Philips Cafe Gourmet HD5410/00 Bedienungsanleitung
ServiceManual
Philips Domestic Appliances and Personal Care
Published by Philips Domestic Appliances and Personal Care Printed in the Netherlands © Copyright reserved Subject to modification
Coffee Maker “Café Gourmet”
HD5410/00
05/12
PRODUCT INFORMATION
- This product meets the requirements regarding
interference suppression on radio and TV.
- After the product has been repaired, it should function
properly and has to meet the safety requirements as
officially laid down at this moment.
TECHNICAL INFORMATION
- Voltage : 220 - 240 V
- Frequency : 50 Hz
- Power consumption : 1250 W + 50 W
(keep warm element)
- Contents jug : 1000 cc
- Color : Aluminum brushed with
Charcoal Grey plastic parts.
- Filter size : 1 x 2
- Thermostat (T1) switch-off temp. : 125 ± 5 °C
- Thermostat (T2) switch-off temp. : 75 - 15 °C
- Fuse cut-off temp : 172 °C
- SAP coding : HD5410
DISASSEMBLY- AND RE-ASSEMBLY ADVISE
- To remove the swing filter holder proceed as follows:
1. Swing the filter holder open.
2. Push with a small screwdriver the plastic cam inside,
see picture for location.
3. While the cam is pushed inside gently lift the filter
holder up until the lowest pin of the filter holder comes
out of the hinge.
4. Pull downwards the filter holder out of alignment till it
comes loose totally.
HD5410/00
2-5
DISASSEMBLY- AND RE-ASSEMBLY ADVISE
- Assembling tank and heater assy.
1. Clean the rubber sealing ring and glass tank and place
the sealing ring on the glass tank.
2. Place the valve -heating assy and glass tank with rubber
ring onto the housing construction of the Coffeemaker.
3. Mind the position of the glass tank so that the printing
on the glass tank is in line with the PHILIPS printing on
the aluminum housing part.
4. Also important is that the heater assy has been aligned
exactly like the picture.
5. Connect the wires to the right positions and make sure
the routing is the same as the picture shows. (Make sure
the wires coming out from the bar do not touch the
heating element surface to prevent the risk that the wires
will melt, which can result in a dangerous situation!
Also make sure the wires are not lead between screw
bosses and U shaped ribs!)
6. Place the spring and pin (filter click function) see picture
for position.
7. Place the tank base assy (only one position possible) and
tighten the three screws alternately to make sure the
construction will be fixed properly.
8. Don’t forget to place the rubber seal (position 5 exploded
view) back on the tank base.
9. When the construction has been aligned properly the
tank cover can be placed easily on top of the appliance.
Important:
Always check the functionality of the valve construction
and check if there is no leakage by operating the
coffeemaker once or twice with water.
If possible let the coffee maker filled with water in the
tank overnight to check if the construction doesn’t leak.
REPAIR INSTRUCTION
Electrical circuit
- When the appliance does not work, check the electrical
circuit.
- If the element, thermal fuse, thermostats or valve
construction prove defective, the complete heating assy
(element, fuse, thermostat, valve construction) has to be
replaced.
Warning: It is not allowed to unscrew or screw on the
heating assy.
Un-assembly and re-assembly from the heating
assy can end into an unsafe appliance!
E
T1
PTC
T2
S1
ASO switch
!
Spring and Pin
position
Alignment
HD5410/00
3-5
REPAIR INSTRUCTION
Working principle
- When the appliance has been switched on, water in the
tank starts to heat up. (Thermostat contacts (T1) and (T2)
are closed, see electrical scheme).
- When the boiling point has been reached, the memory
spring (M1) in the valve construction will expand and
pushes the rod (R2) downwards.
The hot water flows along thermostat (T2) and rubber valve
(V3), into the coffee filter.
Thermostat contact (T2) will open when the temperature
of 75 °C has reached and switches the heating element off.
The function of thermostat (T1) is only to limit the
temperature of the heating element.
- To start the process again, cold water must be poured via
the tank cover along the memory spring (M1).
The memory spring (M1) will shrink and thermostat
contact (T2) will close again.
The spring (S4) will push the rod (R2) upwards and valve
(V3) will close the water outlet.
De-scaling
- If the water system is nearly or less clogged by scale then
operate the coffeemaker a few times with vinegar or with a
10-15 % solution of either vinegar-acid, citric acid or tartar
acid, into cold tap water.
- Do not use other de-scaling agents as these may harm the
appliance.
- If this procedure does not restore the function, then switch
off the coffeemaker when the acid has passed through
during approximately. 3 min. Keep the appliance in this
condition overnight and continue/repeat the cleaning
operation. After the de-scaling procedure, operate the
coffeemaker twice with tap water in order to rinse away any
residual substances.
OPTIONAL (accessories)
- Commercial trade number : HD7979
(Jug included lid, Charcoal grey)
M1
R2
S4
V3
T2
PARTS LIST
Pos Service code Description
1
2
3
4
5
6
7
8
9965 000 32860
9965 000 32861
9965 000 32862
9965 000 32863
9965 000 32864
9965 000 32865
9965 000 32866
9965 000 32867
Glass tank
Sealingring Glasstank
Filter lock assy (spring + pin)
Tank base assy
Rubber seal, waterreduction
Tanklid, ALU
Heatingelement valve assy
Tank cover
Pos Service code Description
9
10
11
12
13
14
15
4222 247 35400
9965 000 32868
9965 000 32869
9965 000 32870
9965 000 32871
9965 000 32872
9965 000 32873
Coffee spoon
Filter assy
ASO switch
Juglid, charcoal grey
Glass Jug + Juglid
PTC element heater
Base
HD5410/00
4-5
EXPLODED VIEW
!
8
6
7
1
2
4
3
5
HD5410/00
5-5
EXPLODED VIEW
14
9
10
12
13
11
15
Andere Handbücher für Cafe Gourmet HD5410/00
2
Inhaltsverzeichnis
Andere Philips Kaffeemaschine Handbücher
Philips
Philips Essence HD7634 Bedienungsanleitung
Philips
Philips Exprelia HD8854 Bedienungsanleitung
Philips
Philips HD7761 Bedienungsanleitung
Philips
Philips HD7220/22 Bedienungsanleitung
Philips
Philips HD8828 Montageanleitung
Philips
Philips L'OR Barista Bedienungsanleitung
Philips
Philips HD8826 Bedienungsanleitung
Philips
Philips HD7810/95 Bedienungsanleitung
Philips
Philips Saeco Poemia HD8325/09 Bedienungsanleitung
Philips
Philips HD7825/30 Bedienungsanleitung
Philips
Philips SENSEO HD7827 Bedienungsanleitung
Philips
Philips HD7761 Bedienungsanleitung
Philips
Philips HD 5665 Bedienungsanleitung
Philips
Philips Carezza Deluxe RI8525/08 Bedienungsanleitung
Philips
Philips HD7761 Bedienungsanleitung
Philips
Philips HD7690/90 Bedienungsanleitung
Philips
Philips HD5730 Bedienungsanleitung
Philips
Philips HD7546 Bedienungsanleitung
Philips
Philips R2USA013MENBICO Bedienungsanleitung
Philips
Philips HD7818/23 Bedienungsanleitung
