Kioti EX35 Bedienungsanleitung
Congratulations, and welcome to the fabulous world of EX35/40/45/50 ownership, where serious work is made
fun again!
This versatile tractor is a culmination of the entire tractor and diesel knowledge gained by the Daedong Indus-
trial Co.,LTD over the years since 1947 and has been designed with the finest materials and under rigid quality
control standards set forth by the KIOTI Engineering Department.
Knowledge of tractor operation is essential for many years of dependable service and reliability. To help new
owner's familiarize themselves with the KIOTI EX35/40/45/50, it is the policy of KIOTI tractor to provide an
owner's manual which includes helpful information about tractor safety, operation and maintenance. If the infor-
mation you seek is not found in this manual, your KIOTI tractor dealer will be happy to help you.
Please feel free to contact DAEDONG IND. CO.,LTD with your questions/concerns.
FOREWORD
This manual includes information titled as WARNING, CAUTION, IMPORTANT
and NOTE. These titles indicate the following:
SAFETY AND VEHICLE DAMAGE WARNING
NOTE
This indicates that interesting or helpful information is being
provided.
CAUTION
!!
!!
!This indicates that a condition may result in damage to your
vehicle or its equipment if the caution is not heeded. Follow the
advice provided with the caution.
WARNING
This indicates that a condition may result in harm, serious injury
or death to you or other persons if the warning is not heeded.
Follow the advice provided with the warning.
!!
!!
!
Thismarkindicatesemphasisonnotablecharacteristicsofwork-
ing procedures, and information about technology for easier
operation.
IMPORTANT
ABBREVIATION LIST
ABBREVIATIONS
4WD
API
ASAE
ASTM
fpm
Hi-Mid-Lo
HST
m/s
PTO
RH/LH
ROPS
m-1 (rpm)
S-1 (r/s)
SAE
SMV
DEFINITIONS
Four Wheel Drive
American Petroleum Institute
American Society of Agricultural Engineers, USA
American Society of Testing and Materials, USA
Feet Per Minute
High Speed-Middle Speed-Low Speed
Hydrostatic Transmission
Meters Per Second
Power Take Off
Right-hand and Left-hand sides are determined by facing in the direction of forward travel
Roll-Over Protective Structures
Revolutions Per Minute
Revolutions Per Second
Society of Automotive Engineers, USA
Slow Moving Vehicle
Various universal symbols have been used on the instruments and controls of your KIOTI tractor. Below is a list
of the universal symbols and their meanings.
UNIVERSAL SYMBOLS
Fuel-Level
Engine Coolant-Temperature
Parking Brake
Battery Charging Condition
Engine Oil-Pressure
Turn Signal
Power Take-Off Clutch Control-
ON Position
Power Take-Off Clutch Control-
OFF Position
Differential Lock
Position Control-Lowered Position
Hazard Warning Lights
Headlight-Low Beam
Headlight-High Beam
Four-Wheel Drive-ON
Fast
Slow
Creep
High Range
Middle Range
H
L
Low Range
Coolant
Preheat
QT lamp
H:High speed travel light
M:Middle speed travel light
L:Low speed travel light
Neutral Position
Single brake light
M
N
SAFETY PRECAUTIONS .............................................
SERVICING OF TRACTOR .........................................
SPECIFICATIONS.........................................................
DESCRIPTION OF OPERATING SYSTEM ..............
OPERATION...................................................................
THREE-POINT HITCH & DRAWBAR........................
HYDRAULIC UNIT ........................................................
TIRES, TREAD AND BALLAST .................................
MAINTENANCE .............................................................
PERIODIC SERVICE ....................................................
STORAGE.......................................................................
TROUBLESHOOTING ..................................................
OPTIONS ........................................................................
INDEX ..............................................................................
TABLE OF CONTENTS
SECTION
1
2
3
4
5
6
7
8
9
10
11
12
13
14
1
BEFORE OPERATING THE TRACTOR .................... 1-2
OPERATING THE TRACTOR .................................... 1-5
DRIVING THE TRACTOR ........................................... 1-8
PARKING THE TRACTOR ......................................... 1-9
OPERATING THE PTO ............................................. 1-10
USING 3-POINT HITCH............................................. 1-10
SERVICING THE TRACTOR .................................... 1-11
TRACTOR SAFETY LABELS................................... 1-14
SAFETY PRECAUTIONS
EX35/40/45/50
1
-2
A careful operator is the best operator.
Most accidents can be avoided by ob-
serving certain precautions.To help pre-
vent accidents, use these safety
precautions, and pay attention to the
job at hand. If you can prevent an
accident, your time will have been well
spent.
BEFORE OPERATING THE
TRACTOR
5. Keep safety decals clean of dirt and
debris.
6. Watch where you are going at all
times so that you are able to avoid
obstacles that can cause injury or
damage to your tractor.
7. When starting the tractor make sure
your path is clear of people to avoid
accidents caused by sudden
movements.
8. Before making reverse movements
with your tractor, you should always
check to see that the path is clear.
1. It is recommended that you read and
understand this entire manual before
operation of your new tractor. Fail-
ure to do so could result in accidents
or injury.
2. Only persons who are properly
trained should be allowed to operate
the tractor.
3. Read and follow all warning labels
and decals affixed to the tractor.
4. Replace any missing or damaged
decals as soon as it is practical. A
list of decals is shown on page1-
14~16.
T46O101A T46O102A
1
-3
SAFETY PRECAUTIONS
16. All persons using the tractor should
have knowledge of its proper op-
eration and should read this manual
carefully.
17. Never get off the tractor without set-
ting the parking brake, lowering the
implement to the ground and shut-
ting of the tractor.
18. No alterations should be made to
your KIOTI tractor.
12. Never start the engine while stand-
ing on the ground.
13. Only the operator should ride on the
tractor unless a passenger seat is
installed. Keep bystanders away
from the tractor while in operation.
14. When getting on and off the tractor,
handholds and step plates should
always be used. This will help to
prevent accidental slips trips and
falls.
15. Be sure to scrape off mud or soil
from your shoes before mounting
the tractor.
T46O103A T46O104A T46O105A
9. Never operate this tractor or any
other agricultural equipment while
under the influence of alcohol,
drugs or while fatigued.
10. While working in cooperation with
other tractors always communicate
your intentions.
11. Do not start your tractor by short-
ing across the starter.
EX35/40/45/50
1
-4
21. Extra caution should be taken when
driving tractors with narrow tread
widths. For added stability you
should adjust your rear wheel tread
width, see page 8-4.
19. Before starting your tractor you
should depress the clutch and
make sure that all shift levers are
in the neutral position and parking
brake is applied.
20. For your safety ROPS with a seat
belt is recommended for all
applications.
(1) Tread
T46O106A T46O107A
A ROPS should never be modified by
welding, grinding or cutting, as this
can weaken the ROPS structure. If any
components of the ROPS unit is
damaged, it must be replaced.
If the ROPS unit is removed or loos-
ened for any reason, the parts should
be fitted back to their original positions
and all bolts should be properly
torqued.
Always use seat belt when the
tractor is equipped with a ROPS.
Never use the seat belt when trac-
tor is not equipped with a ROPS.
NOTE
1
-5
SAFETY PRECAUTIONS
1. Avoid accidental contact with gear
shift levers while the engine is
running. Unexpected tractor move-
ments can result in bodily injury.
2. Do not park your tractor on a steep
incline, and remember to shut off the
engine and PTO before dismount-
ing the tractor.
OPERATING THE TRACTOR
T46O109A
T46O108A T46O110A
3. Do not operate your tractor in an en-
closed building without the proper
ventilation. Exhaust fumes contain
carbon monoxide and may cause
series injury or death.
Andere Handbücher für EX35
1
Dieses Handbuch passt für folgende Modelle
3
Inhaltsverzeichnis
Andere Kioti Traktor Handbücher
Kioti
Kioti CH20 Gebrauchsanweisung
Kioti
Kioti CK2810 Bedienungsanleitung
Kioti
Kioti L3503 Bedienungsanleitung
Kioti
Kioti LK30 Bedienungsanleitung
Kioti
Kioti DK50 Bedienungsanleitung
Kioti
Kioti PX Series Bedienungsanleitung
Kioti
Kioti DK6010 Bedienungsanleitung
Kioti
Kioti RX6010C Bedienungsanleitung
Kioti
Kioti DK4810 Bedienungsanleitung
Kioti
Kioti DK90 Bedienungsanleitung
Kioti
Kioti CK25 Bedienungsanleitung
Kioti
Kioti DS3510 Bedienungsanleitung
Kioti
Kioti DS4110 Bedienungsanleitung
Kioti
Kioti DK6010 Bedienungsanleitung
Kioti
Kioti CK25 Bedienungsanleitung
Kioti
Kioti DK Series Bedienungsanleitung
Kioti
Kioti DK35 Bedienungsanleitung
Kioti
Kioti NX4510 Bedienungsanleitung
Kioti
Kioti KL155 Bedienungsanleitung
Kioti
Kioti CS2610 Bedienungsanleitung
