Raypak Raytherm H-2100 Bedienungsanleitung

Catalog No.: 2000.26M Effective: 12-1-07 Replaces: 12-1-99

Job:

Engineer:

Contractor:

Prepared By:

Model: Date:

EFFICIENT

82% thermal efficiency – highest of any atmospheric

boiler available today

THERMAL SHOCK PROOF

Twenty-year warranty against thermal shock damage

up to 150°F differential

Maximum operating temperature: 230°F

LIGHTWEIGHT

A floor load of 70 lbs./sq. ft. or less

HIGH RECOVERY

Cuts fuel costs substantially because the standby and

radiation losses normal to other boilers and tank-type

water heaters are eliminated

LOW WATER OPERATING TEMPERATURE

Operates with water temperature as low as 105°F

without condensing

Heat Exchanger

ASME Inspected and Stamped

160 PSIG

National Board Approved

Headers

Glass-lined Cast Iron – Standard

Bronze – Option A-1

Finned Tubing

Copper – Standard

Cupro Nickel – Option A-3

ASME Steel Tube Sheet

Silicone O-Rings

60 PSIG ASME Pressure Relief Valve

Temperature and Pressure Gauge

(Boiler)

Water Connections

Left Hand – Standard

Right Hand – Option A-6

Flow Configuration

Two-pass (Standard)

Single-pass (Cast Iron Only)

Controls

120V, 60Hz, 1 Ph Power Supply

120/24V Transformer

100% Pilot Shut-off/Lockout

Electronic, Intermittent Ignition (IID)

Pilot

High Limit Control, Manual Reset

High Limit Control, Auto Reset –

Models 3001-4001

On/Off Switch

Flow Switch

Economaster II Pump Time Delay

Gas Control Train

Manual Main Gas Shut-off Cock

Main Gas Pressure Regulator

Redundant Safety Shut-off Valve

Control Valve

Firing Mode

On/off (H4)

Two-stage Firing (H3)

Four-stage Firing (H9)

Motorized Modulation (H2)

B-6000 (H6)

Fuel

Natural Gas

Propane Gas

Design Certified ANSI Z21.13/

CSA 4.9

Construction

Front Controls

Stainless Steel Burners

Polytuf Powder Coat Finish

Built-in Draft Diverter

Draft Inducer

Motorized Draft Inducer –

Option D-2

Temperature Controllers

B-7 Modulating

B-5 Modulating, Outdoor Reset

B-6 Two-stage

B- Four-stage Digital

Y-241 Electronic Sequencer,

1-4 Stages

Y-281 Electronic Sequencer,

1-8 Stages

Additional Safety Controls

F-9 Low Water Cut-off Probe

I-1 High Limit Control,

Auto Reset

S-1 Low Gas Pressure Switch

S-2 High Gas Pressure Switch

Regulatory Agency Requirements

Raytherm

- Type H

Hydronic Heating Boilers

Commercial

Models 2100-4001 (Indoor)

Fig. 8184

Catalog No.: 2000.26M Effective: 12-1-07 Replaces: 12-1-99

Raytherm - Type H

Hydronic Heating Boilers Model

MODELS H 2100 THRU 4001

MBTUH Dimensions (inches) Approx.

Model Natural Gas Width Overall Height Gas Conn. Water Conn. Flue Dia. Shipping

No. Input Output A B G H K Weight (Lbs.)

H-2100 2100 1722 61.0 68-1/4 * 3** 24 1400

H-2500 2499 2049 70.0 68-1/4 * 3** 26 1580

H-3001 3000 2460 81-1/4 68-1/4 2 3** 28 1750

H-3500 3500 2870 92-1/2 68-1/4 2 3** 30 1920

H-4001 4000 3280 103-3/4 68-1/4 2 3** 32 2100

* 1-1/2” or 2” contingent on boiler type code requirementsNOTE: Ratings are for elevations up to 2,000 feet. For

elevations over 2,000 feet, reduce ratings 4% for

every 1,000 feet above sea level. ** 4” on one-pass option

BOILER RATE OF FLOW AND PRESSURE DROP

Model

10° ∆T 20°

∆

30°

∆

40°∆T

No. GPM

∆P FT GPM

∆

P FT GPM

∆

P FT GPM ∆P FT

H-2100 N/A N/A 172 11.0 115 5.0 N/A N/A

H-2500 N/A N/A N/A N/A 137 7.5 102 4.3

TWO-PASS H-3001 N/A N/A N/A N/A 164 11.2 123 6.5

H-3500 N/A N/A N/A N/A 191 16.2 144 9.3

H-4001 N/A N/A N/A N/A N/A N/A 164 12.8

H-2100 344 14.0 N/A N/A N/A N/A N/A N/A

H-2500 N/A N/A 205 5.3 N/A N/A N/A N/A

ONE-PASS H-3001 N/A N/A 246 7.8 N/A N/A N/A N/A

H-3500 N/A N/A 287 11.0 191 5.0 N/A N/A

H-4001 N/A N/A 328 14.8 219 6.8 N/A N/A

N/A – Not Applicable

NOTES:

Values represent maximum flows and pressure drops for closed heating systems.

Maximum acceptable flow through heat exchanger tubes is 200 GPM (two-pass); 400 GPM (one-pass)

Single-pass heat exchangers are to be used only when flow rates exceed the allowable for two-pass

Raypak, Inc. 2151 Eastman Avenue, Oxnard, CA 93030 (805) 278-5300 Fax (800) 872-9725 www.raypak.com

Dieses Handbuch passt für folgende Modelle

Andere Raypak Kessel Handbücher

Raypak

Raypak 88AR-398A Handbuch

Raypak

Raypak HI DELTA HD101 THRU 2342B Bedienungsanleitung

Raypak

Raypak 503-2003 Bedienungsanleitung

Raypak

Raypak XPAK 120 Handbuch

Raypak

Raypak 0180B Type H Bedienungsanleitung

Raypak

Raypak MVB 504A Montageanleitung

Raypak

Raypak Raytherm H-181 Bedienungsanleitung

Raypak

Raypak 504-2004 Leitfaden

Raypak

Raypak MVB 503 Handbuch

Raypak

Raypak RAYTHERM H-962 Bedienungsanleitung

Raypak

Raypak DELTA LIMITED 989B-2339B Bedienungsanleitung

Raypak

Raypak Raytherm H-182 Bedienungsanleitung

Raypak

Raypak 180B Bedienungsanleitung

Raypak

Raypak RAYTHERM 133 Bedienungsanleitung

Raypak

Raypak XFyre 300A Handbuch

Raypak

Raypak 1005-2005 Handbuch

Raypak

Raypak H7 504-2004 Bedienungsanleitung

Raypak

Raypak 0090B 0135B Bedienungsanleitung

Raypak

Raypak Hydronic Space Heating 42-180 Bedienungsanleitung

Raypak

Raypak Gas Fired Boiler Leitfaden

Raypak

Raypak Commercial Space Heating and Domestic Water Bedienungsanleitung

Raypak

Raypak Xtherm 1505A Handbuch

Raypak

Raypak 751 Bedienungsanleitung

Raypak

Raypak RAYTHERM H-962 Bedienungsanleitung

Beliebte Kessel Handbücher anderer Marken

Vaillant

Vaillant uniSTOR VIH SW GB 500 BES Bedienungsanleitung

Radijator

Radijator BIO max 23.1 Bedienungsanleitung

Brunner

Brunner BSV 20 Bedienungsanleitung

Buderus

Buderus Logamax GB062-24 KDE H V2 Bedienungsanleitung

Potterton

Potterton 50e Datenblatt

UTICA BOILERS

UTICA BOILERS TriFire Bedienungsanleitung

Joannes

Joannes LADY Series Handbuch

ECR International

ECR International UB90-125 Gebrauchsanweisung

Froling

Froling FHG Turbo 3000 Bedienungsanleitung

Froling

Froling P4 Pellet 8 - 105 Bedienungsanleitung

U.S. Boiler Company

U.S. Boiler Company K2 Bedienungsanleitung

Henrad

Henrad C95 FF Bedienungsanleitung

NeOvo

NeOvo EcoNox EF 36 Bedienungsanleitung

Potterton

Potterton PROMAX SL 12 Bedienungsanleitung

Eco Hometec

Eco Hometec EC 25 COMPACT Bedienungsanleitung

Viessmann

Viessmann VITODENS 200 Leitfaden

Baxi

Baxi Prime 1.24 Bedienungsanleitung

REXNOVA

REXNOVA ISA 20 BITHERMAL Bedienungsanleitung