PROEL HP-X series Bedienungsanleitung



1

ServiceManual

HPXSeries



ApplicableModels:

HPX4600

HPX6000



2



TableofContents



1SafetyInstructions............................................................................................................................................... 3

2TechnicalSpecification ........................................................................................................................................ 4

3BlockDiagram...................................................................................................................................................... 5

4SignalFlowchart .................................................................................................................................................. 6

5MalfunctionAnalysisonSMPS(PowerSupply)................................................................................................... 7

6MalfunctionAnalysisonInputModule ............................................................................................................. 12

7MalfunctionAnalysisonDisplayModule .......................................................................................................... 13

8MalfunctionAnalysisonPre‐AmplifierModule ................................................................................................ 14

9MalfunctionAnalysisonProtectionModule..................................................................................................... 16

10MalfunctionAnalysisonPowerOutputStageModule................................................................................... 17

11SpecialNotes ................................................................................................................................................... 18



3

1SafetyInstructions

1.1Duetohighvoltageinternal,pleasebecarefulduringtroubleshootingandmaintenancecourse.

Pleasereadtheusermanualandthismaintenancemanualfirst.

1.2Duetothewrongoperationincheckingandrepairingcoursewillresultstoruineddamageonsomeparts,sopleaseoperate

followthismanual.

1.3ThemaintenancepersonmustbeONLYaqualifiedprofessionalpersonnelauthorizedbyPROEL.

1.4Don’treplacethekeydevicesandadjusttheadjustablepotentiometersbyyourself,itwillchangetheparameterofthe

equipment.

1.5Pleasecutoffthepowertoguaranteethesafetyoftheservicepersonwhenrepairing.

1.6Thedevicesmarked  inthedrawingindicatesakeydevice,pleasereplaceitONLYwithasparepartspecifiedbyPROEL.



4

2TechnicalSpecification

MODELHPX4600HPX6000

Power8ohm*850W1200W

Power4ohm*1400W2000W

Power2ohm**2300W3000W

PowerBRIDGE8ohm*3000W4100W

PowerBRIDGE4ohm**4600W6000W

OutputStageClass3H

Frequencyresponse(+0/‐0.5dB)20Hz‐20KHz

InputSensitivity(selectable)0.775Vrms(0dBu)/1.0Vrms(0dBV)/32dB(fixedGAIN)

InputConnectors/ImpedanceXLRM(withXLRFLINK),20Kohm(balanced),10Kohm

(unbalanced)

OutputConnectorsSPEAKONandBindingPost

DampingFactor>200

SlewRate>20V/uS

S/NRatio(unweighted)>90dB

THD+N<0.1%

ControlsINPUTLEVEL,INPUTSENSITIVITY,STEREO/BRIDGE/PARALLEL,SOFT

CLIPPING

LEDIndicatorsPOWER,ON,PARALLEL,BRIDGE,SIGNAL,LIMIT,PROTECT

CoolingVariablespeedDCfan

ProtectionsAClowpower,DC,thermal,shortcircuit,VHF,CLIPlimiter,SOFT

CLIPlimiter

MainsSupplyVoltage230VAC(±10%)50/60Hzor120VAC(±10%)50/60Hz

MaximumConsumption2330VA3320VA

RatedConsumption***620VA830VA

StandbyConsumption5VA6VA

Dimensions(WxHxD)483x89x505mm19"x3.5"x19.9"(2Urack)

Weight13Kg(28.7lb)13,6Kg(29.9lb)

*RMSbothchannelTHD<1%

**40msburst

***Ratedconsumptionismeasuredwithpinknoisewithacrestfactorof12dB,thiscanbeconsidered

astandardmusicprogram.



5

3BlockDiagram

3.1HPX4600/HPX6000BlockDiagram:



6

4SignalFlowchart







7

5MalfunctionAnalysisonSMPS(PowerSupply)

5.1CircuitDiagramofAuxPowerSupplyModule:



5.2MalfunctionAnalysisonAuxPowerSupplyModule:



Sequence

No.

Circuitto

check

MostProbablyFailures

1

AuxPower

Supply

Board

STYLEDisoff;theequipmentisunavailabletostart.

‐Checkthecircuit,seeiftheCN1pinandthecopperfoilofAuxPower

Supplyisbroken;Whenamplifierconnectstopowersupply,theAux

PowerSupply(self‐activatedswitch)willstarttowork,itprovidestwo

groupstandbypowersupply+5V&+16V.Amongthem,CN3/+5Visfor

poweron/offled(orange),CN1/12foot/+16Visforthemainpower

controlboard,themainpoweron/offiscontrolledbytheCN4/(1)(3)in

plug.WhentheCN4/(1)(3)isclosed,OP3/817willbeconnected,

Q2/8050willbedownedtolowlevel(VPI).

RepairingGuide:Whenrepairingthepowerboard,pleasecuttheDC/300Vfuse,seriesconnecta

100W—200Wlamptostartthemachine,preventingthedamageofrelateddevicewhenrepairing.



8



5.3CircuitDiagramofSMPSControlModule:



5.4MalfunctionAnalysisonSMPSControlModule:



Sequence

No.

Circuit

Function

Failure

1SMPSControl

‐Theequipmentisunavailabletostart;

‐Protectionfunctionwillbeactivatedwheninlowimpedanceoutput;

‐Cyclicprotectionoftheswitchpower;

‐Delaystart,over‐voltagePROT,low‐voltagePROTandovercurrent

PROT.

RepairingGuide:

1)Whenrepairingthecontrolboard,youcancuteveryprotectcircuitgraduallyfoundthedefective

area!



9

5.5CircuitDiagramofEMCModule:



5.6MalfunctionAnalysisonEMCModule:



Sequence

No.

Circuit

Function

Failure

1LineFilter

‐RestrictiononEMIandRFITheequipmentisunavailableto

start‐up,theACfuseoftherearpanelisburntwhenconnectedthe

electricitychecktheRT1componentandseeifthereisshortcircuit.



5.7CircuitDiagramofLowVoltagecontrolcircuit:



10

5.8MalfunctionAnalysisonLowVoltagecontrolcircuit:



Sequence

No.

Circuit

Function

Failure

1Low‐voltage

Control

‐Theequipmentcannotbestarted:LM2596zenerwilloutput

‐onegroup+24V,providedpowersupplyfortherelay,fansand

LEDonfrontpanel.Amplifierprotection:±15Vpowersupplyis

abnormal.Fansarestopped,quickorslowworking.Soft‐start

resistorisburntonpowersupply.

‐Connectingthejumperof110VandACIport,thedoublevoltage

rectifierwillletthecircuitworkwith110Vand120Vmainsvoltage.

RepairingGuide:

Equipmentcannotbestarted,buttheLEDoncontrolboardisnormal.Pleasecheckifthe+24V

powersupplyofCN6connectorisnormalornot.



5.9CircuitDiagramofSMPSPSUModule:



5.10MalfunctionAnalysisonSMPSPSUModule:



Sequence

No.

Circuit

Function

Failure

1

Soft‐start/

Rectifier

Filter

‐Smokecomesoutbutstillworkswhenpoweroutput,focusto

checkwhethertherelaydoesnotpull‐inresultsNPTR1,NPTR2

thermistorburntduetoover‐current;

‐Connectthejumperof110VandACIporttoformthevoltage

doublingrectifyingcircuit,thenitcanworkin110Vand120Vvoltage

program;

‐Rectifiedfiltercircuitshort‐circuitandcauseburntoftheACinput

Andere Handbücher für HP-X series

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere PROEL Verstärker Handbücher

PROEL

PROEL ACDT180V Bedienungsanleitung

PROEL

PROEL AMP240V4 Bedienungsanleitung

PROEL

PROEL HP-X series Bedienungsanleitung

PROEL

PROEL HPD3400 Bedienungsanleitung

PROEL

PROEL AMP03VR Bedienungsanleitung

PROEL

PROEL AMP03 Bedienungsanleitung

PROEL

PROEL AXIOM DSO26 Bedienungsanleitung

PROEL

PROEL AMIX63 Bedienungsanleitung

PROEL

PROEL ACDT90 Bedienungsanleitung

PROEL

PROEL AMP35E Bedienungsanleitung

PROEL

PROEL HPAMP104 Bedienungsanleitung

PROEL

PROEL Axiom HPD3400PFC Bedienungsanleitung

PROEL

PROEL HPD2004 Bedienungsanleitung

PROEL

PROEL DPX1000 Bedienungsanleitung

PROEL

PROEL PMA 120 Bedienungsanleitung

PROEL

PROEL PRL250 Bedienungsanleitung

PROEL

PROEL AMP120XL Bedienungsanleitung

PROEL

PROEL AMP 240Z4 Bedienungsanleitung

PROEL

PROEL PRL Series Betriebsanleitung

PROEL

PROEL ACDT180 Bedienungsanleitung

PROEL

PROEL ACDT90 Bedienungsanleitung

PROEL

PROEL HPD2004 Bedienungsanleitung

PROEL

PROEL PSW2600 Bedienungsanleitung

PROEL

PROEL DPX1200PFC Bedienungsanleitung

Beliebte Verstärker Handbücher anderer Marken

ASTRO

ASTRO HVO V40 P Bedienungsanleitung

Marantz

Marantz SUPERSCOPE BLA-545 Montageanleitung

NAD

NAD CI980 Bedienungsanleitung

Technics

Technics SE-CH770 Bedienungsanleitung

Harman Kardon

Harman Kardon HK6300 Bedienungsanleitung

NAD

NAD T975 Bedienungsanleitung

McIntosh

McIntosh MA6850 Bedienungsanleitung

Electro-Harmonix

Electro-Harmonix ENGLISH MUFF’N Bedienungsanleitung

Viatron

Viatron Autrix Bedienungsanleitung

GME

GME GA9800 Bedienungsanleitung

Atlas

Atlas CP700 Bedienungsanleitung

Roland

Roland KC-1000 Bedienungsanleitung

Pyle

Pyle PFMRA350BW Bedienungsanleitung

Advantage

Advantage S-250 Bedienungsanleitung

IRT Electronics

IRT Electronics DVA-3007 Bedienungsanleitung

Dimavery

Dimavery BA-100 Series Bedienungsanleitung

Sony

Sony XM-S400D Bedienungsanleitung

Schertler

Schertler ROY X Bedienungsanleitung