Raypak 751-1501 Bedienungsanleitung

Catalog No.: 2000.36G Effective: 2-1-08 Replaces: 5-1-05

Job:

Engineer:

Contractor:

Prepared By: Date:

Model: Indoor/Outdoor:

100% Factory Fire Tested

Efficiency: 84%

Maximum Outlet Temperature: 230°F

Minimum Non-Condensing Inlet Temperature: 105°F

Thermal Shock Proof Heat Exchanger

Footprint: Less Than 5-1/2 ft2

Limited Twenty-Year Thermal Shock Warranty

Limited Ten-Year Heat Exchanger Warranty

Ten-Year Unconditional Burner Head Warranty

Operation Status Center and Full Diagnostic Panel

Heat Exchanger

Bronze Headers

ASME Inspected and Stamped

160 PSIG Working Pressure

National Board Approved

Copper-finned Tubes

ASME Steel Tube Retainer

Silicone High Temp O-Rings

60 PSIG ASME Pressure Relief

Valve

Temperature and Pressure Gauge,

Shipped Loose

Control

120V, 60Hz, Power Supply

120/24V 60Hz Transformer

100% Pilot Shutoff/Lockout

Electronic Intermittent Ignition Pilot

(IID)

High Limit Control, Manual Reset

High Limit Control, Auto Reset

On/Off Switch

Flow Switch

Blocked Vent Pressure Switch

Combustion Air Proving Switch

Time Delay Pump Off Control

Central Point Wiring Diagnostics

Panel

Burner

Aerodynamically Stabilized

Non-Clog Burner

Ultra-Low NOx: Less than 30 PPM

Gas Train

Fuel

Natural Gas

Propane (Models 751 & 1001)

Manual Gas Shut-off Valves

Gas Pressure Regulator

Safety Shut-off Valve

Firing Control Valve

Manual Low Gas Pressure Switch

On/Off Firing Mode (H4)

Design Certified ANSI Z21.13/

CSA 4.9

Construction

Indoor/Outdoor Construction

Front Controls Enclosed

PolyTuf Powder Coat Finish

Connections (Water, Electrical,

Gas)

Rear – Standard

Right Side – Option A-8

Venting

Vent Location

Rear – Standard

Right Side – Option Z-2

Vent Termination Cap

Outdoor - Option D-11

Indoor, Horizontal – Option D-15

Indoor, Vertical (by others)

Temperature Controls

B-20 Single-Stage Controller,

100-200°F

B-6 2-Stage Controller, 100-200°F

B-21 4-Stage TempTracker Digital

Controller, Loose

B-23 4-Stage TempTracker Digital

Controller, Outdoor Reset, Loose

Y-241 Electronic Sequencer,

1-4 Stages

Y-281 Electronic Sequencer,

5-8 Stages

Additional Safety Controls (Optional)

F-10 Low Water Cut-off,

Remote Probe

S-2 Manual High Gas Pressure

Switch

Regulatory Agency Requirements

C-5 Ignition Lockout Module

Other Equipment

Condensing Heat Exchanger

Pump

ADB™ - Type H

Hydronic Heating Boilers

Models 751-1501

Catalog No.: 2000.36G Effective: 2-1-08 Replaces: 5-1-05

ADB – Type H

Models 751-1501 Model

MBTUH B D E F G H K M P

Ship

Weight Foot-

print Amps*

Model Input Output Height NPT NPT

Flue ∅(Lbs.) (Ft2)

H 751 750 630 64 38 44-1/2 29-3/4 1-1/2 2 8 17-3/4 41 680 5.4 8

H 1001 999 840 72 46 52-1/2 37-3/4 1-1/2 2-1/2 10 21-1/2 49 720 5.4 10

H 1501 1499 1260 82 56 62-1/2 47-3/4 1-1/2 2-1/2 12 20-1/4 59 780 5.4 12

- Dimensions are in inches.

- Ratings shown are for elevations up to 5,000 feet. For installations at elevations

above 5,000 feet, please consult the factory for additional instructions.

- For direct vent applications, please contact the factory about relocating the pump.

* Current draw does NOT include pump.

(Supply breaker must have delayed trip.)

RATES OF FLOW AND PRESSURE DROPS

20°F ∆T 30°F ∆T 40°F ∆T Maximum Flow Minimum Flow

Model GPM

∆P (ft.) GPM ∆P (ft.) GPM ∆P (ft.) GPM ∆P (ft.) ∆T (°F) GPM ∆P (ft.) ∆T (°F)

H 751 63 5.8 42 2.9 32 1.8 110 17.0 11 32 1.8 40

H 1001 84 11.8 56 5.6 42 3.4 110 20.0 15 42 3.4 40

H 1501 126 31.4 84 14.9 63 9.1 126 31.4 20 63 9.1 40

Certified Clearances

Front 24” (for service)

Rear 12” (water side)

Right 1”

Left 1”

Top 0” (see note 1)

Floor 0” (see note 2)

Vent 1”

Notes:

1. 24” required for service

2. DO NOT install on carpeting

Raypak, Inc. 2151 Eastman Avenue, Oxnard, CA 93030 (805) 278-5300 Fax (800) 872-9725 www.raypak.com

Dieses Handbuch passt für folgende Modelle

Andere Raypak Kessel Handbücher

Raypak

Raypak 0133-4001 Bedienungsanleitung

Raypak

Raypak XFYRE 500 Bedienungsanleitung

Raypak

Raypak RAYTHERM H-962 Bedienungsanleitung

Raypak

Raypak HI DELTA HD101 THRU 2342B Leitfaden

Raypak

Raypak 0133-4001 Bedienungsanleitung

Raypak

Raypak MVB 504A Montageanleitung

Raypak

Raypak 302BE-902BE Bedienungsanleitung

Raypak

Raypak H-0030B Leitfaden

Raypak

Raypak 503-2003 Handbuch

Raypak

Raypak Xtherm 1005 Handbuch

Raypak

Raypak XFYRE 500 Leitfaden

Raypak

Raypak RAYTHERM 0042B Handbuch

Raypak

Raypak H7 504-2004 Bedienungsanleitung

Raypak

Raypak 399B-2339B Handbuch

Raypak

Raypak 503-2003 Bedienungsanleitung

Raypak

Raypak FlexGas 302BD Bedienungsanleitung

Raypak

Raypak 241275 Bedienungsanleitung

Raypak

Raypak Raytherm H-2100 Bedienungsanleitung

Raypak

Raypak XVers 856-3006 Leitfaden

Raypak

Raypak RAYTHERM H-0042 Bedienungsanleitung

Raypak

Raypak XPAK 85 Leitfaden

Raypak

Raypak 504-2004 Leitfaden

Raypak

Raypak HI DELTA 302B Handbuch

Raypak

Raypak Xtherm 1005 Einrichtungshandbuch

Beliebte Kessel Handbücher anderer Marken

Vaillant

Vaillant uniSTOR VIH SW GB 500 BES Bedienungsanleitung

Radijator

Radijator BIO max 23.1 Bedienungsanleitung

Brunner

Brunner BSV 20 Bedienungsanleitung

Buderus

Buderus Logamax GB062-24 KDE H V2 Bedienungsanleitung

Potterton

Potterton 50e Datenblatt

UTICA BOILERS

UTICA BOILERS TriFire Bedienungsanleitung

Joannes

Joannes LADY Series Handbuch

ECR International

ECR International UB90-125 Gebrauchsanweisung

Froling

Froling FHG Turbo 3000 Bedienungsanleitung

Froling

Froling P4 Pellet 8 - 105 Bedienungsanleitung

U.S. Boiler Company

U.S. Boiler Company K2 Bedienungsanleitung

Henrad

Henrad C95 FF Bedienungsanleitung

NeOvo

NeOvo EcoNox EF 36 Bedienungsanleitung

Potterton

Potterton PROMAX SL 12 Bedienungsanleitung

Eco Hometec

Eco Hometec EC 25 COMPACT Bedienungsanleitung

Viessmann

Viessmann VITODENS 200 Leitfaden

Baxi

Baxi Prime 1.24 Bedienungsanleitung

REXNOVA

REXNOVA ISA 20 BITHERMAL Bedienungsanleitung