Movincool Classic Plus 14 Bedienungsanleitung
SERVICE MANUAL
CLASSIC PLUS 14
i
FOREWORD
This manual has been published to service the MovinCool Classic Plus 14. Please use this service manual only
when servicing the Classic Plus 14.
DEFINITION OF TERMS
WARNING: Describes precautions that should be observed in order to prevent injury to the user during
installation or unit operation.
CAUTION: Describes precautions that should be observed in order to prevent damage to the unit or its
components, which may occur during installation or unit operation if sufficient care is not taken.
NOTE: Provides additional information that facilitates installation or unit operation.
GENERAL PRECAUTIONS
WARNINGS:
• All electrical work if necessary, should only be performed by qualified electrical personnel. Repair to
electrical components by non-certified technicians may result in personal injury and/or damage to the
unit. All electrical components replaced must be genuine MovinCool, purchased from an authorized
reseller.
• When handling refrigerant, always wear proper eye protection and do not allow the refrigerant to
come in contact with your skin.
•Do not expose refrigerant to an open flame.
•The proper electrical outlet for MovinCool units must be equipped with a “UL” approved ground-fault
breaker to prevent electrical shock from the unit.
•When brazing any tubing, always wear eye protection and work only in a well ventilated area.
ii
iii
TABLE OF CONTENTS
FOREWORD ............................................................................................... i
DEFINITION OF TERMS ............................................................................ i
GENERAL PRECAUTIONS ........................................................................ i
TABLE OF CONTENTS ............................................................................ iii
GENERAL DESCRIPTION ......................................................................... 1
CONSTRUCTION, SPECIFICATIONS, & DATA ........................................ 3
REFRIGERANT SYSTEM .......................................................................... 9
ELECTRICAL SYSTEM............................................................................ 13
TROUBLESHOOTING & REPAIR ............................................................ 19
iv
GENERAL DESCRIPTION
1
Generally speaking, conventional air conditioners cool
the entire enclosed environment. They act as “heat
exchangers”, requiring an interior unit (evaporator) to
blow cool air into the interior and an exterior unit
(condenser) to exhaust exchanged heat to the out-
doors. Unlike conventional air conditioners, the
MovinCool Spot Cooling System is a spot cooler
which directs cool air to particular areas or objects.
MovinCool Spot Cooling Systems have the following
features:
1. Compact Design
The innovative design of MovinCool has
resulted in one compact unit, replacing the
need for two separate units.
2. Easy Transportation and Installation
With the whole cooling system built into one
compact unit, MovinCool requires no piping
and can be easily transported and installed.
3. Energy Conservation
MovinCool is economical because it cools
only the area or objects which need to be
cooled.
CONDENSER
(OUTDOOR UNIT)
EVAPORATOR
(INDOOR UNIT)
Conventional Air Conditioner
Air Flow of MovinCool Spot Cooling System
GENERAL DESCRIPTION
2
CONSTRUCTION, SPECIFICATIONS & DATA
3
Exhaust Air Duct
Cool Air Duct
Centrifugal Fan
Housing for
Condenser Fan
Condenser
Compressor
Caster
Control Box
Capillary Tube
Drain Switch
Caster with Brake
Construction of Classic Plus 14
CONSTRUCTION, SPECIFICATIONS & DATA
4
Construction Diagram
Cool Air Ducts
Evaporator
Drain Tank
Air Filter
(evaporator)
Front Panel
Condenser Fan
Side Panel
Fan Motor
Upper Panel
Air Filter(condenser)
Power Cord
Condenser
Air Filter (condenser)
Compressor
Capillary Tube
Accumulator
Casters
Control Panel
Evaporator Fan Control Box
Base Panel
CONSTRUCTION, SPECIFICATIONS & DATA
5
1. Basic Construction
The MovinCool Spot Cooling System is
compact in construction because the con-
denser and the evaporator are enclosed in
one unit. The interior is divided into three
sections. The upper front face is equipped
with the evaporator, while the lower front face
contains the drain tank. The rear section
contains the condenser, the compressor and
the control box.
2. Air Flow
Air drawn from the right side face passes
through the condenser which extracts the
heat. This hot air is blown out through the
upper exhaust air duct. Air taken in from the
front face is cooled by the evaporator and
then blown through the cool air duct which
can be turned in any direction. All the air
inlets are equipped with filters, while the
exhaust air duct is protected by wire mesh.
3. Compressor and Fans
The compressor is hermetically sealed. A
two-speed fan motor is used with two cen-
trifugal fans to draw air across the evaporator
and condenser.
4. Drain Tank
The capacity of the drain tank is 5.0 gallons
(19 liters). The unit is equipped with a "Tank
Full" LED and a device to automatically stop
the operation of the unit when the drain tank
reaches a level of approximately 4.0 gallons
(15 liters).
Air Flow
Andere Handbücher für Classic Plus 14
3
Inhaltsverzeichnis
Andere Movincool Klimaanlage Handbücher
Movincool
Movincool Office Pro 36 Bedienungsanleitung
Movincool
Movincool CMW30 Bedienungsanleitung
Movincool
Movincool CLIMATE PRO 12 Bedienungsanleitung
Movincool
Movincool Ofice Pro 36 Bedienungsanleitung
Movincool
Movincool PC7 Bedienungsanleitung
Movincool
Movincool 24HFU Bedienungsanleitung
Movincool
Movincool OFFICE PRO 12 Bedienungsanleitung
Movincool
Movincool CLIMATE PRO 18 Bedienungsanleitung
Movincool
Movincool CM 25 Bedienungsanleitung
Movincool
Movincool Classic Plus 26 Bedienungsanleitung
Movincool
Movincool Office Pro 36 Bedienungsanleitung
Movincool
Movincool Office Pro 24 Bedienungsanleitung
Movincool
Movincool OFFICE PRO 18 Bedienungsanleitung
Movincool
Movincool Office Pro 24 Bedienungsanleitung
Movincool
Movincool CLIMATE PRO X14 Bedienungsanleitung
Movincool
Movincool OFFICE PRO 12 Bedienungsanleitung
Movincool
Movincool PC7 Gebrauchs- und Wartungshandbuch
Movincool
Movincool Office Pro 60 Bedienungsanleitung
Movincool
Movincool Office Pro W20 Bedienungsanleitung
Movincool
Movincool OFFICE PRO 12 Bedienungsanleitung
