Lefroy Brooks M2-4403 Montageanleitung

INSTALLATION, OPERATING & MAINTENANCE INSTRUCTIONS

M2-4403

FLEETWOOD CROSS HANDLE THERMOSTATIC WITH TWO LEVER FLOW CONTROLS

TRIM ONLY, TO SUIT M1-4202 ROUGH

Contents

Dimensions 3

InstalLation Procedure 4

Parts List 7

Fault Finder 8

Safety Tips, Care and Maintenance 9

Guarantee 10

5 11/16"

(145mm)

9 1/16"

(230mm)

2 3/16"

(55mm)

1 5/8"

(42mm)

3 1/8"

(80mm)

2 11/16"

(68mm)

3/16"

(5mm)

Ø3"

(Ø76mm)

Ø1 1/4"

(Ø31.7mm)

1 9/16"~2 15/16"

(40mm~80mm)

1 7/16"

(36mm)

2 15/16"

(75mm)

W3/16-24

Dimensions in Inches (& Millimetres)

Whilst every effort is made to ensure accuracy, design and dimensions are subject to change without

notice as part of the company’s product development process.

1 2

Wall surface

3 1/8~4 1/8”

(80mm~105mm)

Diameter 45mm~50mm

136mm~140mm

Diameter 45mm~50mm

67mm67mm

90mm~105mm

40mm~50mm

Outlet

Cold supply

Hot supply

Steps 1-4

InstallationProcedure

Lefroy Brooks always recommends that plumbing products be installed by a licensed professional.

Shut off main water supply before installation.

1Before installing the valve into the wall, please note that a distance between 80mm~105mm

from the wall surface to the rear of the valve should be left so that the trim can be ﬁtted

correctly.

2Install valve assembly into the wall.

3Cut a hole in the wall surface for ﬁtting the trim kit. The hole dimension is as shown in ﬁgure 3.

4Throw away the protective caps only when building construction is completed and you are ready

to ﬁt the trim kit in.

REMOVE CAP ONLY, KEEP THE REST OF THE MUD GUARD AS IT IS NEEDED TO HOLD THE TRIM

FIXING SCREWS.

5 6

7 8

InstallationProcedure

Lefroy Brooks always recommends that plumbing products be installed by a licensed professional.

Shut off main water supply before installation.

5Take out the stopper.

6Turn on the ﬂow controller. Turn the thermostatic cartridge until the water temperature is at 38.

Suggestion: attach a hose to the outlet and guide water to basin or a receiver to get the

temperature and prevent it from wetting the ﬂoor.

7Turn off the water supply. Install the stopper and make sure its “B” plane as shown is horizontal

and on the left side.

8Fix the stem extension and the adjusting ring.

Steps 5-8

11 12

InstallationProcedure

Lefroy Brooks always recommends that plumbing products be installed by a licensed professional.

Shut off main water supply before installation.

9Install the canopies.

10 Fix the front plate with screws.

11 Fix the canopy with screw. When it is ﬁxed, check that the temperature-limit-button is in the

horizontal position.

12 Install handle assembly with set screws.

Steps 9-12

1 Set screw (292598)

2 Handle (029686)

3 Screw (008196)

4 Clip (012242)

5 Spindle (110386)

6 Canopy (018960)

7 Front panel (006228)

8 Seal (013152)

9 Handle (029685-51)

10 Screw (008994)

11 Button (036272)

12 Spring (005157)

13 Adaptor (067960)

14 Pin (003147)

15 Canopy (018959-52)

16 Set screw (065086)

17 Adjusting ring (104295)

18 Screw (008186)

19 Allen wrench (031000)

20 Allen wrench (031003)

PartsList Exploded view

FaultFinder

Fault Cause Rectiﬁcation

Wobbling of handle. The ﬁxing screw comes loose. Check for ﬁxing screw and

re-tighten it properly.

Wobbling of canopy. The canopy comes loose. Check and tighten the canopy.

SafetyTips,CareandMaintenance

Safety Tips

If you are soldering during faucet installation,remove cartridges, seats, gaskets and washers prior to

applying ﬂame, otherwise you will void the warranty.

Cover drain openings to avoid losing small parts.

When cutting or soldering pipe, use safety glasses to protect your eyes.

Important Points

Prior to beginning installation. turn off the cold and hot water lines and open the old faucet to release

built-up pressure.

Overtightening nuts may cause damage.

Wrap all threaded connections with pipe tape available at your local plumbing supply store.

Always wrap in a clockwise direction. The ﬁttings should be installed by a state-licenced plumber.

Please note:

When there is a difference in water pressure between hot and cold supplies to the mixing valve, the

pressures should be equalized by a plumber in accordance with best practice and legislation.

Maintenance

Your new bathroom faucet is designed for years of trouble-free performance. Keep it looking new by

cleaning it periodically with a soft cloth. Avoid abrasive cleaners, wire wool and harsh chemicals as

these will dull the ﬁnish and void your warranty.

Routine Maintenance

The frequency and extent of attention required will vary according to prevailing site and operational

conditions, however a 12 monthly maintenance schedule is recommended.

If the product has operated satisfactorily for some time, but performance has been degraded, please

check the Fault Finder section to identify the problem.

Maintenance Check List

 s 7ORNORDAMAGEDSEALSANDWASHERS

 s $AMAGEDSEALFACES

 s 4HREADWEAR

 s )NCORRECTADJUSTMENT

 s #OMPONENTFAILURE

 s $EBRISORLIMESCALEBUILDUP

Guarantee

Guarantee of Quality

This product is guaranteed against faulty materials and workmanship for 12 months from date

of purchase. For the guarantee to be valid, the unit must be installed by a competent person, in

accordance with the instruction booklet.

Any part found to be defective during the guarantee period, will (at our option) be repaired or

replaced, free of charge, provided the unit has been installed, and properly used in

accordance with the instruction booklet.

Our products correspond to the valid technical and water supply standards as well as the relevant

approvals requirements. We guarantee them to be free of design and production faults at the time

of delivery and that with correct use and care in accordance with our printed instructions they will

function reliably.

Guarantee period

sThe guarantee is valid in private homes for 5 years from the purchase date. Proof of purchase

has to be provided when making a guarantee claim.

sBy use in commercial or institutional applications the guarantee is valid for 1 year after ﬁrst use.

To make a guarantee claim, proof of purchase or, the beginning of use is required.

Not Covered by this Guarantee

Damage or defects arising from incorrect installation, improper use or lack of maintenance.

Installed product damaged in transit Consequential loss, damage or product removal and installation

costs.

Lefroy Brooks is not responsible for any on site labour charges.

Inhaltsverzeichnis

Andere Lefroy Brooks Küchen- und Badezimmerausstattung Handbücher

Lefroy Brooks

Lefroy Brooks K1-1201 Montageanleitung

Lefroy Brooks

Lefroy Brooks FLEETWOOD M2-4707 Montageanleitung

Lefroy Brooks

Lefroy Brooks K1-1012 Montageanleitung

Lefroy Brooks

Lefroy Brooks M1-2154 Montageanleitung

Lefroy Brooks

Lefroy Brooks K1-1300 Montageanleitung

Lefroy Brooks

Lefroy Brooks M1-4404 Montageanleitung

Lefroy Brooks

Lefroy Brooks X1-1998 Montageanleitung

Lefroy Brooks

Lefroy Brooks FLEETWOOD M2-4711 Montageanleitung

Lefroy Brooks

Lefroy Brooks K1-2100 Montageanleitung

Lefroy Brooks

Lefroy Brooks CB-1108 Montageanleitung

Lefroy Brooks

Lefroy Brooks M2-2400 Bedienungsanleitung

Lefroy Brooks

Lefroy Brooks FLEETWOOD M2-2210 Montageanleitung

Lefroy Brooks

Lefroy Brooks R1-4027 Montageanleitung

Lefroy Brooks

Lefroy Brooks M1-5351 Montageanleitung

Lefroy Brooks

Lefroy Brooks K1-1400 Bedienungsanleitung

Lefroy Brooks

Lefroy Brooks K1-3400 Montageanleitung

Lefroy Brooks

Lefroy Brooks C1-1103 (LB1228) Bedienungsanleitung

Lefroy Brooks

Lefroy Brooks CW-1050 Montageanleitung

Lefroy Brooks

Lefroy Brooks FLEETWOOD M2-5300 Montageanleitung

Lefroy Brooks

Lefroy Brooks M2-1212 Bedienungsanleitung

Lefroy Brooks

Lefroy Brooks M2-2201 Montageanleitung

Lefroy Brooks

Lefroy Brooks M1-4203 Montageanleitung

Lefroy Brooks

Lefroy Brooks CB-2401 Montageanleitung

Lefroy Brooks

Lefroy Brooks M1-5111 Montageanleitung

Beliebte Küchen- und Badezimmerausstattung Handbücher anderer Marken

Grohe

Grohe BRIDGEFORD 33 870 Bedienungsanleitung

Hans Grohe

Hans Grohe Zenio Metro 31811000 Bedienungsanleitung

Gröne

Gröne Zedra 32 555 Bedienungsanleitung

Transform

Transform QL045 Bedienungsanleitung

Sanela

Sanela SLU 09PTB Bedienungsanleitung

Glacier bay

Glacier bay FP4A0052BNV Montageanleitung

Grohe

Grohe Rapido E Bedienungsanleitung

Danze

Danze D302455 Bedienungsanleitung

Waterworks

Waterworks CEKM30 Merkblatt

Helvex

Helvex Omega TV-298 Bedienungsanleitung

Tribata.

Tribata. GEORGIAN G5393 Bedienungsanleitung

Alpha Bidet

Alpha Bidet Alpha One Bedienungsanleitung

InSinkErator

InSinkErator H/HC3300 Installationshandbuch

Clou

Clou Xo type 1 Bedienungsanleitung

Kohler

Kohler Contra 26448T-4 Bedienungsanleitung

Grohe

Grohe Bridgeford 20 158 Bedienungsanleitung

Hans Grohe

Hans Grohe Croma Select S 180 Showerpipe EcoSmart... Bedienungsanleitung

Wickes

Wickes MONO SINK MIXER Bedienungsanleitung