MULTIQUIP Power WHISPERWATT DCA-220SSJ Leitfaden

PARTS AND OPERATION MANUAL

OPERATION AND PARTS MANUAL

Revision #1 (03/22/07)

THIS MANUAL MUST ACCOMPANY

THE EQUIPMENT AT ALLTIMES.

WHISPERWATTTM SERIES

MODEL DCA-220SSJ

60 Hz GENERATOR

PARTS LIST NO. C1870300404

PAGE 2 — DCA-220SSJ— OPERATION AND PARTS MANUAL — REV. #1 (03/22/07)

DCA-220SSJ— OPERATION AND PARTS MANUAL — REV. #1 (03/22/07) — PAGE 3

NOTE PAGE

PAGE 4 — DCA-220SSJ— OPERATION AND PARTS MANUAL — REV. #1 (03/22/07)

TABLE OF CONTENTS

Specification and part

number are subject to

change without notice.

NOTE

MQ POWER DCA-220SSJMQ POWER DCA-220SSJ

MQ POWER DCA-220SSJ

WHISPERWHISPER

WHISPERWW

WAA

ATTTT

TTTT

TTTMTM

TMTM

GENERATORGENERATOR

GENERATOR

California Proposition 65 Warning ..................................... 2

Table Of Contents ............................................................. 4

Parts Ordering Procedures ............................................... 5

Specifications ................................................................... 6

Dimensions (Top, Side, Front) ........................................... 7

Safety Message Alert Symbols .................................... 8-9

Rules for Safe Operation ........................................... 10-13

Generator Decals ....................................................... 14-15

Installation ................................................................. 16-17

General Information ........................................................ 18

Major Components ......................................................... 19

Diagnostic Display ..................................................... 20-36

Generator Control Panel ................................................. 37

Engine Operating Panel ............................................. 38-39

Output Terminal Panel Familiarization ........................ 40-42

Load Application ............................................................. 43

Generator Outputs .......................................................... 44

Gauge Reading ............................................................... 45

Output Terminal Panel Connections ................................ 46

Setup .............................................................................. 47

Generator Start-up Procedure (Manual) ..................... 52-54

Generator Start-up Procedure (Auto Mode) .................... 55

Generator Shut-Down Procedure .................................... 56

Maintenance (Engine) ................................................ 57-58

Maintenance Jacket Water Heater/Battery Charger ........ 59

Maintenance (Trailer) ................................................. 60-63

Trailer Wiring Diagram ..................................................... 64

Generator Wiring Diagram ............................................... 65

Engine Wiring Diagram ................................................... 66

Generator Troubleshooting .............................................. 67

Engine Controller Troubleshooting ................................... 68

Explanation of Code in Remarks Column ....................... 70

Suggested Spare Parts .................................................. 71

Generator Assembly .................................................. 72-74

Control Panel Assembly ............................................ 76-77

Control Box Assembly ............................................... 78-81

Engine and Radiator Assembly ................................. 82-87

Output Terminal Assembly ......................................... 88-89

Battery Assembly ...................................................... 90-91

Muffler Assembly ...................................................... 92-93

Fuel Tank Assembly .................................................. 94-95

Enclosure Assembly ............................................... 96-101

Rubber Seals Assembly ........................................ 102-103

Nameplate and Decals .......................................... 104-105

Terms and Condition of Sale — Parts .......................... 106

COMPONENT DRACOMPONENT DRA

COMPONENT DRAWINGSWINGS

WINGSWINGS

WINGS

DCA-220SSJ— OPERATION AND PARTS MANUAL — REV. #1 (03/22/07) — PAGE 5

MQPOWER

A Division of Multiquip Inc.

POST OFFICE BOX 6254

CARSON, CA 90749

310-537-3700 • 800-421-1244

FAX: 310-632-2656

E-MAIL: [email protected]

INTERNET: www.mqpower.com

When ordering parts,

please supply the following information:

❒❒

❒Dealer account number

❒❒

❒Dealer name and address

❒❒

❒Shipping address (if different than billing address)

❒❒

❒Return fax number

❒❒

❒Applicable model number

❒❒

❒Quantity, part number and description of each part

❒❒

❒Specify preferred method of shipment:

✓FedEx or UPS Ground

✓FedEx or UPS Second Day or Third Day

✓FedEx or UPS Next Day

✓Federal Express Priority One

✓DHL

✓Tr u c k

Note:Unless otherwise indicated by customer, all

orders are treated as “Standard Orders”, and will

ship within 24 hours.We will make every effort to

ship “Air Shipments” the same day that the order is

received, if prior to 2PM west coast time. “Stock

Orders” must be so noted on fax or web forms.

Extra Discounts!

All parts orders which include complete part numbers and

are received by our automated web parts order system, or

by fax qualify for the following extra discounts:

Ordered Standard Stock orders

via orders ($750 list and above)

Fax 3% 10%

Web 5% 10%

Special freight allowances

when you order 10 or more

line items via Web or Fax!**

FedEx Ground Service

at no charge for freight

No other allowances on freight shipped by any other carrier.

**Common nuts, bolts and washers (all items under $1.00

list price) do not count towards the 10+ line items.

Place Your Parts Order Via Web or Fax

For Even More Savings!

(Domestic USA Dealers Only)

NOTE:DISCOUNTS ARESUBJECT TO CHANGE

Here’s how to get help...

Please have the model and serial number

on hand when calling.

MQ POWER CORPORATE OFFICE

18910 Wilmington Ave. 800-421-1244

Carson, CA 90746

FAX:

310-632-2656

Email: mqpower@multiquip.com

Internet: www.mqpower.com

PARTS DEPARTMENT

800-427-1244

FAX:

800-672-7877

310-537-3700

FAX:

310-637-3284

SERVICE DEPARTMENT

800-835-2551

FAX:

310-638-8046

310-537-3700

TECHNICAL ASSISTANCE

800-835-2551

FAX:

310-638-8046

WARRANTY DEPARTMENT

800-835-2551,

EXT.

279

FAX:

310-638-8046

310-537-3700,

EXT.

279

Direct TOLL-FREE access

to our Parts Department:

Toll-free nationwide — 800-427-1244

Toll-free FAX — 800-6-PARTS-7 (800/672-7877)

PARTS ORDERING PROCEDURES

PAGE 6 — DCA-220SSJ— OPERATION AND PARTS MANUAL — REV. #1 (03/22/07)

DCA-220SSJ — SPECIFICATIONS

snoitacificepSrotareneG.1elbaT

ledoMUJSS022-ACD

epyT ,detalitnevfles,dleifgnivloveR

rotarenegsuonorhcnysepytdetcetorpnepo

noitcennoCeruta

mrAlartueNhtiwratS

esahP 3

tuptuOybdnatS )WK491(AVK242

tuptuOemirP )WK671(AVK022

egatloV V084RO,042

ycneuqerF zH

deepS mpr0081

rotcaFrewoP 8.0

rewoPCA.XUA zH06,esahPelgniS

egatloV V021

tuptuO )2XWK4.2(WK8.4

thgieWyrD ).gk03

1,3(.sbl598,6

thgieWteW ).gk025,3(.sbl357,7

snoitacificepSenignE.2elbaT

ledoM 584FH8606EREEDNHOJ

epyT ria-ria,degrahc-obrut,noitcejnitcerid,delooc-retaw,elcyc4

srednilyCfo.oN sre

dnilyc6

ekortSxeroB )mm721xmm601(.ni00.5x.ni71.4

tuptuOdetaR MPR0081/.P.H682

tnemecalpsiD )sretil8.6(.ni.uc

514

gnitratS CDV21cirtcelE

yticapaCtnalooC )sretil42(.lag4.6

yticapaCliOebuL )sretil13(.lag91.8

epyTleuF leuF

leseiD2#

yticapaCknaTleuF )sretil083(.lag001

noitpmusnoCleuF tarh/)L6.15(.lag36.31 daollluf

yrettaB 1xhA821

DCA-220SSJ— OPERATION AND PARTS MANUAL — REV. #1 (03/22/07) — PAGE 7

DCA-220SSJ — DIMENSIONS (TOP, SIDE AND FRONT)

Figure 1. Dimensions

SNOISNEMID.3ELBAT

ecnerefeR

retteL ).mm(.tfnoisnemiDretteLecnerefeR).mm(.tfnoisnemiD

A).mm049(.ni00.73F ).mm005,3(.ni08.731

B).mm0

49(.ni00.73G ).mm007,1(.ni29.66

C).mm050,1(.ni33.14H ).mm042,1(.ni18.84

D).mm050,1(.ni33.14

E).mm050,1(.ni33.14

PAGE 8 — DCA-220SSJ— OPERATION AND PARTS MANUAL — REV. #1 (03/22/07)

This Owner's Manual has been

developed to provide complete

instructions for the safe and

efficient operation of the

MQ Power

Model DCA-220SSJ

Whisperwatt™ Generator.

Before using this generator,ensure that the operating

individual has read and understands all instructions in

this manual.

Safety precautions should be followed at all times when

operating this equipment. Failure to read and understand the

Safety Messages and Operating Instructions could result in

injury to yourself and others.

FOR YOUR SAFETY AND THE SAFETY OF OTHERS! HAZARD SYMBOLS

Potential hazards associated with the operation of this

equipment will be referenced with "

Hazard Symbols

" which

appear throughout this manual, and will be referenced in

conjunction with Safety "

Message Alert Symbols

NOTE

DCA-220SSJ — SAFETY MESSAGE ALERT SYMBOLS

SAFETY MESSAGE ALERT SYMBOLS

The three (3) Safety Messages shown below will inform you

about potential hazards that could injure you or others. The

Safety Messages specifically address the level of exposure

to the operator, and are preceded by one of three words:

DANGER, WARNING, or CAUTION.

You WILL be KILLED or SERIOUSLY injured if you

do not follow directions.

You COULD be KILLED or SERIOUSLY injured if

you do not follow directions.

You CAN be injured if you do not follow directions

Gasoline engine exhaust gases contain

poisonous carbon monoxide. This gas is

colorless and odorless, and can cause

DEATH

if inhaled. NEVER operate this

equipment in a confined area or enclosed structure that

does not provide ample free flow air.

Gasoline

is extremely flammable, and

its vapors can cause an explosion if

ignited. DO NOT start the engine near

spilled fuel or combustible fluids.

DO NOT fill the fuel tank while the engine

is running or hot.

DO NOT overfill tank, since spilled fuel could ignite if it

comes into contact with hot engine parts or sparks from

the ignition system. Store fuel in approved containers, in

well-ventilated areas and away from sparks and flames.

NEVER use fuel as a cleaning agent.

Engine components can generate extreme

heat.To prevent burns, DO NOT touch these

areas while the engine is running or

immediately after operations. NEVER

operate the engine with heat shields or heat

guards removed.

WARNING

DANGER

CAUTION

WARNING - LETHAL EXHAUST GASES

WARNING - BURN HAZARDS

WARNING - EXPLOSIVE FUEL

During operation of this generator, there

exists the possibility of

electrocution,

electrical shock or burn,

which can cause

severe bodily harm

or even

DEATH!

DANGER - ELECTROCUTION HAZARDS

DCA-220SSJ— OPERATION AND PARTS MANUAL — REV. #1 (03/22/07) — PAGE 9

DCA-220SSJ — SAFETY MESSAGE ALERT SYMBOLS

ALWAYS place the MPEC control switch

in the OFF/RESET position when the

generator is not in use.

ALWAYS wear approved

respiratory

protection.

ALWAYS wear approved

eye

and

hearing

protection.

Other important messages are provided throughout this

manual to help prevent damage to your generator, other

property, or the surrounding environment.

This generator, other property, or

the surrounding environment

could be damaged if you do not

follow instructions.

NOTE

NEVER tamper with the factory settings

of the engine governor or settings.

Personal injury and damage to the engine

or equipment can result if operating in

speed ranges above maximum allowable.

CAUTION - OVER-SPEED CONDITIONS

CAUTION - ACCIDENTAL STARTING

CAUTION - RESPIRATORY HAZARDS

CAUTION - SIGHT AND HEARING HAZARDS

CAUTION - EQUIPMENT DAMAGE MESSAGES

NEVER operate equipment with covers,

or guards removed. Keep

fingers

hands

hair

and clothing away from all moving

parts to prevent injury.

WARNING - ROTATING PARTS

PAGE 10 — DCA-220SSJ— OPERATION AND PARTS MANUAL — REV. #1 (03/22/07)

DCA-220SSJ — RULES FOR SAFE OPERATION

The following safety guidelines should always be used when

operating the

DCA-220SSJWhisperwatt™ AC Generator.

General Safety:

■

DO NOT operate or service this

equipment before reading this entire

manual.

The operator MUST BE familiar with proper safety

precautions and operations techniques before using

generator.

■

This equipment should not be operated by persons under

18 years of age.

■

NEVER operate this equipment without proper protective

clothing, shatterproof glasses, steel-toed boots and other

protective devices required by the job.

■

NEVER operate this equipment when not

feeling well due to fatigue, illness or taking

medicine.

■

NEVER operate this equipment under the influence or

drugs or alcohol.

Failure to follow instructions in this manual may lead to

serious injury

or even

DEATH

! This equipment is to be

operated by trained and qualified personnel only! This

equipment is for industrial use only.

DANGER - READ THIS MANUAL!

■

ALWAYS check the machine for loosened threads or bolts

before starting.

■

NEVER operate the generator in an explosive atmosphere

or near combustible materials. An explosion or fire could

result causing severe

bodily harm or even death.

■

NEVER touch the hot exhaust manifold, muffler

or cylinder. Allow these parts to cool before

servicing engine or generator.

■

HighTemperatures – Allow the engine

to cool before performing service and

maintenance functions. Contact with

hot!

components can cause serious

burns.

■

The engine of this generator requires an adequate free

flow of cooling air.

NEVER

operate the generator in any

enclosed or narrow area where free flow of the air is

restricted. If the air flow is

restricted it will cause serious

damage to the generator or

engine and may cause injury

to people. The generator

engine gives off DEADLY

carbon monoxide gas.

■

DO NOT place hands or fingers inside generator engine

compartment when engine is running.

■

NEVER run engine without air filter.Severe engine damage

may occur.

■

DO NOT leave the generator running in the

manual mode

unattended.

■

Refer to the

John Deere Engine Owner's Manual

for

engine technical questions or information.

■

ALWAYS store equipment properly when it is not being

used. Equipment should be stored in a clean, dry location

out of the reach of children.

■

NEVER use accessories or attachments, which are not

recommended by MQ Power for this equipment. Damage

to the equipment and/or injury to user may result.

■

Manufacturer does not assume responsibility for any

accident due to equipment modifications. Unauthorized

equipment modification will void all warranties.

■

Whenever necessary, replace nameplate, operation and

safety decals when they become difficult read.

Andere Handbücher für Power WHISPERWATT DCA-220SSJ

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere MULTIQUIP Tragbarer Generator Handbücher

MULTIQUIP

MULTIQUIP WhisperWatt 125 DCA125USI Konfigurationshandbuch

MULTIQUIP

MULTIQUIP GA6HR Bedienungsanleitung

MULTIQUIP

MULTIQUIP DA7000SS Leitfaden

MULTIQUIP

MULTIQUIP WHISPERWATT DCA-400SSV Bedienungsanleitung

MULTIQUIP

MULTIQUIP DCA85USJ2 Leitfaden

MULTIQUIP

MULTIQUIP GAC-6HZR Leitfaden

MULTIQUIP

MULTIQUIP Power WHISPERWATT DCA-40SSI Bedienungsanleitung

MULTIQUIP

MULTIQUIP GA3.6H Bedienungsanleitung

MULTIQUIP

MULTIQUIP WHISPERWATT DCA-400SSV Leitfaden

MULTIQUIP

MULTIQUIP Power WHISPERWATT DCA-36SPX Leitfaden

MULTIQUIP

MULTIQUIP WHISPERWATT Series Bedienungsanleitung

MULTIQUIP

MULTIQUIP Power Ultra-Silent DCA-70SSIU Leitfaden

MULTIQUIP

MULTIQUIP DA7000SSA2GH Leitfaden

MULTIQUIP

MULTIQUIP GA36HR Bedienungsanleitung

MULTIQUIP

MULTIQUIP Power WHISPERWATT DCA25SSIU Leitfaden

MULTIQUIP

MULTIQUIP MQP20P Leitfaden

MULTIQUIP

MULTIQUIP Power WHISPERWATT DCA400SSI Bedienungsanleitung

MULTIQUIP

MULTIQUIP ULTRA-SILENT DCA-125USJ Leitfaden

MULTIQUIP

MULTIQUIP POWER WHISPERWATT DCA-25SSI2 Bedienungsanleitung

MULTIQUIP

MULTIQUIP DCA125USI3CAN Bedienungsanleitung

MULTIQUIP

MULTIQUIP WhisperWatt DCA45SSKU3 Leitfaden

MULTIQUIP

MULTIQUIP Power WHISPERWATT DCA-150SSJU3 Leitfaden

MULTIQUIP

MULTIQUIP Power Ultra-Silent DCA-45USI Leitfaden

MULTIQUIP

MULTIQUIP WHISPERWATT DCA-15SPXU4 Bedienungsanleitung

Beliebte Tragbarer Generator Handbücher anderer Marken

Kohler

Kohler 20EORZ Bedienungsanleitung

Powerhorse

Powerhorse 83171 Bedienungsanleitung

HURST

HURST ML-630-SI Bedienungsanleitung

ETQ

ETQ TG4000 Bedienungsanleitung

Briggs & Stratton

Briggs & Stratton 40265 Einrichtungshandbuch

evertz

evertz 7700 Series Bedienungsanleitung

Firefly

Firefly Cygnus CYG2400/460/24 Bedienungsanleitung

Owon

Owon Waveform Generator Bedienungsanleitung

Draper

Draper PG950S Firmware-Update

SDMO

SDMO SH 4000 Bedienungsanleitung

EINHELL

EINHELL STE 5500 Bedienungsanleitung

Wanco

Wanco WI3000P Bedienungsanleitung

Full Boar

Full Boar FBT-3300 Bedienungsanleitung

Dwyer Instruments

Dwyer Instruments ASG Bedienungsanleitung

Westinghouse

Westinghouse WH1000i Series Bedienungsanleitung

Wallenstein

Wallenstein GF5000A Bedienungsanleitung

Leroy-Somer

Leroy-Somer LSA 49.1 Bedienungsanleitung

Yamakoyo

Yamakoyo SH2900DX Bedienungsanleitung