best operator.
Most accidents can be avoided by ob-
serving certain precautions.To help pre-
vent accidents, use these safety
precautions, and pay attention to the
job at hand. If you can prevent an
accident, your time will have been well
spent.
BEFORE OPERATING THE
TRACTOR
5. Keep safety decals free of dirt and
debris.
6. Watch where you are going at all
times so that you are able to avoid
obstacles that can cause injury or
damage to your tractor.
7. When starting the tractor make sure
your path is clear of people to avoid
accidents caused by sudden
movements.
8. Before backing up your tractor, you
should always check to see that the
path is clear.
1. It is recommended that you read and
understand this entire manual before
operation of your new tractor. Fail-
ure to do so could result in accidents
or injury.
2. Only persons who are properly
trained should be allowed to operate
the tractor.
3. Read and follow all warning labels
and decals affixed to the tractor.
4. Replace any missing or damaged
decals as soon as it is practical. A
list of decals is shown on page1-
14~16.
S43O101A S43O102A
1
-3
SAFETY PRECAUTIONS
16. All persons using the tractor should
have knowledge of its proper op-
eration and should read this manual
carefully.
17. Never get off the tractor without set-
ting the parking brake, lowering the
implement to the ground and shut-
ting down the tractor.
18. No alterations should be made to
your KIOTItractor without first con-
sulting your KIOTI dealer.
12. Never start the engine while stand-
ing on the ground.
13. Only the operator should ride on the
tractor unless a passenger seat is
installed. Keep bystanders away
from the tractor while in operation.
14. When getting on and off the tractor,
handholds and step plates should
always be used. This will help to
prevent accidental slips trips and
falls.
15. Be sure to scrape off mud or soil
from your shoes before mounting
the tractor.
S43O103A S43O104A S43O105A
9. Never operate this tractor or any
other agricultural equipment while
under the influence of alcohol,
drugs or while fatigued.
10. While working in cooperation with
other tractors always communicate
your intentions.
11. Do not start your tractor by short-
ing across the starter.
DK90
1
-4
A ROPS and CAB should never be
modified by welding, grinding or cutting,
as this can weaken the ROPS
structure. If any components of the
ROPS unit is damaged, it must be
replaced.
If the ROPS unit is removed or loos-
ened for any reason, the parts should
be fitted back to their original positions
and all bolts should be properly torqued.
Always use seat belt when the trac-
tor is equipped with a ROPS and
CAB. All tractors in U.S. must
have CAB or ROPS.
21. Extra caution should be taken when
driving tractors with narrow tread
widths. For added stability you
should adjust your rear wheel tread
width, see page 8-3.
19. Before starting your tractor you
should depress the clutch and
make sure that all shift levers are
in the neutral position.
20. For your safety ROPS with a seat
belt is recommended for most
applications.
(1) Tread
S43O106A S43O107A
NOTE
1
-5
SAFETY PRECAUTIONS
1. Avoid accidental contact with gear
shift levers while the engine is
running. Unexpected tractor move-
ments can result in bodily injury.
2. Do not park your tractor on a steep
incline, and remember to shut off the
engine and P.T.O before dismount-
ing the tractor.
OPERATING THE TRACTOR
3. Do not operate your tractor in an en-
closed building without the proper
ventilation. Exhaust fumes can
cause serious injury or death.
S43O109A
S43O108A S43O110A
Inhaltsverzeichnis
Andere Kioti Traktor Handbücher
Kioti
Kioti DK55 Bedienungsanleitung
Kioti
Kioti US Bedienungsanleitung
Kioti
Kioti NX4520 Bedienungsanleitung
Kioti
Kioti KL135 Bedienungsanleitung
Kioti
Kioti DK4810 Bedienungsanleitung
Kioti
Kioti CK3510 Bedienungsanleitung
Kioti
Kioti CS2610 Bedienungsanleitung
Kioti
Kioti KL155 Bedienungsanleitung
Kioti
Kioti PX Series Bedienungsanleitung
Kioti
Kioti DK65 Bedienungsanleitung
Kioti
Kioti CK2810 Bedienungsanleitung
Kioti
Kioti RX6010C Bedienungsanleitung
Kioti
Kioti DK6010 Bedienungsanleitung
Kioti
Kioti DK50 Bedienungsanleitung
Kioti
Kioti DK Series Bedienungsanleitung
Kioti
Kioti DK 802 Bedienungsanleitung
Kioti
Kioti NX4510 Bedienungsanleitung
Kioti
Kioti CS2220H Bedienungsanleitung
Kioti
Kioti EX35 Bedienungsanleitung
Kioti
Kioti RX6030 Bedienungsanleitung
