Playcore BigToys Navigator Series Bedienungsanleitung

Issued/Revised:

SHEET 1 OF 5

09/20/17

BT407 NINA

Play Systems

1-866-814-8697 bigtoys.com

Parts List

PART NUMBER

QTYDESCRIPTION

BT4621SWOOP CLIMB

BT4681

TWISTED TRIDENT

BT4701

SUSPENDED PLAYSHELL

BT477

1HELIX SPINNER

3115362

SINGLE DISK CABLE

3115501DOUBLE DISK CABLE

4040301

UPRIGHT 1

4055031

UPRIGHT 2

4055051UPRIGHT 3

3116451

311349*35" POST TOP COVER

812049*

3/8" x 1/2" P.B.H.C.S. w/PATCH

817451*

3/4" ID BRONZE BEARING

HARDWARE COMPLETE

Items listed below Hardware Complete line are included with Hardware Complete Number

Warning: During Installation, Hardware And Small Parts Are Choking Hazards For Young Children. Store

Unused Parts Appropriately Until Assembly Is Completed. Once Assembly Is Completed, Remove Any

Unused Parts From The Play Environment And Dispose/Save Them In A Secure Location. Any bolt end

protruding more than two full threads beyond the face of the nut causes risk of clothing entanglement.

Promptly cut-off flush, file smooth, and treat to prevent corrosion.

Unless Otherwise Specified, All Units of Measure are Each

Note: Peen Tee-Nuts and Flatwashers to match radius of pipe after assembly is complete.

Note: Loctite (supplied by others) should be used on any non-patch hardware.

INSTALLATION INSTRUCTIONS:

1. Dig footing holes as shown in Ground Plan. See specific installation sheets for Elevation Views.

2. Refer to specific installation sheets for component attachments, hardware, details, and concrete requirements.

3. Attach 5" Post Top Cover to Uprights using 3/8" x 1/2" P.B.H.C.S. w/Patch. See Detail 612.

4. Attach Single Disk Cabe and Double Disk Cable to Tabs located on Uprights. See Detail 355.

5. Plumb and level the entire assembly and tighten all fasteners.

6. After entire discrete unit is assembled pour concrete footings within 4" to the top and taper away from post for water drainage. Allow

to cure at least 48 hours before use. NOTE: Temporary bracing may be required until concrete cures.

7. When the structure is finished and satisfactory, eliminate sharp points and sharp edges (burring) on installed hardware like bolt,

nuts, etc. Install resilient surfacing material within the use zone of play structure in accordance with ASTM specifications F1292

appropriate for the fall height of each structure. Refer to the safety guidelines.

MAINTENANCE PROCEDURE:

Periodically check hardware for tightness, and tighten as necessary. Always check all parts for breakage or wear, and immediately

put equipment out of service until any faulty parts found are repaired or replaced. Also Check all metal parts for rust, paint loss and

touch-up if necessary with paint. Check for welded areas and verify integrity. Check periodically resilient surfacing for appropriate

depth and remove extraneous materials that could cause injury, infection, or disease. Maintain detailed installation, inspection,

maintenance, and repair records for each public-use playground equipment.

SHEET 2 OF 5

09/20/17

BT407 NINA

Play Systems

1-866-814-8697 bigtoys.com

FINISHED ASSEMBLY

=INSTALLATION DETAIL

5" POST TOP COVER

(311349)

UPRIGHT 1

(404030)

UPRIGHT 2

(405503)

DOUBLE DISK CABLE

(311550)

TWISTED TRIDENT

(BT468)

SINGLE DISK CABLE

(311536)

UPRIGHT 3

(405505)

SUSPENDED PLAYSHELL

(BT470)

SINGLE DISK CABLE

(311536)

355

SWOOP CLIMB

(BT462)

HELIX SPINNER

(BT477)

SHEET 3 OF 5

09/20/17

BT407 NINA

Play Systems

1-866-814-8697 bigtoys.com

PLAN VIEW

DOUBLE DISK CABLE

(311550)

UPRIGHT 1

(404030)

TWISTED TRIDENT

(BT468)

SINGLE DISK CABLE

(311536)

SINGLE DISK CABLE

(311536)

SUSPENDED

PLAYSHELL

(BT470)

SWOOP CLIMB

(BT462)

UPRIGHT 2

(405503)

UPRIGHT 3

(405505)

HELIX SPINNER

(BT477)

SHEET 4 OF 5

09/20/17

BT407 NINA

Play Systems

1-866-814-8697 bigtoys.com

10 11

GROUND PLAN

Horizontal Dim.

Vertical Dim.

194 3/4 in

[494.68 cm]

FOOTING TABLE

Hole No. Hor. Dim. Ver. Dim. Diagonal

100 0

278 1/8" 19 11/16" 80 9/16"

391 3/4" 19 5/16" 93 3/4"

484 11/16" 37 3/8" 92 9/16"

55/16" 44 3/4" 44 7/8"

623 11/16" 86 3/8" 89 9/16"

724 5/16" 86 3/8" 89 11/16"

865 3/4" 101 7/16" 120 7/8"

958 11/16" 115 15/16" 129 15/16"

10 17 7/8" 138 5/8" 139 3/4"

11 18 9/16" 138 5/8" 139 13/16"

156 5/8 in

[397.75 cm]

SHEET 5 OF 5

09/20/17

BT407 NINA

INCH0

10961114815

712 13

365

1-866-814-8697 bigtoys.com

612

UPRIGHT

5" POST TOP COVER

(311349)

355

*LOCTITE (SUPPLIED BY

OTHERS) SHOULD BE

USED ON ANY NON-PATCH

HARDWARE.

3/4" I.D. BRONZE

WASHER (817451)

TAB

CABLE

3/8" x 1/2" P.B.H.C.S.

w/PATCH (812049)

Parts List

PART NUMBER

QTYDESCRIPTION

3113951METAL CLIMBER

3113971

3113502SHROUD

8120834

1/4" x 1 1/4" P.B.H.C.S.

817408

1/4" FLAT WASHER (5/8" O.D.)

8010512

3/8" x 5 3/4" HEX HEAD BOLT

817410

3/8" FLAT WASHER

8043532

3/8" LOCK NUT

HARDWARE COMPLETE

Issued/Revised:

SHEET 1 OF 4

BT462 SWOOP CLIMB

1-866-814-8697 bigtoys.com

2/21/2012

*Items listed below Hardware Complete line are included with Hardware Complete Number

Warning: During Installation, Hardware And Small Parts Are Choking Hazards For Young Children. Store

Unused Parts Appropriately Until Assembly Is Completed. Once Assembly Is Completed, Remove Any

Unused Parts From The Play Environment And Dispose/Save Them In A Secure Location. Any bolt end

protruding more than two full threads beyond the face of the nut causes risk of clothing entanglement.

Promptly cut-off flush, file smooth, and treat to prevent corrosion.

Unless Otherwise Specified, All Units of Measure are Each

Note: Peen Tee-Nuts and Flatwashers to match radius of pipe after assembly is complete.

Note: Loctite (supplied by others) should be used on any non-patch hardware.

INSTALLATION INSTRUCTIONS:

1. Dig footing holes as shown in Elevation and Plan Views. Refer to Top View for correct Upright and orientation.

2. Attach Metal Climber to Uprights using 3/8" x 5 3/4" Hex Head Bolt, 3/8" Flat Washer, and 3/8" Lock Nut. See Detail 601.

3. Attach Shroud to Upright using 1/4" x 1 1/4" P.B.H.C.S and 1/4" Flat Washer (5/8" O.D.). See Detail 603.

4. Plumb and level the entire assembly and tighten all fasteners.

IMPORTANT! Avoid creating any gaps between the components which fall between 3-1/2" and 9". It has been shown that such

gaps create entrapment points which can trap a child and cause injury.

5. After entire unit is assembled pour concrete footings within 4” to the top and taper away from post for water drainage. Allow to cure at

least 48 hours before use. Temporary bracing may be required until concrete cures.

6. When the structure is finished and satisfactory, eliminate sharp points and sharp edges (burring) on installed hardware like bolts, nuts,

etc. Install resilient surfacing material within the use zone of play structure in accordance with ASTM specifications F1292 appropriate for

the fall height of each structure. Refer to the safety guidelines.

MAINTENANCE PROCEDURE:

Periodically check hardware for tightness, and tighten as necessary. Always check all parts for breakage or wear, and immediately

put equipment out of service until any faulty parts found are repaired or replaced. Also Check all metal parts for rust, paint loss and

touch-up if necessary with paint. Check for welded areas and verify integrity. Check periodically resilient surfacing for appropriate

depth and remove extraneous materials that could cause injury, infection, or disease. Maintain detailed installation, inspection,

maintenance, and repair records for each public-use playground equipment.

Issued/Revised:

SHEET 2 OF 4

BT462 SWOOP CLIMB

1-866-814-8697 bigtoys.com

2/21/2012

=INSTALLATION DETAIL FINISHED ASSEMBLY COMPONENTS SHOWN IN

HIDDEN LINES ARE SOLD SEPARATELY

METAL CLIMBER

(311395)

SHROUD (311350)

603

601

UNDERNEATH

Issued/Revised:

SHEET 3 OF 4

BT462 SWOOP CLIMB

1-866-814-8697 bigtoys.com

2/21/2012

CONCRETE REQUIRED

0.218 CUBIC YARDS

[0.166 CUBIC METERS]

ELEVATION VIEW

PLAN VIEW

48 15/16 in

[124.33 cm]

30 in

[76.20 cm]

10 in

[25.40 cm]

48 in

[121.92 cm]

REF.

5 3/4 in

[14.61 cm]

36 1/2 in

[92.71 cm]

52 1/4 in

[132.72 cm]

52 9/16 in

[133.52 cm]

--- RESILIENT SURFACE---

20 in

[50.80 cm]

18 in

[45.72 cm]

REF.

18 in

[45.72 cm]

TYP.

BRICK OR EQUIVALENT

Issued/Revised:

SHEET 4 OF 4

BT462 SWOOP CLIMBER

INCH0

10961114815

712 13

365

1-866-814-8697 bigtoys.com

2/21/2012

601

CLIMBER

UPRIGHT

3/8" FLAT WASHER

(817410)

3/8" x 5 3/4" HEX

HEAD BOLT (801051)

3/8" LOCK NUT

(804353)

3/8" FLAT WASHER

(817410)

603

1/4" x 1 1/4"

P.B.H.C.S. (812083)

1/4" FLAT WASHER

(5/8" O.D.) (817408)

SHROUD (311350)

Parts List

PART NUMBER

QTYDESCRIPTION

3114631WAVE ARCH CLIMBER

3115131

3113502SHROUD

8120834

1/4" x 1 1/4" P.B.H.C.S.

817408

1/4" FLAT WASHER (5/8" O.D.)

8010512

3/8" x 5 3/4" HEX HEAD BOLT

8174104

3/8" FLAT WASHER

8043532

3/8" LOCK NUT

HARDWARE COMPLETE

Issued/Revised:

SHEET 1 OF 4

BT468 TWISTED TRIDENT

1-866-814-8697 bigtoys.com

2/21/2012

*Items listed below Hardware Complete line are included with Hardware Complete Number

Warning: During Installation, Hardware And Small Parts Are Choking Hazards For Young Children. Store

Unused Parts Appropriately Until Assembly Is Completed. Once Assembly Is Completed, Remove Any

Unused Parts From The Play Environment And Dispose/Save Them In A Secure Location. Any bolt end

protruding more than two full threads beyond the face of the nut causes risk of clothing entanglement.

Promptly cut-off flush, file smooth, and treat to prevent corrosion.

Unless Otherwise Specified, All Units of Measure are Each

Note: Peen Tee-Nuts and Flatwashers to match radius of pipe after assembly is complete.

Note: Loctite (supplied by others) should be used on any non-patch hardware.

INSTALLATION INSTRUCTIONS:

1. Dig footing holes as shown in Elevation and Plan Views. Refer to Top View for correct Upright and orientation.

2. Attach Wave Arch to Upright using 3/8" x 5 3/4" Hex Head Bolt, 3/8" Flat Washer and 3/8" Lock Nut. See Detail 601.

3. Attach Shroud to Uprights using 1/4" x 1 1/4" P.B.H.C.S and 1/4" Flat Washer (5/8" O.D.). See Detail 603.

4. Plumb and level the entire assembly and tighten all fasteners.

IMPORTANT! Avoid creating any gaps between the components which fall between 3 1/2" and 9". It has been shown that such

gaps create entrapment points which can trap a child and cause injury.

5. After entire unit is assembled pour concrete footings within 4” to the top and taper away from post for water drainage. Allow to cure at

least 48 hours before use. Temporary bracing may be required until concrete cures.

6. When the structure is finished and satisfactory, eliminate sharp points and sharp edges (burring) on installed hardware like bolts, nuts,

etc. Install resilient surfacing material within the use zone of play structure in accordance with ASTM specifications F1292 appropriate for

the fall height of each structure. Refer to the safety guidelines. Ø

MAINTENANCE PROCEDURE:

Periodically check hardware for tightness, and tighten as necessary. Always check all parts for breakage or wear, and immediately

put equipment out of service until any faulty parts found are repaired or replaced. Also Check all metal parts for rust, paint loss and

touch-up if necessary with paint. Check for welded areas and verify integrity. Check periodically resilient surfacing for appropriate

depth and remove extraneous materials that could cause injury, infection, or disease. Maintain detailed installation, inspection,

maintenance, and repair records for each public-use playground equipment.

Andere Handbücher für BigToys Navigator Series

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Playcore Spielgeräte und Spielplatzausstattung Handbücher

Playcore

Playcore BigToys Junior Synchro Bedienungsanleitung

Playcore

Playcore UltraPlay Early Play UP147 Bedienungsanleitung

Playcore

Playcore UltraPlay UPLAY-020-N Bedienungsanleitung

Playcore

Playcore BigToys EARLYWORKS MEC-041 Bedienungsanleitung

Playcore

Playcore ultraPLAY uPLAY TODAY MADDIE'S CHASE... Bedienungsanleitung

Playcore

Playcore GameTime Technisches Handbuch

Playcore

Playcore ultraPLAY uPLAY TODAY TREASURE HOLLOW Bedienungsanleitung

Playcore

Playcore Swing-N-Slide PB 9240 Bedienungsanleitung

Playcore

Playcore BigToys MBT-410 Bedienungsanleitung

Playcore

Playcore Swing-N-Slide PB 9240 Bedienungsanleitung

Playcore

Playcore BigToys MEC-015 Bedienungsanleitung

Playcore

Playcore Swing-N-Slide Mega Rider Bedienungsanleitung

Playcore

Playcore Rain Wheel Bedienungsanleitung

Playcore

Playcore Freenotes Harmony Park Aria 2017 Bedienungsanleitung

Playcore

Playcore Swing-N-Slide PB 5207 Bedienungsanleitung

Playcore

Playcore ultraPLAY uPLAY TODAY CUMBERLAND GAP Bedienungsanleitung

Playcore

Playcore ultraPLAY uPLAY TODAY BOULDER POINT Bedienungsanleitung

Playcore

Playcore Swing-N-Slide PB 9241 Bedienungsanleitung

Playcore

Playcore uPLAY TODAY TIMBER GLEN Bedienungsanleitung

Playcore

Playcore ultraPLAY NatureROCKS 5TSL Bedienungsanleitung

Playcore

Playcore uPLAY TODAY RAINBOW LAKE Bedienungsanleitung

Playcore

Playcore GameTime VistaRope 5960SP Bedienungsanleitung

Playcore

Playcore ultraPLAY uPLAY TODAY SIGNAL SPRINGS... Bedienungsanleitung

Playcore

Playcore uPLAY TODAY BIGHORN Bedienungsanleitung

Beliebte Spielgeräte und Spielplatzausstattung Handbücher anderer Marken

FUNormous

FUNormous Disney Junior MICKEY MOUSE Bedienungsanleitung

b4Adventure

b4Adventure Slackers TREEZONE ADVENTURE THREE HOUSE Bedienungsanleitung

PoolMaster

PoolMaster 72775 Bedienungsanleitung

Palmako

Palmako 4743142009857 Installationshandbuch

BOERPLAY

BOERPLAY PSTE000.019 Bedienungsanleitung

MGA Entertainment

MGA Entertainment Little Tikes Dunk'n Toss Bouncer Benutzerhandbuch

stilum

stilum Erika Bedienungsanleitung

Costway

Costway NP10816 Bedienungsanleitung

Trigano

Trigano VABI Bedienungsanleitung

Outward

Outward OUT116 Bedienungsanleitung

GALOPIN

GALOPIN ARC02 Bedienungsanleitung

stilum

stilum levis Technische Daten

Ledon

Ledon BASIC Bai LB012 Bedienungsanleitung

BOERPLAY

BOERPLAY PSTE115.002 Bedienungsanleitung

Europlay

Europlay S306 Programmierhandbuch

SportsPlay Equipment

SportsPlay Equipment 361-509H Bedienungsanleitung

Ledon

Ledon 302250 Bedienungsanleitung

Costway

Costway NP10441 Bedienungsanleitung