Lenovo ThinkPad X200si Betriebsanleitung

Removing and replacing a FRU

This chapter presents directions and drawings for use in removing and replacing a

FRU. Be sure to observe the following general rules:

1. Do not try to service any computer unless you have been trained and certified.

An untrained person runs the risk of damaging parts.

2. Before replacing any FRU, review “FRU replacement notices” on page 79.

3. Begin by removing any FRUs that have to be removed before the failing FRU.

Any such FRUs are listed at the top of the page. Remove them in the order in

which they are listed.

4. Follow the correct sequence in the steps for removing the FRU, as given in the

drawings by the numbers in square callouts.

5. When turning a screw to replace a FRU, turn it in the direction as given by the

arrow in the drawing.

6. When removing the FRU, move it in the direction as given by the arrow in the

drawing.

7. To put the new FRU in place, reverse the removal procedure and follow any

notes that pertain to replacement. For information about connecting and

arranging internal cables, see “Locations” on page 161.

8. When replacing a FRU, use the correct screw as shown in the procedures.

DANGER

Before removing any FRU, turn off the computer, unplug all power cords

from electrical outlets, remove the battery pack, and then disconnect any

interconnecting cables.

Attention: After replacing a FRU, do not turn on the computer until you have

made sure that all screws, springs, and other small parts are in place and none are

loose inside the computer. Verify this by shaking the computer gently and listening

for rattling sounds. Metallic parts or metal flakes can cause electrical short circuits.

Attention: The system board is sensitive to, and can be damaged by, electrostatic

discharge. Before touching it, establish personal grounding by touching a ground

point with one hand or by using an electrostatic discharge (ESD) strap (P/N

6405959).

www.battery-adapter.com

Before servicing ThinkPad X200, X200s, X200si, X201, X201i, and

X201s

Removing the SIM card:

Some models of the ThinkPad X200, X200s, X200si, X201, X201i, and X201s you are

servicing might have the SIM card that the customer has been installed.

If the computer you are servicing has the SIM card, remove it before you start the

servicing.

To remove the SIM card, you need to remove the battery pack first. (See “1010

Battery pack” on page 85.)

After you finish the servicing, make sure that you insert the card back into the slot

firmly.

Notice on disconnecting the cable from flip-lock ZIF connector:

Some cables used in the ThinkPad X200, X200s, X200si, X201, X201i, and X201s are

connected to the flip-lock ZIF connectors.

When disconnecting the cable from those connectors, do as shown in this figure.

84 ThinkPad X200, X200s, X200si, X201, X201i, and X201s Hardware Maintenance Manual

www.battery-adapter.com

1010 Battery pack

Important notice for replacing a battery pack:

Lenovo ThinkVantage Toolbox (in Windows 7) and Lenovo System Toolbox (in

Windows Vista and Windows XP) have an automatic battery diagnostic that

determines if the battery pack is defective. A battery pack FRU should not be

replaced unless this diagnostic shows that the battery is defective.

The only exception to this is if the battery pack is physically damaged or a

customer is reporting a possible safety issue.

If ThinkVantage Toolbox or Lenovo System Toolbox is not installed in the

computer, the customer should download this program before a non-physically

damaged battery pack is replaced. Note that a physically damaged battery pack

is non-warranty replacement.

Removing and replacing a FRU 85

www.battery-adapter.com

Table 9. Removal steps of battery pack

DANGER

Use only the battery specified in the parts list for your computer. Any other

battery could ignite or explode.

Unlock the battery release lever 1. Holding the battery release lever in the

unlocked position 2, remove the battery pack in the direction shown by arrow

3.

1 2

When installing: Install the battery pack along the slide rails of the slot. Then

make sure that the battery release lever is in the locked position.

86 ThinkPad X200, X200s, X200si, X201, X201i, and X201s Hardware Maintenance Manual

www.battery-adapter.com

1020 Hard disk drive (HDD) cover, HDD, and HDD rubber rails or solid

state drive (SSD) and storage converter

For access, remove this FRU:

v“1010 Battery pack” on page 85

Table 10. Removal steps of HDD cover, HDD, and HDD drive rubber rails or SSD and

storage converter

Step Screw (quantity) Color Torque

1 Hard disk drive screw, M3 ×3 mm,

wafer-head, nylon-coated (1)

Black 0.392 Nm

(4 kgfcm)

Attention:

vDo not drop the hard disk drive or apply any physical shock to it. The hard

disk drive is sensitive to physical shock. Improper handling can cause damage

and permanent loss of data.

vBefore removing the drive, have the user make a backup copy of all the

information on it if possible.

vNever remove the drive while the system is operating or is in suspend mode.

Removing and replacing a FRU 87

www.battery-adapter.com

Table 10. Removal steps of HDD cover, HDD, and HDD drive rubber rails or SSD and

storage converter (continued)

When installing: Make sure that the HDD connector or SSD connector is

attached firmly.

88 ThinkPad X200, X200s, X200si, X201, X201i, and X201s Hardware Maintenance Manual

www.battery-adapter.com

Table 10. Removal steps of HDD cover, HDD, and HDD drive rubber rails or SSD and

storage converter (continued)

HDD and HDD rubber rails:

When installing: The rubber rails on the hard disk drive must be attached to

the replacement drive. Otherwise the drive cannot be installed properly.

SSD and storage converter:

Removing and replacing a FRU 89

www.battery-adapter.com

Table 10. Removal steps of HDD cover, HDD, and HDD drive rubber rails or SSD and

storage converter (continued)

When installing: When you install the SSD in the storage converter, do as

follows.

90 ThinkPad X200, X200s, X200si, X201, X201i, and X201s Hardware Maintenance Manual

www.battery-adapter.com

1030 DIMM

For access, remove this FRU in order:

v“1010 Battery pack” on page 85

Table 11. Removal steps of dimm

Remove the DIMM slot cover as shown in this figure.

Note: Loosen the screws 1, but do not remove them.

Removing and replacing a FRU 91

www.battery-adapter.com

Table 11. Removal steps of dimm (continued)

Note: For ThinkPad X200, X200s, and X200si, if only one DIMM is used on the

computer you are servicing, the card must be installed in SLOT-0 (a), but not

in SLOT-1 (b).

For ThinkPad X200, X200s, and X200si:

a b

92 ThinkPad X200, X200s, X200si, X201, X201i, and X201s Hardware Maintenance Manual

www.battery-adapter.com

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Lenovo Laptop Handbücher

Lenovo

Lenovo ThinkPad X240 Bedienungsanleitung

Lenovo

Lenovo Yoga 5G 14 05 Betriebsanleitung

Lenovo

Lenovo ThinkPad E490s Betriebsanleitung

Lenovo

Lenovo ThinkPad X60 Series Bedienungsanleitung

Lenovo

Lenovo V100 Bedienungsanleitung

Lenovo

Lenovo 21CD007JAU Bedienungsanleitung

Lenovo

Lenovo Flex 3 Bedienungsanleitung

Lenovo

Lenovo K4450A Betriebsanleitung

Lenovo

Lenovo ThinkPad X60 Tablet Bedienungsanleitung

Lenovo

Lenovo ideapad 330S-14AST Bedienungsanleitung

Lenovo

Lenovo IdeaPad Y560 Bedienungsanleitung

Lenovo

Lenovo Legion Tower 5i Betriebsanleitung

Lenovo

Lenovo 82K0000JBM Bedienungsanleitung

Lenovo

Lenovo 1866 - ThinkPad X41 Tablet Leitfaden

Lenovo

Lenovo R61i - ThinkPad 7650 - Core 2 Duo 1.83 GHz Betriebsanleitung

Lenovo

Lenovo ThinkPad X230 Tablet Bedienungsanleitung

Lenovo

Lenovo IDEAPAD Z580 Series Bedienungsanleitung

Lenovo

Lenovo 20UD002BIX Bedienungsanleitung

Lenovo

Lenovo 41896HU Betriebsanleitung

Lenovo

Lenovo ThinkPad R400 Anleitung zur Verwendung

Lenovo

Lenovo 1866 - ThinkPad X41 Tablet Bedienungsanleitung

Lenovo

Lenovo Legion Y740 Series Bedienungsanleitung

Lenovo

Lenovo ThinkPad Edge E320 Kurzanleitung

Lenovo

Lenovo ThinkPad X300 Bedienungsanleitung

Beliebte Laptop Handbücher anderer Marken

HP ze2401xt - Pavilion Notebook PC Bedienungsanleitung

Velocity

Velocity NoteMagix M10 Bedienungsanleitung

Dell

Dell Alienware 17 R2 Bedienungsanleitung

Toshiba

Toshiba A105-S2236 Bedienungsanleitung

HP ENVY 17 Handbuch

Winbook

Winbook LM Bedienungsanleitung

Dell

Dell Inspiron 1464 Bedienungsanleitung

Dell

Dell Inspiron 15R 5537 Bedienungsanleitung

HP PROBOOK 4520S Handbuch

Dell

Dell Latitude ATG D620 Bedienungsanleitung

Dell

Dell Latitude 7310 Bedienungsanleitung

Dell

Dell Precision GU806 Bedienungsanleitung

Sony

Sony VAIO PCG-R505JLK Bedienungsanleitung

HP Compaq tc4200 Kurzanleitung

Toshiba

Toshiba mini NB300 Bedienungsanleitung

Sony

Sony VGN-T240P VAIO Bedienungsanleitung

Compaq

Compaq Armada E700 Series Bedienungsanleitung

Fujitsu

Fujitsu Lifebook A6230 Bedienungsanleitung