Macnaught RETRACTA C1 Bedienungsanleitung
Instruction Manual
REV 07/27/23
Spring Driven Hose Reel
WARNING:
Read carefully and understand all INSTRUCTIONS before operating. Failure to follow the safety
rules and other basic safety precautions may result in serious personal injury.
Save these instructions in a safe place and on hand so that they can be read when required.
GENERAL SAFETY REGULATIONS
WARNING: The warnings, cautions, and instructions
discussed in this instruction manual cannot cover all
possible conditions or situations that could occur. It
must be understood by the operator that common
sense and caution are factors that cannot be built into
this product, but must be supplied by the operator.
The following general warnings should be observed when installing, operating
or maintaining hose reel equipment.
1. Keep the work area clean and dry. Damp or wet work areas can result in
injury.
2. Keep children away from work area. Do not allow children to handle this
product.
3. The operator should wear appropriate protection equipment to protect against
personal injury.
4. Do not let go of the hose when rewinding.
5. Do not attempt to stop leaks with your hand or body.
6. Caution should be observed against burning due to hot water temperature
when using hot water reels.
7. Use reel in well ventilated areas if toxic or flammable fluids are in use.
8. Do not exceed the maximum working pressure for this reel. (Refer to the
Technical Details)
9. Only use compatible fluids with this reel. (Refer to compatible fluids in the
Technical Details)
10. Use the right tool for the job. Do not attempt to force small equipment to do
the work of larger industrial equipment. There are certain applications for
which this equipment was designed. It will do the job better and more safely
at the capacity for which it was intended. Do not modify this equipment, and
do not use this equipment for a purpose for which it was not intended.
11. Check for damaged parts. Before using this product, carefully check that it
will operate properly and perform its intended function. Check for damaged
parts and any other conditions that may affect the operation of this product.
DO NOT use damaged equipment.
12. Before attempting any maintenance disconnect and turn off supply line, then
release the line pressure.
13. Do not overreach. Keep proper footing and balance at all times to prevent
tripping, falling, back injury, etc.
14. Do not use the equipment when tired or under the influence of drugs,
alcohol, or medication. A moment of inattention while operating this
equipment may result in serious personal injury.
TECHNICAL DETAILS
Page 1
TECHNICAL
DETAILS
SAFETY
PRECAUTIONS
INSTALLATIONOPERATIONMAINTENANCE
LIMITED
WARRANTY
205mm / 8"
396mm / 15.6"
438mm / 17.24"84mm / 3.3"
Hose Reel Type Max.
Pressure
Item No.
C1AW315B-01CB
C1AW350B-02CB
C1AW412B-01CC
C1AW440B-02CC
C1HC412R-01DD
C1HC440R-06FD
C1HC412R-01DD-SG
C1HC440R-06FD-SG
C1DR412D-03DD
C1DR440D-07FD
C1WD315R-01CB
Outlet
1/4" BSPT (M)
1/4" NPT (M)
3/8" BSPT (M)
3/8" NPT (M)
1/2" BSPT (M)
1/2" NPT (M)
1/2" BSPT (M)
1/2" NPT (M)
1/2" Quick Connector
1/2" Quick Connector
1/4" BSPT (M)
Hybrid Polymer
Hybrid Polymer
Hybrid Polymer
Hybrid Polymer
Hybrid Polymer
Hybrid Polymer
Hybrid Polymer
Hybrid Polymer
Hybrid Polymer
Hybrid Polymer
PVC
3/8"
3/8"
1/2"
1/2"
1/2"
1/2"
1/2"
1/2"
1/2"
1/2"
3/8"
Inlet
Hose Capacity
Material I.D. Length
15m
50ft
12m
40ft
12m
40ft
12m
40ft
12m
40ft
15m
3/8" BSPT (M)
3/8" NPT (M)
3/8" BSPT (M)
3/8" NPT (M)
1/2" BSP(F)
3/4"-11 1/2 GHT (F)
1/2" BSP(F)
3/4"-11 1/2 GHT (F)
1/2" Quick Connector
3/4"-11 1/2 GHT (F)
3/8" BSPT (M)
Air / Water
Air / Water
Air / Water
Air / Water
Hot / Cold Water
Hot / Cold Water
Hot / Cold Water
Hot / Cold Water
Garden / Horticulture
Garden / Horticulture
Weedicide / Pesticides
250 psi
250 psi
250 psi
250 psi
300 psi
300 psi
300 psi
300 psi
150 psi
150 psi
300 psi
Hose Working
Temperature
-20°C～60°C
-4°F～140°F
-20°C～60°C
-4°F～140°F
-40°C～80°C
-40°F～176°F
-40°C～80°C
-40°F～176°F
0°C～60°C
32°F～140°F
0°C～60°C
[125mm / 4.92"
40mm / 1.57"
192mm / 7.55"
8.5mm / 2-Ø0.33"
15.5mm / 2-Ø0.61"
15mm / 0.6
"
HOSE REEL SAFETY PRECAUTIONS
1. Use proper eye protection when assembling and using the hose reel.
2. Keep children away from the work area.
3. Personal injury and/or equipment damage may result if proper safety precautions are not
observed.
4. Ensure that the reel is properly installed before connecting input and output hoses.
5. Bleed fluid/gas pressure from the system before servicing the reel.
6. Before connecting the reel to the supply line, ensure that the pressure does not exceed the
maximum working pressure rating of the reel.
7. Remember, even low pressure is very dangerous and can cause personal injury or death.
8. If a leak occurs in the hose or reel, remove system pressure immediately.
9. Ensure that the reel, hose, and equipment being serviced is properly grounded.
10. If the reel ceases to unwind or rewind, remove the system pressure immediately.
11. Do not pull or jerk on the hose.
WARNING: Exposure of skin directly to pressurised air, or fluids could result in severe
bodily injury.
INSTALLATION
1. Prior to mounting the hose reel, ensure that the supply line pressure does not exceed the
maximum working pressure of the hose reel.
2. Unpack and inspect the reel for damage. Turn by hand to check for smooth operation.
3. Check operation by pulling out hose and then recoiling it back into the reel.
4. For overhead ceiling mounting: Install reel at most 10 ft/ 3m above the floor.
5. You will need to purchase appropriate hardware for mounting your new reel.
a. The reel base has two 8.5mm drilled holes for mounting on a suitable flat surface.
b. Using the two holes in the base, mount the reel in the desired location. Be sure to use
appropriate hardware and tighten securely.
Page 2
TECHNICAL
DETAILS
SAFETY
PRECAUTIONS
INSTALLATIONOPERATIONMAINTENANCE
LIMITED
WARRANTY
Ceiling
Wall
Page 3
TECHNICAL
DETAILS
SAFETY
PRECAUTIONS
INSTALLATIONOPERATIONMAINTENANCE
LIMITED
WARRANTY
5. Apply teflon tape or pipe sealant to supply line threads, attach to reel inlet and tighten. The
other end of the incoming line can now be connected to the desired supply source.
6. Apply teflon tape or pipe sealant to outlet fitting on the reel hose, then attach to desired tool,
or nozzle. Check connection for leakage, also check the hose reel for correct operation.
Refer to Operation section.
7. If hose stopper adjustment is required, pull the hose from the reel and allow to latch at
desired length. Loosen stopper bolts, and slide the stopper to a position close to the hose
guide. Tighten stopper bolts, and unlatch the reel.
OPERATION
1. Check the reel for correct operation by slowly pulling out the hose. A ”clicking” noise will be
heard every half revolution of the drum.
2. To latch the reel, pull out the hose and allow it to retract after hearing the first second or third
“click”.
3. To unlatch, slowly pull out the hose until the ”clicking” noise stops, then let the hose retract
until the hose stopper rests against the hose guide.
4. If necessary, adjust spring tension on the reel by adding or removing wraps of the hose from
the spool, one wraps at a time, until the desired tension is obtained. Add wraps to increase
tension. Remove wraps to decrease tension.
WARNING:
DO NOT OPEN COVER.
This reel is non-repairable and must not be opened as this can cause serious
injury or death. There are no spare parts available. See below picture.
60°
180°FREEDOM OF ROTATION
60°
Locking Position
Locking Position
Locking Position
Page 4
TECHNICAL
DETAILS
SAFETY
PRECAUTIONS
INSTALLATIONOPERATIONMAINTENANCE
LIMITED
WARRANTY
MAINTENANCE
1. Make sure the hose is in proper working order.
2. Clean the hose with a cloth dipped in warm water to remove dirt or deposits and ensure
correct rewinding.
3. Do not use detergents or solvents which could prove incompatible with reel materials.
4. Dismantling of the unit by unskilled personal could prove hazardous; the risk involved mainly
concerns the preloaded springs.
LIMITED WARRANTY
For Warranty Terms and Conditions see macnaught.com.au / macnaughtusa.com.
For a list of Australian Service Centres see macnaught.com.au
8-PT4.0x12F
Don’t Open!
Macnaught
Macnaught Americas
* Read Manual Before Use!
Size: 145x210mm REV 07/27/23157克双铜
Dieses Handbuch passt für folgende Modelle
6
Inhaltsverzeichnis
Andere Macnaught Werkzeuge Handbücher
Macnaught
Macnaught M3D-SSAW3850-H Bedienungsanleitung
Macnaught
Macnaught MINI-LUBE K6 Bedienungsanleitung
Macnaught
Macnaught Lubermate L-AWP1015 Bedienungsanleitung
Macnaught
Macnaught powergun pg450 Bedienungsanleitung
Macnaught
Macnaught M3D-SSAW-5050 Bedienungsanleitung
Macnaught
Macnaught lubemate L-AWP1030 Bedienungsanleitung
Macnaught
Macnaught lubemate L-OD90B Bedienungsanleitung
Macnaught
Macnaught K7/KR MINI-LUBE Series Bedienungsanleitung
Macnaught
Macnaught B2-01 Bedienungsanleitung
Macnaught
Macnaught P3 POWERLUBE Bedienungsanleitung
Macnaught
Macnaught Retracta R3 Bedienungsanleitung
Macnaught
Macnaught Flexigun K32 Bedienungsanleitung
Macnaught
Macnaught Retracta F Series Bedienungsanleitung
Macnaught
Macnaught OKTR585-1-001 Bedienungsanleitung
Macnaught
Macnaught M3D-DEF-7530 Bedienungsanleitung
Macnaught
Macnaught Flexigun K29 Bedienungsanleitung
Macnaught
Macnaught RETRACTA FHM1900-01 Bedienungsanleitung
Macnaught
Macnaught MATP1220 Bedienungsanleitung
Macnaught
Macnaught K53-01 Bedienungsanleitung
Macnaught
Macnaught BG100 Bedienungsanleitung
