Minuteman X17 ECO CFS Bedienungsanleitung

User Manual

X17 ECO CFS Carpet Extractor

115V/230V with High Pressure

Minuteman®, Minuteman International, Inc.

A Member of the Hako Group #988725UMCFS Rev. C 03/18

X17 ECO CFS Carpet Extractor #988725UMCFS Rev. C 03/18

Technical Speciﬁ cations

This manual is furnished with each new Minuteman X17 ECO CFS. This provides the necessary operating and

preventive maintenance instructions. Operators must read and understand this manual before operating or servicing

this machine.

This machine was designed to give you excellent performance and eﬃ ciency. For best results and minimal cost,

please follow the general guidelines below:

· Operate the machine with reasonable care.

· Follow the manufacturer’s suggested maintenance instructions as provided in this booklet.

· Use original Minuteman supplied parts.

Technical Speciﬁ cations

X17 ECO CFS Carpet Extractor #988725UMCFS Rev. C 03/18

Model No. X17115Z / X17115HPZ X17230Z/X17230HPZ

Current Max. 12.5 Amps 7 Amps

Voltage 115V 230V

Vacuum motor power 1250W 1250W

Brush motor power 100W 100W

Pump motor power 50PSI / 100PSI (HP) 50PSI / 100PSI (HP)

Working width 17 in.; 43 cm 17 in., 43cm

Gross Weight 116 lb.; 52.6 kg 116 lb.; 52.6 kg

Solution tank 10 Gallons; 37.8 LITERS 10 Gallon; 37.8 LITERS

Recovery tank 7 Gallons; 26.5 LITERS 7 Gallon; 26.5 LITERS

Power Cord Length 50 ft.; 15.24m 50 ft.; 15.24m

Suction (sealed) 100in. of water 100in. of water

*Vibration < 8.2 ft/s2; <2,5 m/s2

Noise emission

The sound pressure level measured under maximum conditions 83 dB (A)

of use (LwA) according to DIN EN 60335-2-68

The sound pressure level measured (at the ear of the driver) under 72 dB (A)

normal conditions of use (LpA) according to DIN EN 60335-2-68

Measurement inaccuracy (KpA) 1,8 dB (A)

*The frequency weighted acceleration measured according to DIN EN ISO 5349 which have an eﬀ ect upon the upper

limbs (hand-arm-system) amounts under normal working conditions.

Model: X17 ECO CFS (Chemical Free Solution) with HP (High Pressure)

X17 ECO CFS Carpet Extractor #988725UMCFS Rev. C 03/18

Table of Contents

Table Of Contents

Technical Speciﬁ cations ............................................................................................................................................................ 2

Table Of Contents ....................................................................................................................................................................... 4

Safety Instructions ..................................................................................................................................................................... 6

Unpacking Instructions .............................................................................................................................................................. 7

Assembly..................................................................................................................................................................................... 8

Handle Assembly Instructions ..................................................................................................................................................................8

Machine Overview .................................................................................................................................................................... 13

X17 CFS Front ...........................................................................................................................................................................................13

Vacuum Connection .................................................................................................................................................................................13

X17 CFS Back & Bottom ..........................................................................................................................................................................14

Handle/ Control Panel ..............................................................................................................................................................................15

Circuit Breakers........................................................................................................................................................................................16

Solution Tank In-line Filter ......................................................................................................................................................................17

Vacuum Intake Filter ................................................................................................................................................................................17

Solution Tank Drain Hose ........................................................................................................................................................................18

Solution Level Indicator ...........................................................................................................................................................................18

Brush Removal .........................................................................................................................................................................................19

Brush Pressure Gauge ............................................................................................................................................................................20

Brush Pressure Adjustment Knob ..........................................................................................................................................................20

Removable Recovery Tank ......................................................................................................................................................................21

High Pressure Spray System (HP) ..........................................................................................................................................................21

Handle Adjustment ...................................................................................................................................................................................22

Cord Relief ................................................................................................................................................................................................22

Accessories ..............................................................................................................................................................................................23

Table of Contents

X17 ECO CFS Carpet Extractor #988725UMCFS Rev. C 03/18

Maintenance .............................................................................................................................................................................. 24

Operating Instructions ............................................................................................................................................................. 27

Chemical Free Solution Unit .................................................................................................................................................... 29

Troubleshooting CFS Unit .......................................................................................................................................................................30

Troubleshooting ....................................................................................................................................................................... 31

Warranty .................................................................................................................................................................................... 34

X17 ECO CFS Carpet Extractor #988725UMCFS Rev. C 03/18

Safety Instructions

SAVE THESE INSTRUCTIONS

Safety Instructions

FOR COMMERCIAL USE ONLY

IMPORTANT SAFETY INSTRUCTIONS

READALL INSTRUCTIONS BEFORE OPERATING EQUIPMENT

When using an electrical appliance, basic precautions should always be followed, including the following:

WARNING - To reduce the risk of ﬁre, electric shock, or injury:

• Do not leave appliance when plugged in. Unplug from outlet when not in use and before servicing.

WARNING - To reduce the risk of electrical shock, do not expose to rain. Store indoors.

• Never allow children or untrained adults to operate this equipment.

• Keeptheareaofoperationclearofallpersons,particularlysmallchildren,

andpets. Keepbystandersatleast25feetawayfromtheareaofoperation.

• Use only as described in this manual. Use only manufacturer’s

recommended attachments.

• Do not use with damaged cord or plug. If appliance is not working as it

should,hasbeendropped,damaged,leftoutdoors,ordroppedintowater,

return it to a service center.

• Do not pull or carry by cord, use cord as a handle, close a door on cord,

or pull cord around sharp edges or corners.

• Do not run appliance over cord.

• Keep cord away from heated surfaces.

• Donotunplugbypullingoncord. Tounplug,grasptheplug,notthecord.

• Do not handle plug or appliance with wet hands.

• Donotputanyobjectintoopenings. Donotusewithanyopeningblocked;

keep free of dust, lint, hair, and anything that may reduce air ﬂow.

• Keephair,looseclothing,ﬁngers,andallpartsofbodyawayfromopenings

and moving parts.

• Do not pick up anything that is burning or smoking, such as cigarettes,

matches, or hot ashes.

• Turn off all controls before unplugging.

• Use extra care when cleaning on stairs.

• Do not use to pick up ﬂammable or combustible liquids such as gasoline

or use in areas where they may be present.

• Connect to a properly grounded outlet only. See grounding instructions.

• Iffoam/liquidcomesoutofexhaustopeningsturnswitch off immediately.

• Use only chemicals recommended by dealer/manufacturer.

• These machines must be used only with the power supply cord provided

from the manufacturer:

– X17115Z / X17115HPZ: Power Cord #748613

– X17230Z / X17230HPZ: Power Cord #748613CE

Unpacking Instructions

X17 ECO CFS Carpet Extractor #988725UMCFS Rev. C 03/18

INSPECTION

Carefully unpack and inspect your machine for shipping damage.

Each unit is tested and thoroughly inspected before shipment, and

any damage is the responsibility of the delivery carrier who should be

notiﬁed immediately.

ELECTRICAL

Model Numbers X17115Z / X17115HPZ are designed to operate on a

standard 15 amp. 115 volt, 60 hz,AC circuit. Voltages below 105 volts

AC or above 125 voltsAC could cause serious damage to the motor.

Model Numbers X17230Z / X17230HPZ are designed to operate on a

standard 10 amp. 230 volt, 50 hz,AC circuit. Voltages below 210 volts

AC or above 250 voltsAC could cause serious damage to the motor.

WARNING

Electric motors and components can cause an explosion when

operated near explosive materials or vapors. Do not operate this

machine near ﬂammable materials such as solvents, thinners, fuels,

grain dust, etc. See Warning Decal, #715061, page 23.

GROUNDING INSTRUCTIONS

This ﬂoor-ﬁnishing machine shall be grounded while in use to protect

the operator from electric shock. The machine is provided with a

three-conductor cord and a three-contact grounding type attachment

plug to ﬁt the proper grounding type receptacle. The green (or green

and yellow) conductor in the cord is the grounding wire. Never

connect this wire to other than the grounding pin of the attachment

plug.

DANGER

Improper connection of the equipment-grounding conductor can result in a risk

of electric shock. Check with a qualiﬁed electrician or service person if you are

in doubt as to whether the outlet is properly grounded. Do not modify the plug

provided with the appliance — if it will not ﬁt the outlet, have a proper outlet

installed by a qualiﬁed electrician.

Model Numbers X17115Z / X17115HPZ are for use on a nominal 115-volt

circuit and has a grounding plug that looks like the plug illustrated in Figure 1.

Model Numbers X17230Z / X17230HPZ are for use on a nominal 230-volt

circuit and has a grounding plug that looks like the plug illustrated in Figure 2.

Make sure that the appliance is connected to an outlet having the same

conﬁguration as the plug. No adapter should be used with this appliance.

Unpacking Instructions

Figure 1 Figure 2

X17 ECO CFS Carpet Extractor #988725UMCFS Rev. C 03/18

Assembly

D F

Handle Assembly Instructions

The X17 CFS Handle Assembly (D) is not assembled

on the machine when shipped. Follow the instruction on

the next pages to connect the handle assembly to the

machine.

A HANDLE ADJUSTMENT KNOB

B SHOULDER BOLT

C COVER

D HANDLE ASSEMBLY

E SCREW

F CORD RELIEF

Assembly

X17 ECO CFS Carpet Extractor #988725UMCFS Rev. C 03/18

Handle Assembly Instructions

ϭ hŶƉĂĐŬŵĂĐŚŝŶĞ

Ϯ hƐŝŶŐƉŚŝůůŝƉƐ ŚĞĂĚƐĐƌĞǁĚƌŝǀĞƌ>KK^E Ăůů

ĨŽƵƌƐĐƌĞǁƐŚŽůĚŝŶŐŽŶƚŚĞďĂĐŬĐŽǀĞƌƉůĂƚĞ

KEKdZDKs^Zt^

X17 ECO CFS Carpet Extractor #988725UMCFS Rev. C 03/18

Assembly

ϯ WƵƐŚƚŚĞƉůĂƚĞƵƉĂŶĚƉƵůůŝƚŐĞŶƚůǇďĂĐŬƚŽ

ƌĞŵŽǀĞ^ĞƚĂƐŝĚĞ

Andere Handbücher für X17 ECO CFS

Inhaltsverzeichnis

Andere Minuteman Bodenreinigungsmaschine Handbücher

Minuteman

Minuteman FR17115 Gebrauchsanweisung

Minuteman

Minuteman mc20001qp Leitfaden

Minuteman

Minuteman MC20000QP Bedienungsanleitung

Minuteman

Minuteman PowerBoss 26 Series Leitfaden

Minuteman

Minuteman X Ride 28 Bedienungsanleitung

Minuteman

Minuteman Mirage M220028K17X Stücklistenhandbuch

Minuteman

Minuteman Kleen Sweep 27 Stücklistenhandbuch

Minuteman

Minuteman Ambassador C46000-00 Leitfaden

Minuteman

Minuteman 747 Stücklistenhandbuch

Minuteman

Minuteman SW5X PB40PL Bedienungsanleitung

Minuteman

Minuteman EX12 Stücklistenhandbuch

Minuteman

Minuteman TRS17-220 Stücklistenhandbuch

Minuteman

Minuteman MC20004CE Leitfaden

Minuteman

Minuteman Mirage 27" Stücklistenhandbuch

Minuteman

Minuteman R500H Bedienungsanleitung

Minuteman

Minuteman M2400 Leitfaden

Minuteman

Minuteman HM47B Bedienungsanleitung

Minuteman

Minuteman C-BOX 100 Bedienungsanleitung

Minuteman

Minuteman M2400 Stücklistenhandbuch

Minuteman

Minuteman M17120-00 Bedienungsanleitung

Minuteman

Minuteman Lumina 28 Traction Drive Stücklistenhandbuch

Minuteman

Minuteman X17 Bedienungsanleitung

Minuteman

Minuteman M27000-00 Leitfaden

Minuteman

Minuteman Ambassador 20 Stücklistenhandbuch

Beliebte Bodenreinigungsmaschine Handbücher anderer Marken

Nilfisk-Advance

Nilfisk-Advance Advance SC370 17B Bedienungsanleitung

Numatic

Numatic ET 4045 Bedienungsanleitung

HAWK ENTERPRISES

HAWK ENTERPRISES HP1513-180BRUTE Bedienungsanleitung

Mytee

Mytee 8070 Mytee-Lite Bedienungsanleitung

Kärcher

Kärcher B 140 R Bedienungsanleitung

Triple S

Triple S Ace 26T1 Bedienungsanleitung

Nilfisk-Advance

Nilfisk-Advance SW 750 Bedienungsanleitung

Tornado

Tornado Marathon 2000 98190 Handbuch

Windsor

Windsor ADMIRAL Admiral 8 Bedienungsanleitung

Numatic

Numatic TTB 1117/100 Bedienungsanleitung

Tennant

Tennant 8210D Bedienungsanleitung

Nobles

Nobles Frontier Produkthandbuch

lavina

lavina 21-X Bedienungsanleitung

KENT

KENT Edge 28B Bedienungsanleitung

Tennant

Tennant 215 Produkthandbuch

Windsor

Windsor BDP 51/2000C Bedienungsanleitung

CleanFreak

CleanFreak DURA-18HD Bedienungsanleitung

Nilfisk-Advance

Nilfisk-Advance Warrior 34RST Administratorhandbuch