Polivac Terminator Bedienungsanleitung

Polivac Terminator

Carpet Extractor Machine

Operations Manual & Trouble Shooting Guide

Polivac Terminator

Carpet Extractor Machine

Technical Specification

Recovery tank 20 litres

Standard cleaning equipment included

1 x 5 mtr solution hose

1 x 5 mtr vacuum hose

1 x 12 inch 2 jet wand

1 x 15mtr Power cable

Vacuum system 2 x 1100 watt 2 stage tangential motors

Solution Pump 1 x 220 psi sealed electric pump 240v 10A

Fibreglass body with Aluminum sub frame

Switches 3 x Red self-illuminating push button switches.

Water capacity Solution tank 50litres

1. 240v power socket inlet.

2. Vacuum # 1 on/off switch

3. Vacuum # 2 on/off switch

4. Solution Pump on/off switch.

1. Solution outlet fitting.

2. Waste water dump valve

Pictured above shows the waste water dump valve in the up position allowing the water to be

Emptied & disposed of. The valve is a slide gate sealed unit that only requires operator

To lift up to dispense water & to push down to close.

Ensure valve is completely closed before operation to obtain maximum suction.

Pictured above is the water cut off system used in the Terminator. The Float switch cut off

waste water from entering the vac motors.

This is the working position of the float.

1)Please note once dirt water level reach the float switch trigger, whole machine will stop

working.

2)User should then switch off all 3 X round switches. then empty the dirt water tank using

dump valve.

3) please check filter.Tthere may be larger dirt stuck on it.if so need to remove them for better suction.

particles stuck there.if so please remove them

4)User can start the job again.

The above picture shows the exhaust point for the vacuum motors.

If at any stage the operator experiences water coming from this point it indicates

Foam is passing by the filter & this needs to be stopped. Water coming from this point

Can only come thru the vac motors. To prevent foam build up, use an antifoaming

Chemical agent. Do so by pouring a small amount of antifoam solution directly into

Waste tank prior to steam cleaning.

Fig 7

1 x 5mtr solution hose

Fig 8

1 x 12" Floor Wand

Fig 9

Operational instructions for Terminator

1. Connect power cable to 240v socket inlet (Fig 1 # 1)

2. Connect the male end of solution hose (Fig 8) to the solution outlet on machine (Fig2)

3. Connect the female solution hose end to the male connection of the wand trigger (Fig 9)

4. Take the G-vac hose (Fig7) & connect to the wand end & the inlet on the dome.

5. Fill unit with hot or cold water Note Do not exceed 50 degrees Celsius for hot wa

Terminator

Drawings by: LeanSynergicDesign.com.au

Cabinet Assembly

26 6 5 2 3

Terminator

Drawings by: LeanSynergicDesign.com.au

No Code Description

1 PPT000 Fibreglass Body

2 PM054 Dump Valve

3 PPR029 Dump Valve Spout

4 PM027 Pipe 40 mm

5 PPR080 Female Connector

6 PPR051 Brass BRB

7 PM031 Dome Seal

8 PM035 Dome Complete

9 PPR030 Seal

10 PM064 1.1/2'' Male Socket

11 PPR135 Button & Loop Set

12 PPR098 4 X 16 mm Pak Phillip

13 PM028A Pullman / Terminator handle

14 PM055 Plastic Elbow

16 PPT022 Float Switch Bracket

17 PM033 90 Deg Elbow

18 PPR114 Dome Latch

19 AAK854 Rivet

20 PPR177 Screw

21 VLB608 Rubber Washer

22 PPR104 Washer

23 PPR096 Nyloc

24 PPT010 Terminal Label (one set)

25 PPR049 Vent Cover

26 PPR002 Continental Trim

Cabinet Assembly Part List

No Code Description

27 PM037 50 mm Pipe

28 PPR103 Screw

29 PPR128 Washer

30 PVT025 Flat Washer

31 PPR095 M4 Nyloc

32 PM001 Socket

33 PVT029 Pan Phillips

34 AAK838 Rivet

35 PPR035 Float Ball

36 PPR013 Filter Screen

PPR144 Float Switch

37 PM037A Cap for the Filter

Inhaltsverzeichnis

Andere Polivac Bodenreinigungsmaschine Handbücher

Polivac

Polivac Predator MK III Bedienungsanleitung

Polivac

Polivac GAZ20 Bedienungsanleitung

Polivac

Polivac Predator MK II Bedienungsanleitung

Polivac

Polivac GASS38KOH Bedienungsanleitung

Polivac

Polivac Predator MK II Bedienungsanleitung

Polivac

Polivac ST2100 Bedienungsanleitung

Polivac

Polivac Predator MK I Bedienungsanleitung

Polivac

Polivac GAZ24 Bedienungsanleitung

Polivac

Polivac GAZ20 Bedienungsanleitung

Polivac

Polivac Stealth Series Bedienungsanleitung

Beliebte Bodenreinigungsmaschine Handbücher anderer Marken

Nilfisk-Advance

Nilfisk-Advance Advance SC370 17B Bedienungsanleitung

Numatic

Numatic ET 4045 Bedienungsanleitung

HAWK ENTERPRISES

HAWK ENTERPRISES HP1513-180BRUTE Bedienungsanleitung

Mytee

Mytee 8070 Mytee-Lite Bedienungsanleitung

Kärcher

Kärcher B 140 R Bedienungsanleitung

Triple S

Triple S Ace 26T1 Bedienungsanleitung

Nilfisk-Advance

Nilfisk-Advance SW 750 Bedienungsanleitung

Tornado

Tornado Marathon 2000 98190 Handbuch

Windsor

Windsor ADMIRAL Admiral 8 Bedienungsanleitung

Numatic

Numatic TTB 1117/100 Bedienungsanleitung

Tennant

Tennant 8210D Bedienungsanleitung

Nobles

Nobles Frontier Produkthandbuch

lavina

lavina 21-X Bedienungsanleitung

KENT

KENT Edge 28B Bedienungsanleitung

Tennant

Tennant 215 Produkthandbuch

Windsor

Windsor BDP 51/2000C Bedienungsanleitung

CleanFreak

CleanFreak DURA-18HD Bedienungsanleitung

Nilfisk-Advance

Nilfisk-Advance Warrior 34RST Administratorhandbuch