Playcore BigToys Navigator Series Bedienungsanleitung

Issued/Revised:

SHEET 1 OF 5

9/25/2017

BT409 PEAK ADVENTURE

Play Systems

Parts List

PART NUMBER

QTYDESCRIPTION

BT4601EXPLORER WALL

BT4611

CHALLENGE CLIMB

BT4621SWOOP CLIMB

BT4671ACTIVE LINK

BT4681

TWISTED TRIDENT

BT4702SUSPENDED PLAYSHELL

BT4761

NAVICLIMB INVERTED

BT4771

HELIX SPINNER

4024421UPRIGHT 1

4024441

UPRIGHT 2

4024461UPRIGHT 3

4055071

UPRIGHT 4

4024501

UPRIGHT 5

4055091UPRIGHT 6

3115671

311349*

5" POST TOP COVER

812049*123/8" x 1/2" P.B.H.C.S. w/PATCH

HARDWARE COMPLETE

Items listed below Hardware Complete line are included with Hardware Complete Number

Warning: During Installation, Hardware And Small Parts Are Choking Hazards For Young Children. Store

Unused Parts Appropriately Until Assembly Is Completed. Once Assembly Is Completed, Remove Any

Unused Parts From The Play Environment And Dispose/Save Them In A Secure Location. Any bolt end

protruding more than two full threads beyond the face of the nut causes risk of clothing entanglement.

Promptly cut-off flush, file smooth, and treat to prevent corrosion.

Unless Otherwise Specified, All Units of Measure are Each

Note: Peen Tee-Nuts and Flatwashers to match radius of pipe after assembly is complete.

Note: Loctite (supplied by others) should be used on any non-patch hardware.

INSTALLATION INSTRUCTIONS:

1. Dig footing holes as shown in Ground Plan. See specific installation sheets for Elevation Views.

2. Refer to specific installation sheets for component attachments, hardware, details, and concrete requirements.

3. Attach 5" Post Top Cover to Uprights using 3/8" x 1/2" P.B.H.C.S. w/Patch. See Detail 612.

4. Plumb and level the entire assembly and tighten all fasteners.

5. After entire discrete unit is assembled pour concrete footings within 4" to the top and taper away from post for water drainage. Allow

to cure at least 48 hours before use. NOTE: Temporary bracing may be required until concrete cures.

6. When the structure is finished and satisfactory, eliminate sharp points and sharp edges (burring) on installed hardware like bolt,

nuts, etc. Install resilient surfacing material within the use zone of play structure in accordance with ASTM specifications F1292

appropriate for the fall height of each structure. Refer to the safety guidelines.

MAINTENANCE PROCEDURE:

Periodically check hardware for tightness, and tighten as necessary. Always check all parts for breakage or wear, and immediately

put equipment out of service until any faulty parts found are repaired or replaced. Also Check all metal parts for rust, paint loss and

touch-up if necessary with paint. Check for welded areas and verify integrity. Check periodically resilient surfacing for appropriate

depth and remove extraneous materials that could cause injury, infection, or disease. Maintain detailed installation, inspection,

maintenance, and repair records for each public-use playground equipment.

Issued/Revised:

SHEET 2 OF 5

9/25/2017

BT409 PEAK ADVENTURE

Play Systems

FINISHED ASSEMBLY

NAVICLIMB INVERTED

(BT476)

EXPLORER WALL

(BT460)

SUSPENDED

PLAYSHELL

(BT470)

ACTIVE LINK

(BT467)

CHALLENGE CLIMB

(BT461)

SWOOP CLIMB

(BT462)

SUSPENDED PLAYSHELL

(BT470)

UPRIGHT 5

(402450)

UPRIGHT 4

(405507)

UPRIGHT 2

(402444)

UPRIGHT 3

(402446)

UPRIGHT 1

(402442)

=INSTALLATION DETAIL

612

5" POST TOP COVER

(311349)

HELIX SPINNER

(BT477)

TWISTED TRIDENT

(BT468)

UPRIGHT 6

(405509)

Issued/Revised:

SHEET 3 OF 5

9/25/2017

BT409 PEAK ADVENTURE

Play Systems

PLAN VIEW

TWISTED TRIDENT

(BT468)

EXPLORER WALL

(BT460)

UPRIGHT 5

(402450)

UPRIGHT 4

(405507)

SUSPENDED PLAYSHELL

(BT470)

ACTIVE LINK

(BT467)

UPRIGHT 2

(402444)

UPRIGHT 3

(402446)

SWOOP CLIMB

(BT462)

UPRIGHT 1

(402442)

CHALLENGE CLIMB

(BT461)

SUSPENDED PLAYSHELL

(BT470)

NAVICLIMB INVERTED

(BT476)

UPRIGHT 6

(405509)

HELIX SPINNER

(BT477)

Issued/Revised:

SHEET 4 OF 5

9/25/2017

BT409 PEAK ADVENTURE

Play Systems

12 13

19 20

162 9/16 in

[412.98 cm]

Horizontal Dim.

346 1/2 in

[880.04 cm]

VerticalDim.

FOOTING TABLE

Hole No. Hor. Dim. Ver. Dim. Diagonal

148 1/8" 048 1/8"

243 9/16" 13 7/16" 45 9/16"

320 11/16" 17 7/16" 27 1/16"

21 1/8" 21 1/8"

566 3/8" 31 9/16" 73 1/2"

624" 62 11/16" 67 1/8"

724" 62 11/16" 67 1/8"

83/4" 76 9/16" 76 5/8"

93/4" 90 1/8" 90 1/4"

10 1" 103 7/16" 103 7/16"

11 1 1/4" 123 13/16" 123 13/16"

12 12 5/16" 131 1/4" 131 13/16"

13 11 5/16" 139 1/8" 139 9/16"

14 78 13/16" 152 1/8" 171"

15 5 3/4" 171 13/16" 171 15/16"

16 68 1/16" 173 7/8" 186 11/16"

17 46 9/16" 179 1/8" 185 1/8"

18 0 206 11/16" 206 11/16"

19 91 7/8" 230 11/16" 248 5/16"

20 42 1/16" 230 11/16" 234 3/8"

21 0 254 11/16" 254 11/16"

22 60 1/16" 283 7/8" 290 3/16"

23 50 3/8'' 322 5/16" 326 1/14"

24 32 7/8" 329 1/4" 330 15/16"

25 70 5/16" 328 1/2" 335 15/16"

GROUND PLAN

Issued/Revised:

SHEET 5 OF 5

9/25/2017

BT409 PEAK ADVENTURE

INCH0

10961114815

712 13

365

612

UPRIGHT

5" POST TOP COVER

(311349)

3/8" x 1/2" P.B.H.C.S.

w/PATCH (812049)

Andere Handbücher für BigToys Navigator Series

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Playcore Spielgeräte und Spielplatzausstattung Handbücher

Playcore

Playcore Swing-N-Slide PB 8154 Bedienungsanleitung

Playcore

Playcore Swing-N-Slide Mega Rider Bedienungsanleitung

Playcore

Playcore Rain Wheel Bedienungsanleitung

Playcore

Playcore Freenotes Harmony Park Aria 2017 Bedienungsanleitung

Playcore

Playcore ultraPLAY UPLAY-038 Bedienungsanleitung

Playcore

Playcore uPLAY TODAY UPLAY-008-N Bedienungsanleitung

Playcore

Playcore uPLAY TODAY AIDEN'S PASS Bedienungsanleitung

Playcore

Playcore BigToys MEC-002 Bedienungsanleitung

Playcore

Playcore ultraPLAY uPLAY TODAY TREASURE HOLLOW Bedienungsanleitung

Playcore

Playcore BigToys EC-610 Bedienungsanleitung

Playcore

Playcore ultraPLAY HAWKS NEST Bedienungsanleitung

Playcore

Playcore UltraPlay UPLAY-020-N Bedienungsanleitung

Playcore

Playcore GameTime Technisches Handbuch

Playcore

Playcore Swing-N-Slide PB 8272T Bedienungsanleitung

Playcore

Playcore PLAYCRAFT P23-0206 Bedienungsanleitung

Playcore

Playcore BigToys MBT-410 Bedienungsanleitung

Playcore

Playcore ultraPlay uPlay Today Deep Creek Series Bedienungsanleitung

Playcore

Playcore BigToys Junior Synchro Bedienungsanleitung

Playcore

Playcore Swing-N-Slide PB 9240 Bedienungsanleitung

Playcore

Playcore ultraPLAY uPLAY TODAY KEEGAN'S KASTLE Bedienungsanleitung

Playcore

Playcore Ultraplay UPLAY-039 Bedienungsanleitung

Playcore

Playcore ultraPLAY uPLAY TODAY MADDIE'S CHASE... Bedienungsanleitung

Playcore

Playcore Swing-N-Slide PB 9242 Bedienungsanleitung

Playcore

Playcore ultraPLAY NatureROCKS 5TSL Bedienungsanleitung

Beliebte Spielgeräte und Spielplatzausstattung Handbücher anderer Marken

FUNormous

FUNormous Disney Junior MICKEY MOUSE Bedienungsanleitung

b4Adventure

b4Adventure Slackers TREEZONE ADVENTURE THREE HOUSE Bedienungsanleitung

PoolMaster

PoolMaster 72775 Bedienungsanleitung

Palmako

Palmako 4743142009857 Installationshandbuch

BOERPLAY

BOERPLAY PSTE000.019 Bedienungsanleitung

MGA Entertainment

MGA Entertainment Little Tikes Dunk'n Toss Bouncer Benutzerhandbuch

stilum

stilum Erika Bedienungsanleitung

Costway

Costway NP10816 Bedienungsanleitung

Trigano

Trigano VABI Bedienungsanleitung

Outward

Outward OUT116 Bedienungsanleitung

GALOPIN

GALOPIN ARC02 Bedienungsanleitung

stilum

stilum levis Technische Daten

Ledon

Ledon BASIC Bai LB012 Bedienungsanleitung

BOERPLAY

BOERPLAY PSTE115.002 Bedienungsanleitung

Europlay

Europlay S306 Programmierhandbuch

SportsPlay Equipment

SportsPlay Equipment 361-509H Bedienungsanleitung

Ledon

Ledon 302250 Bedienungsanleitung

Costway

Costway NP10441 Bedienungsanleitung