Playcore BigToys MEC-002 Bedienungsanleitung

Issued/Revised:

SHEET 1 OF 3

11/20/19

MEC-002 KID SEAT

1-866-814-8697 bigtoys.com

Parts List

PART NUMBERQTYDESCRIPTIONITEM

4046162

24" BULLNOSE PLANK

404615224" PLANK2

4046092

BENCH LEG

4046221HARDWARE COMPLETE

4021212

ANCHOR ROD

80969316#14 x 1 1/2" SCREW

81740816

1/4" FLAT WASHER (5/8" O.D.)

Items listed below Hardware Complete line are included with Hardware Complete Number

Warning: During Installation, Hardware And Small Parts Are Choking Hazards For Young Children. Store

Unused Parts Appropriately Until Assembly Is Completed. Once Assembly Is Completed, Remove Any

Unused Parts From The Play Environment And Dispose/Save Them In A Secure Location. Any bolt end

protruding more than two full threads beyond the face of the nut causes risk of clothing entanglement.

Promptly cut-off flush, file smooth, and treat to prevent corrosion.

Unless Otherwise Specified, All Units of Measure are Each

Note: Peen Tee-Nuts and Flatwashers to match radius of pipe after assembly is complete.

Note: Loctite (supplied by others) should be used on any non-patch hardware.

INSTALLATION INSTRUCTIONS:

1. Dig footing holes as shown in Elevation and Plan Views.

2. Attach Planks to Bench Legs using 1/4" Flat Washers and #14 Screws as shown in Detail 158. See Finished Assembly view for

Plank locations.

3. Insert Anchor Rods through the bottom hole of the Bench Legs.

4. Place assembled Kid Seat into footing hole.

5. Plumb and level the entire assembly and tighten all fasteners.

6. After Kid Seat is assembled and level, pour concrete footings within 4" to the top and taper away from post for water drainage.

Allow to cure at least 48 hours before use. Temporary bracing may be required until concrete cures.

7. When the structure is finished and satisfactory, eliminate sharp points and sharp edges (burring) on installed hardware like bolts,

nuts etc. Install resilient surfacing material within the use zone of play structure in accordance with ASTM specifications F1292

appropriate for the fall height of each structure. Refer to the safety guidelines.

MAINTENANCE PROCEDURE:

Periodically check hardware for tightness, and tighten as necessary. Always check all parts for breakage or wear, and immediately

put equipment out of service until any faulty parts found are repaired or replaced. Also Check all metal parts for rust, paint loss and

touch-up if necessary with paint. Check for welded areas and verify integrity. Check periodically resilient surfacing for appropriate

depth and remove extraneous materials that could cause injury, infection, or disease. Maintain detailed installation, inspection,

maintenance, and repair records for each public-use playground equipment.

All manuals and user guides at all-guidesbox.com

all-guidesbox.com

Issued/Revised:

SHEET 2 OF 3

11/20/19

MEC-002 KID SEAT

1-866-814-8697 bigtoys.com

ELEVATION VIEW

PLAN VIEW

FINISHED

ASSEMBLY

24" PLANK (404615)

24" BULLNOSE

PLANK (404616)

BENCH LEG

(404609)

1'-0" [30.48 cm]

0'-10" [25.40 cm]

BRICK OR

EQUIVALENT

CONCRETE REQUIRED

.04 CUBIC YARDS

[.03 CUBIC METERS]

1'- 1/2" [31.75 cm]

1'-2" [35.56 cm]

158

All manuals and user guides at all-guidesbox.com

Issued/Revised:

SHEET 3 OF 3

11/20/19

MEC-002 KID SEAT

INCH0

10961114815

712 13

365

1-866-814-8697 bigtoys.com

158

1/4" FLAT WASHER

(5/8" O.D.) (817408)

BENCH LEG

PLANK

#14 x 1 1/2" SCREW

(809693)

All manuals and user guides at all-guidesbox.com

Inhaltsverzeichnis

Andere Playcore Spielgeräte und Spielplatzausstattung Handbücher

Playcore

Playcore ultraPLAY uPLAY TODAY KEEGAN'S KASTLE Bedienungsanleitung

Playcore

Playcore Swing-N-Slide PB 5207 Bedienungsanleitung

Playcore

Playcore BigToys Junior Synchro Bedienungsanleitung

Playcore

Playcore Ultraplay UPLAY-039 Bedienungsanleitung

Playcore

Playcore uPLAY TODAY TIMBER GLEN Bedienungsanleitung

Playcore

Playcore Swing-N-Slide PB 8272T Bedienungsanleitung

Playcore

Playcore uPLAY TODAY BIG SKY Bedienungsanleitung

Playcore

Playcore Swing-N-Slide PB 9240 Bedienungsanleitung

Playcore

Playcore BigToys EC-610 Bedienungsanleitung

Playcore

Playcore uPLAY TODAY SOUTH FORK UPLAY-001-N Bedienungsanleitung

Playcore

Playcore Swing-N-Slide NE 3024 Bedienungsanleitung

Playcore

Playcore BigToys EARLYWORKS MEC-041 Bedienungsanleitung

Playcore

Playcore Swing-N-Slide PB 9242 Bedienungsanleitung

Playcore

Playcore ultraPLAY CARSON'S CANYON Bedienungsanleitung

Playcore

Playcore Swing-N-Slide PB 9240 Bedienungsanleitung

Playcore

Playcore ultraPLAY uPLAY TODAY PIKE'S PEAK Bedienungsanleitung

Playcore

Playcore uPLAY TODAY AIDEN'S PASS Bedienungsanleitung

Playcore

Playcore BigToys earlyworks MEC-007 Bedienungsanleitung

Playcore

Playcore GameTime VistaRope 5960SP Bedienungsanleitung

Playcore

Playcore Swing-N-Slide PB 9241 Bedienungsanleitung

Playcore

Playcore ultraPlay uPlay Today Deep Creek Series Bedienungsanleitung

Playcore

Playcore ultraPLAY uPLAY TODAY TREASURE HOLLOW Bedienungsanleitung

Playcore

Playcore BigToys Navigator Series Bedienungsanleitung

Playcore

Playcore ultraPLAY HAWKS NEST Bedienungsanleitung

Beliebte Spielgeräte und Spielplatzausstattung Handbücher anderer Marken

FUNormous

FUNormous Disney Junior MICKEY MOUSE Bedienungsanleitung

b4Adventure

b4Adventure Slackers TREEZONE ADVENTURE THREE HOUSE Bedienungsanleitung

PoolMaster

PoolMaster 72775 Bedienungsanleitung

Palmako

Palmako 4743142009857 Installationshandbuch

BOERPLAY

BOERPLAY PSTE000.019 Bedienungsanleitung

MGA Entertainment

MGA Entertainment Little Tikes Dunk'n Toss Bouncer Benutzerhandbuch

stilum

stilum Erika Bedienungsanleitung

Costway

Costway NP10816 Bedienungsanleitung

Trigano

Trigano VABI Bedienungsanleitung

Outward

Outward OUT116 Bedienungsanleitung

GALOPIN

GALOPIN ARC02 Bedienungsanleitung

stilum

stilum levis Technische Daten

Ledon

Ledon BASIC Bai LB012 Bedienungsanleitung

BOERPLAY

BOERPLAY PSTE115.002 Bedienungsanleitung

Europlay

Europlay S306 Programmierhandbuch

SportsPlay Equipment

SportsPlay Equipment 361-509H Bedienungsanleitung

Ledon

Ledon 302250 Bedienungsanleitung

Costway

Costway NP10441 Bedienungsanleitung