Quadra-Fire MT VERNON STOVE AE Konfigurationshandbuch

www.quadrare.com 7014-139F June 27, 2008

MT VERNON STOVE AE & MT VERNON INSERT AE

Heat Exchanger & Exhaust Cleaning Instructions

Refer to your Owner’s Manual for complete cleaning

instructions for all components.

For trouble free use of your pellet appliance you must perform cleaning

as called for in these instructions. Not doing so will result in:

• Poor operating performance

• Smoke spillage into the home

• Overheating of components

Not properly cleaning your appliance on a regular basis will void your

warranty.

WARNING

Fire Risk

Page 2 7014-139F June 27, 2008

FIREPOT MAINTENANCE

The repot oor and repot air holes will need to be

scraped occasionally depending on the quality of fuel

being used. Use a putty knife, a at head screwdriver

or the repot clean-out tool provided to remove excess

carbon from the repot.

Firepot Air

Holes Firepot

Floor

Firepot Exploded View

Baffle

Latches

Ashpan

Heat Exchanger

Insert flat head screwdriver into “V”

section and push down and the

bottom of the latch will fall forward

off of post

Locating ears - 1 on

each side. Fit behind

bottom edge

Set the wall control thermostat to “OFF” on AUTOMATIC/

MANUAL SETTING screen and let the appliance com-

pletely cool. The exhaust blower must be off before you

can unplug the appliance before servicing.

2. Smoke spillage into the room can occur if the appliance

is not cool before unplugging.

The appliance must be in complete shutdown, completely

cool and the exhaust blower off before performing any

cleaning or maintenance. There is a risk of shock if

the appliance is not unplugged before servicing the

appliance.

PROPER SHUTDOWN PROCEDURE

NOTE: Performing this routine service will require approximately 20

minutes a month depending on type and quality of fuel you burn.

CAUTION

CLEANING OR FREQUENCY DAILY WEEKLY

INSPECTION

FIREPOT

Softwood Pellets

FIREPOT

Hardwood Pellets

Every 5 bags

Every 3 bags

FIREPOT

Corn, Wheat, or Sun-

ower Seeds

Every 1 bag

ASHPAN

Wood Pellets

Every 5 bags

HEAT EXCHANGER Every 1 ton of

fuel

-OR-

EXHAUST BLOWER Every 3 tons of

fuel

-OR- X

ASHPAN

Alternate Fuel X

-OR-

Daily

EVERY 2

WEEKS

YEARLY

June 27, 2008 7014-139F Page 

Tools Needed: Shop Vac* and Micro Cleaning Kit*; at head

and Phillips screwdriver; 11/2 Nut-driver or wrench.

* Shop Vac and Micro Cleaning Kit

can be purchased at your local hardware store.

Figure 4

1. It is necessary to remove the bafe to gain access

to the heat exchanger. Complete instructions for

removing the bafe can be found in your Owner’s

Manual.

2. Vacuum the ash from the heat exchanger with an

upholstery brush to remove the majority of the ash.

Be sure to vacuum the back of the bafe also.

Inspect the drop tube and remove any residue build-

up in the drop tube. Figure 2.

se the crevice tool to nish cleaning the heat

exchanger ns. It is critical that the 2 exhaust exits

at the back of the rebox oor (left and right) be

thoroughly cleaned. Figure 4. There are several

ways this can done.

a. Use the crevice tool.

b. Attach a hose 1/2 inch (12.7mm) in diameter

and approximately 2 feet (607mm) in length to

your vacuum hose.

Use a bottle brush and push the ash down to

the bottom. Remove the combustion (exhaust)

blower and then vacuum out the ash. Figures

5 through 8 on page 4.

2 exhaust exits (left and right side) must

be thoroughly cleaned. Each exit is

approximately 4 inches wide, 1 inch

across and 3 inches deep.

.

Assemble the crevice tool from the Micro Cleaning

Kit to attach to a Shop Vac. Figure 3.

Figure 2

Figure 3

Figure 1 - Example of a dirty heat exchanger

Page  7014-139F June 27, 2008

Figure 9

Vacuum out the exhaust area.

Loosen all 6 screws, but do NOT Remove

5. Removing the Combustion (Exhaust) Blower

Figure 5

Figure 8

Figure 7 - Stove is shown in this example

Set blower on top of housing.

Do not disconnect the wires.

Figure 6

a. The combustion blower is mounted in the bottom

right rear of the appliance. Figure 5.

b. Use an 11/2 nut driver to loosen all 6 nuts, but do

not remove. Rotate the blower and remove from

the housing. Figure 6.

c. Set the blower on the top of the housing for the stove

and place on the rebox oor for the insert. You do

not need to disconnect the wires. Figure 7.

d. Vacuum out the exhaust area. Figure 8. You

may need to replace the gasket at this time also.

Order part SRV7000-2.

A view of the inside of the exhaust area. Figure 9.

BLOWER LOCATION ON STOVE

Combustion Blower

BLOWER LOCATION ON INSERT

Remove (6) Nuts

Remove

Side

Panel

Combustion Blower

Dieses Handbuch passt für folgende Modelle

Andere Quadra-Fire Kamin im Innenbereich Handbücher

Quadra-Fire

Quadra-Fire SANTAFEI-MBK Sicherheitsleitfaden

Quadra-Fire

Quadra-Fire Direct Vent Gas Fireplace Insert Bedienungsanleitung

Quadra-Fire

Quadra-Fire Village QVI35 Montageanleitung

Quadra-Fire

Quadra-Fire COLUMBIA BAY Bedienungsanleitung

Quadra-Fire

Quadra-Fire 5100 ACC Bedienungsanleitung

Quadra-Fire

Quadra-Fire MTVERNINSAE-MBK Bedienungsanleitung

Quadra-Fire

Quadra-Fire VOYA-GRAND-MBK Bedienungsanleitung

Quadra-Fire

Quadra-Fire 31I-ACC Bedienungsanleitung

Quadra-Fire

Quadra-Fire 31I-ACC Bedienungsanleitung

Quadra-Fire

Quadra-Fire 27I-ACC Bedienungsanleitung

Quadra-Fire

Quadra-Fire 21M-ACC-C Bedienungsanleitung

Quadra-Fire

Quadra-Fire QV26E-B Bedienungsanleitung

Quadra-Fire

Quadra-Fire FireBrick qvi25fb Montageanleitung

Quadra-Fire

Quadra-Fire BODBAY Bedienungsanleitung

Quadra-Fire

Quadra-Fire 57ST-ACC-AU Bedienungsanleitung

Quadra-Fire

Quadra-Fire 31I-ACC Bedienungsanleitung

Quadra-Fire

Quadra-Fire MTVERNINSAE-MBK Bedienungsanleitung

Quadra-Fire

Quadra-Fire CASTILE Series Bedienungsanleitung

Quadra-Fire

Quadra-Fire QV32E (120V) Handbuch

Quadra-Fire

Quadra-Fire QFP38-LP Bedienungsanleitung

Quadra-Fire

Quadra-Fire EXPIII-MBK-APAC Bedienungsanleitung

Quadra-Fire

Quadra-Fire QFP 30 Handbuch

Quadra-Fire

Quadra-Fire HUDBAY-INS Bedienungsanleitung

Quadra-Fire

Quadra-Fire MTVERNINSAE-MBK Bedienungsanleitung

Beliebte Kamin im Innenbereich Handbücher anderer Marken

Brigantia

Brigantia 35-DVRS31N-2 Betriebsanleitung

Nordpeis

Nordpeis Bergen Bedienungsanleitung

Superior

Superior BCT2536TMN Bedienungsanleitung

Renaissance

Renaissance RUMFORD 1000 Bedienungsanleitung

Lacunza

Lacunza IV-800 Bedienungsanleitung

Baxi

Baxi 940 Gebrauchsanweisung

Dru

Dru Maestro 60/2 Tall RCH Bedienungsanleitung

Diamond Fireglass

Diamond Fireglass SS-O22 Bedienungsanleitung

HearthStone

HearthStone Windsor Bay 8830 Programmierhandbuch

Napoleon

Napoleon ASCENT B42 Bedienungsanleitung

Enviro

Enviro E33GI Bedienungsanleitung

Smeg

Smeg L30 FABE Montageanleitung

KEDDY

KEDDY K700 Bedienungsanleitung

Godin

Godin 3451 Bedienungsanleitung

Jøtul

Jøtul Jotul GI 535 DV IPI New Harbor Bedienungsanleitung

Desa

Desa CCFPDFT Bedienungsanleitung

Miles Industries

Miles Industries Vogue 1300IRN Handbuch

Regency Fireplace Products

Regency Fireplace Products Pro Series Kurzanleitung