Pentair SHURFLO Bedienungsanleitung

WATER PURFICATION 911-585 REV. E 1

SHURFLO® LO-FLO 105 SERIES RV PUMPS

INSTALLATION MANUAL

SHURFLO Lo-Flo 105 Series RV pumps are rugged, lightweight, compact and provide the ability to self-prime and run dry.

Standard features include a pressure demand switch, built in 3/8” hose barb ports, ﬂexible mounting feet, splash proof motor,

and thermal protector. All with the security that comes with a UL Recognized Component.

INSTALLATION

SHURFLO Lo-Flo 105 Series RV pumps are self-priming and can be located up to 2.5

feet above the water level. Horizontal and vertical prime vary depending on the ﬂuid

viscosity and pump conﬁguration. The pump can be at the same level or below the

tank.

❚ The pump should be located in an area that is dry and properly ventilated to pre-

vent heat build-up.

❚ Use 50-mesh strainer minimum at the inlet side of the pump. Use ﬂexible hose on

inlet.

❚ The pump can be mounted in any position. However, if mounting the pump verti-

cally the pump head should be in the down position so that in the event of a leak,

ﬂuid will not enter the motor.

❚ 12 Volt pump must be provided with a 5-amp fuse.

❚ Recommended wire size is 16 gauge (1.3 mm) or larger wire as determined by volt-

age drop. Negative (-) must be connected to a known ground. Ground wire must be

the same (gauge/mm) as the positive.

TROUBLESHOOTING

PUMP WILL NOT START

√ For correct voltage (+10%) and

electrical connections

√ Fuse or breaker

√ Pressure switch operation and

correct voltage at switch

√ Rectiﬁer or motor for open or

grounded circuit

√ For locked drive assembly

PUMP WILL NOT PRIME

(No Discharge/Motor Runs)

√ Strainer for debris

√ Inlet/Outlet tube severely restricted

(kinked)

√ Inlet /Outlet valves for debris or

swelling

PUMP WILL NOT SHUT-OFF

√ Output line closed and no leaks

√ For air trapped in outlet line or

pump head

√ For correct voltage to pump

√ Debris in pump Inlet/Outlet valves

√ For loose drive assembly or pump

head screws

√ Pressure switch operation/adjust-

ment

LEAKS FROM PUMP HEAD OR SWITCH

√ For loose screws at switch or pump

head

√ Switch diaphragm ruptured or

pinched

√ For punctured diaphragm if ﬂuid is

present at drain holes

To Faucet

City Water

Check Valve

Alternate Plumbing

for City Water Entry

From Pump

“T” Fitting

RED(+)

PUM P

SWITCH

BLACK(-)

FUSE BATTERY

50 Mesh Strainer Required if using SHURFLO P/N 170-06X-00

A 1/2” to 3/8” Barb splicer is required.

Water Tank

Plumbing Systems can vary.

Consult SHURFLO for detailed

information.

WATER PURIFICATION

3545 HARBOR GATEWAY SOUTH, SUITE 103, COSTA MESA, CA 92626, (800) 854-3218 WWW.SHURFLO.COM

All Pentair trademarks and logos are owned by Pentair, Inc. All other brand or product names are trademarks or registered marks of their respective owners.

Because we are continuously improving our products and services, Pentair reserves the right to change speciﬁcations without prior notice.

Pentair is an equal opportunity employer.

PRODUCT SPECIFICATIONS

Model Number: 105 Series

Pump Design: Positive Displacement Pump

Motor: Placement Magnet, 11-262-00

Voltage: 12 VDC

Pressure Switch: Factory Set: 30 PSI Shut-off, Turn-on 25+/- 5 PSI

Liquid Temperature: 100° Max F [43° C]

Prime: Self Priming up to 2.5 ft. vertical

Ports: 3/8" Barb

Net Weight: 1.27 lbs.

Duty Cycle: Intermittnet

Max Amps: 105-003, 2.5 Amps @ 30 PSI

MATERIALS OF CONSTRUCTION

Motor Housing: Nylon

Plastic: Polypropylene

Valves: EPDM

Diaphragm: Santoprene

Fasteners: Zinc Plated /

Stainess Steel

#10 Screw Mounting Hole

3/8” Hose Barb Port

Pressure Switch

18 AWG Red Positive

18 AWG Black Negative

5.01.70”1.55”3.94”

2.45”

1.87”

2.25”

3.20”

6.82”

FLOW: GPM [LPM]

0.30

[1.14]

0.65

[2.46]

1.00

[3.79]

[2.1]

[1.4]

[0.7]

PRESSURE: PSI [BAR]

Inhaltsverzeichnis

Andere Pentair Wasserpumpe Handbücher

Pentair

Pentair Myers WG20 Handbuch

Pentair

Pentair STA-RITE INTELLIFLO3 VSF Bedienungsanleitung

Pentair

Pentair Multi EVO-A 3-40 Bedienungsanleitung

Pentair

Pentair MYERS TPL15 Handbuch

Pentair

Pentair Fleck 2510 ECONOMINDER Bedienungsanleitung

Pentair

Pentair HYDROMATIC S Handbuch

Pentair

Pentair Myers MSC150 Series Bedienungsanleitung

Pentair

Pentair AURORA LAYNE VERTI-LINE Series Bedienungsanleitung

Pentair

Pentair PVM Series Benutzerhandbuch

Pentair

Pentair DKG Bedienungsanleitung

Pentair

Pentair MYERS MS33D Bedienungsanleitung

Pentair

Pentair Myers 4V Series Handbuch

Pentair

Pentair WATERFALL AFP-75 Bedienungsanleitung

Pentair

Pentair STA-RITE D Series Bedienungsanleitung

Pentair

Pentair MYERS S25M1C Handbuch

Pentair

Pentair 3050 Bedienungsanleitung

Pentair

Pentair BERKELEY 4BSD Bedienungsanleitung

Pentair

Pentair Hydromatic S4L Handbuch

Pentair

Pentair Berkeley B81205 Bedienungsanleitung

Pentair

Pentair JUNG PUMPEN K2 plus Bedienungsanleitung

Pentair

Pentair SHURFLO 4008 RV REVOLUTION Bedienungsanleitung

Pentair

Pentair MNG3SC Bedienungsanleitung

Pentair

Pentair Nocchi VLR Series Bedienungsanleitung

Pentair

Pentair Myers DRY PIT 4VCDP Handbuch

Beliebte Wasserpumpe Handbücher anderer Marken

Neptun

Neptun NPHW 5500 Bedienungsanleitung

Sensidyne

Sensidyne Gilian BDX-II Montage- und Bedienungsanleitung

Draper

Draper 47808 Bedienungsanleitung

Trolla

Trolla 12820 Bedienungsanleitung

Sunfab

Sunfab SVH Series Bedienungsanleitung

WilTec

WilTec 50740 Bedienungsanleitung

Fieldmann

Fieldmann FVC 5015 EK Bedienungsanleitung

Everbilt

Everbilt EFSUB5-122HD Bedienungsanleitung

Graco

Graco Husky 3300e Bedienungsanleitung

esotec

esotec 101018 Bedienungsanleitung

moyno

moyno 2000 CC Bedienungsanleitung

Becker

Becker BASIC VASF 2.80/1-0.AC230 Bedienungsanleitung

Sykes AmeriPumps

Sykes AmeriPumps GP100M Fehlerbehebungshandbuch

DUROMAX

DUROMAX XP WX Series Bedienungsanleitung

BRINKMANN PUMPS

BRINKMANN PUMPS SBF550 Bedienungsanleitung

Franklin Electric

Franklin Electric IPS Bedienungsanleitung

Xylem

Xylem e-1532 Series Bedienungsanleitung

Milton Roy

Milton Roy PRIMEROYAL Bedienungsanleitung