Prince Castle 428-BX Bedienungsanleitung

355 East Kehoe Blvd. zCarol Stream, IL 60188

Tel: (630) 462-8800 zFax: (630) 462-1460

Toll Free: 1-800-PCASTLE (1-800-722-7853)

428-BX 428-513 Printed in the USA 0101 2002

TABLE OF CONTENTS PAGE

Installation............................................................................................. 2

Electrical Specifications .................................................................... 2

Product Identification.......................................................................... 2

Operation .............................................................................................. 3

Preventive Maintenance .................................................................... 4

Cleaning ................................................................................................. 4

Troubleshooting Chart ........................................................................ 5

Exploded View ..................................................................................... 6

Parts List ............................................................................................... 6

Wiring Diagram ..................................................................................... 7

LIMITED WARRANTY

This product is warranted to be free from defects in material and/

or workmanship for a period of two (2) years from date of original

installation. On-location service for failure within 1 year of

installation, proof of purchase will be required.

Any component which proves to be faulty in material and/or

workmanship will be replaced or repaired (at the option of Prince

Castle, Inc.) without cost to the customer for parts or labor.

This warranty is subject to the following exceptions/conditions:

zUse of any non-genuine Prince Castle parts voids this

warranty.

zAll labor shall be performed during regular work hours. Overtime

premium will be charged to the buyer.

zDamage caused by carelessness, neglect, and/or abuse

(e.g., dropping, tampering or altering parts), equipment

damaged in shipment, by fire, flood or an act of God is not

covered under this warranty.

zMotors that fail due to the lack of monthly lubrication will not

necessarily be covered under warranty.

zThis toaster must be serviced by a Prince Castle Authorized

Service Center or a Prince Castle Service Technician. Failure

to do so can void this warranty.

Conveyor Toaster

Model No. 428-BX

Operation

Manual

ELECTRICAL INFORMATION

Model VoltsWatts Amps Hz Plug

428-BX 208 2600 12.5 50/60 6-2OP

Conveyor Toaster

Model No. 428-BX

INSTALLATION

1. After you have removed the toaster from the carton, inspect the unit for signs of damage. If there is damage to the

unit:

zNotify carrier within 24 hours after delivery.

zSave carton and packing materials for inspection purposes.

zContact your local dealer or, if purchased directly, the Prince Castle Customer Sales Department at 1-630-462-8800 to

arrange for a replacement to be sent.

2. Verify that all parts have been received. Remove Protective Coating.

3. Adjust legs so toaster is level.

4. Remove packaging from bun slide and install bun slide in toaster by hooking it into the two pins in the rear of the

chamber.

5. The toaster fan located on the bottom of the toaster in the rear draws in cool room air and circulates it through the

toaster sides and tops. To insure adequate heat dissipation do not position the toaster where the fan would draw in

hot discharge from another appliance.

INTENDED USE

This toaster is designed to toast breads bagels or English

muffins. Do not attempt to toast croissants. Their butter

content will cause them to stick to the conveyor. Do not

attempt to toast products that have been buttered or spread

with jam or other coating Do not attempt to bake in the

toaster.

PRODUCT IDENTIFICATION

Lower Heater

Control Switch

Upper Heater

Control Switch

Speed

Control

Switch

Power

Switch

Extended

Conveyor

Assembly

Bun Ramp

428-BX 428-513 Printed in the USA 0101 2002

OPERATION

Plug unit into the proper voltage receptacle.

Set Power switch to “l” for On.

Turn upper and lower heater controls to

maximum.

Conveyor Toaster

Model No. 428-BX

Allow 20 minutes for toaster to warm up.

Lay Bread, Bagel or Muffin, cut side up

on the extended conveyor and push into

toaster until it slides on to the conveyor

chain. To control toast color, vary the

conveyor speed or the heater settings.

428-BX 428-513 Printed in the USA 0101 2002

The motors used on the Prince Castle Bun

Toasters, require monthly lubrication, 2-3 drops

of 3 in 1 oil. Motors that fail due to the lack of

monthly lubrication will not necessarily be

covered under warranty. We would like to have

field service technicians stress this mainte-

nance requirement whenever failures occur on

these toasters.

Oil Hole

The conveyor chain should not touch the top

surface of the crumb tray holder. If the chain does

touch, retention it by unplugging the unit, remove

both side covers, loosen the front bearing mount-

ing screws and pivot the bearing until the chain

no longer touches. Retighten bearing screws and

replace side covers

Conveyor Toaster

Model No. 428-BX

428-BX 428-513 Printed in the USA 0101 2002

PREVENTATIVE MAINTENANCE

WARNING: Turn off power switch,

unplug toaster from wall outlet, and

let toaster cool down before doing

any repairs. All repairs should be

done by a qualified service techni-

cian.

WARNING: This unit is not water tight.

Do not clean with a water jet or jet

spray. Do not immerse the unit in

water

1. Set the POWER switch to OFF. Allow

toaster to cool for 30 minutes.

2. Unplug toaster.

3. Remove crumb tray and clean toaster and

parts by wiping with damp cloth.

Note: Some units come with a Teflon coated

return chute. Do not use an abrasive cleaning

agent or scrub brush on the Teflon.

CLEANING

Conveyor Toaster

Model No. 428-BX

PROBLEM CAUSE SOLUTION

High limit tripped. Toaster overheating due to Clean any debris from the fan guard

blockage of airflow. that might be blocking the flow.

Airflow fan inoperable. Replace fan .

No power. Circuit breaker tripped. Reset circuit breaker.

Power switch inoperable. Replace power switch.

Broken wire in power cord. Replace power cord.

Toaster conveyor not Conveyor motor inoperable. Lubricate and/or Replace motor.

turning. Conveyor switch inoperable. Replace speed switch.

Motor chain is loose Retension motor chain.

Conveyor bearings worn Replace bearings

Conveyor chain binds Sprockets worn. Replace sprockets.

up in operation. Excessive slack in conveyor Remove a chain link.

chain.

Toaster overheating. Airflow blockage. Clean any debris from fan guard

Airflow fan inoperable Replace fan motor.

Upper and lower heat Heater switch inoperable. Replace heater switch.

tubes not heating. Heater inoperable. Replace heater .

Bread product burning. Conveyor speed too slow. Adjust to proper settings

Bread product too light. Conveyor speed too fast. Adjust to proper settings

Lower heaters heating High Limit Switch Tripped See High Limit Tripped section

but top heaters are not.

428-BX 428-513 Printed in the USA 0101 2002

TROUBLESHOOTING CHART

PARTS LIST

Conveyor Toaster

Model No. 428-BX

428-BX 428-513 Printed in the USA 0101 2002

PN Qty Description

428-108 1 COVER,REAR GM2

428-126 2 COVER,SIDE

428-307 1 IDLER SHAFT ASSY

421-087 1 DRIVE SHAFT ASSY

421-286 2 BEARING,TEFLON REAR

421-287 1 BRACKET,CONVEYOR SHAFT STOP

428-080 1 TRAY,CRUMB

421-071 1 SPROCKET,DRIVE

428-144 1 CHAIN,DRIVE ANSI 25 75 LINKS

428-081 1 CHUTE,BUN SLIDE BX

428-311 1 CHAIN,CONVEYOR,76 LINKS

421-072 1 SPROCKET,IDLER

428-305 1 CONVEYOR,EXTENSION RH

428-306 1 CONVEYOR,EXTENSION LH

428-304 2 BEARING,TEFLON FRONT

428-362 1 GUARD,FRONT PLASTIC

86-312 4 SPACER

86-255 4 LEG,1"HI,1/4-20 MTG STUD,PLAST

70-043 1 KNOB,SPEED CONTROL

428-143 1 LINK,SPRING CLIP CONN. ANSI 25

86-271 1 GUARD,4"TUBEAXIAL FAN

421-090 3 CLIP,SPLICING CONVEYOR

78-173S 2 SWITCH,HEAT CONTROL,240V

70-042 2 KNOB,HEAT CONTROL

78-228S 1 SWITCH,ROCKER DPST ARCO C6053

87-018S 1 MOTOR,GEAR

428-142 1 FAN,4" TUBEAXIAL W/TAPPED HLS

72-159S 1 LINE CORD ASSY

421-274 1 INSULATOR,HIGH LIMIT

428-170S 6 HEATER,550W 69V 12.5"

65-048-10S 1 RELAY,DPDT,30A,220/240 50/60HZ

428-247 1 HEAT SHIELD,428’S

Conveyor Toaster

Model No. 428-BX

428-BX 428-513 Printed in the USA 0101 2002

WIRING DIAGRAM

Inhaltsverzeichnis

Andere Prince Castle Toaster Handbücher

Prince Castle

Prince Castle DCFT-MCD Series Bedienungsanleitung

Prince Castle

Prince Castle 428 Series Bedienungsanleitung

Prince Castle

Prince Castle 428 Series Bedienungsanleitung

Prince Castle

Prince Castle CTD Bedienungsanleitung

Prince Castle

Prince Castle 247 Series Bedienungsanleitung

Prince Castle

Prince Castle DCFT-MCD Series Bedienungsanleitung

Prince Castle

Prince Castle 428-3B Bedienungsanleitung

Prince Castle

Prince Castle DCFT-MCD Series Bedienungsanleitung

Prince Castle

Prince Castle DCFT-BKM Bedienungsanleitung

Prince Castle

Prince Castle 428 Bedienungsanleitung

Prince Castle

Prince Castle 464-B Bedienungsanleitung

Prince Castle

Prince Castle DCFT-MINI-MCD Series Bedienungsanleitung

Prince Castle

Prince Castle 297 Series Bedienungsanleitung

Prince Castle

Prince Castle TX-208BK Bedienungsanleitung

Prince Castle

Prince Castle 454-B Bedienungsanleitung

Prince Castle

Prince Castle 247-ACC Bedienungsanleitung

Prince Castle

Prince Castle TX-230EBKCE Bedienungsanleitung

Prince Castle

Prince Castle IRT-SB-NA-1PS Bedienungsanleitung

Prince Castle

Prince Castle 212-GFCCE Bedienungsanleitung

Prince Castle

Prince Castle TX-230BKCE Bedienungsanleitung

Prince Castle

Prince Castle CTS-W Bedienungsanleitung

Prince Castle

Prince Castle TX-208 Bedienungsanleitung

Prince Castle

Prince Castle 296 Series Bedienungsanleitung

Prince Castle

Prince Castle DCFT-BK Bedienungsanleitung

Beliebte Toaster Handbücher anderer Marken

Taurus

Taurus ARCTIC 960648 Bedienungsanleitung

Redfox

Redfox TO 920 G Bedienungsanleitung

Moulinex

Moulinex LS340D11 Bedienungsanleitung

Amica

Amica TD 3021 Bedienungsanleitung

Electrolux

Electrolux EAT978 Bedienungsanleitung

SEVERIN

SEVERIN SA 9275 Bedienungsanleitung

Breville

Breville the Big One BTS100 Bedienungsanleitung

Sunbeam

Sunbeam TA2540 Bedienungsanleitung

ARENDO

ARENDO 305716 Bedienungsanleitung

Life

Life Crispy AT-001 Bedienungsanleitung

Beko

Beko TAM 6201 I Bedienungsanleitung

Zephir

Zephir ZHC485 Bedienungsanleitung

H.Koenig

H.Koenig TOS9 Bedienungsanleitung

ZIEGELMULLER

ZIEGELMULLER Ritter ET 10 Produkthandbuch

HURAKAN

HURAKAN HKN-TOP3 Bedienungsanleitung

Philips

Philips HD2565 Bedienungsanleitung

Bosch

Bosch DesignLine Plus TAT4P44 GB Series Bedienungsanleitung

Panasonic

Panasonic NT-ZP1-V Bedienungsanleitung