Raypak Raytherm H-182 Bedienungsanleitung

Catalog No.: 2000.205D Effective: 1-1-08 Replaces: 4-1-05

Job:

Engineer:

Contractor:

Prepared By: Date:

Model: Indoor

EFFICIENT

82% efficiency – highest of any atmospheric boiler

available today

THERMAL SHOCK PROOF

Twenty-year warranty against thermal shock damage

up to 150°F differential

Maximum operating temperature: 230°F

LIGHTWEIGHT

A floor load of 70 lbs./sq. ft. or less

HIGH RECOVERY

Cuts fuel costs substantially because the standby and

radiation losses normal to other boilers and

tank-type water heaters are eliminated

LOW WATER OPERATING TEMPERATURE

Operates with water temperature as low as

105°F without condensing

Heat Exchanger

ASME Inspected and Stamped

160 PSIG

National Board Approved

Headers

Cast Iron Glass-lined – Standard

Bronze – Option A-1

Finned Tubing

Copper – Standard

Cupro Nickel – Option A-3

ASME Steel Tube Sheet

Silicone O-Rings

ASME Pressure Relief Valve

45 PSIG – Standard

PSIG ASME – Optional

Temperature and Pressure Gauge,

Shipped Loose

Water Connections

Left Hand – Standard

Right Hand – Option A-6

Flow Configuration – Two-pass

Pump – Optional

Mounted, 1/8 HP, 120 Volt, 1∅,60 Hz

Controls

120V, 60Hz, 1 Ph Power Supply

120/24V Transformer

100% Pilot Shut-off/Lockout

Electronic, Intermittent Ignition (IID) Pilot

High Limit Control, Manual Reset

On/Off Switch

Flow Switch

Economaster II Pump Time Delay

Gas Control Train

Manual Main Gas Shut-off Cock

Main Gas Pressure Regulator

Redundant Safety Shut-off Valve

Control Valve

Firing Mode

On/Off (H4)

Two-stage Firing (H3)

Mechanical Modulation,

110-170°F (H5)

Mechanical Modulation,

150-210°F (H1)

Fuel

Natural Gas

Propane Gas

Design Certified ANSI Z21.13

Construction

Front Controls

Stainless Steel Burners

Polytuf Powder Coat Finish

Vent Selection

Draft Diverter – Option D-10

Power Vent, Loose – Option D-2

Base (Optional)

Combustible Floor Shield –

Option J-1

Temperature Controls

Note: H1 and H5 do not require a

controller

B-6 Two-stage – 100-200ºF

Y-241 Electronic Sequencer,

1-4 Stages

Y-281 Electronic Sequencer,

1-8 Stages

Additional Safety Controls

F-10 Low Water Cut-off Probe

I-1 High Limit Control, Auto

Reset, 240°F

S-1 Low Gas Pressure Switch,

Manual

S-2 High Gas Pressure Switch,

Manual

Regulatory Agency Requirements

Raytherm

- Type H

Hydronic Heating Boilers

Models 182-400 - Indoor

Catalog No.: 2000.205D Effective: 1-1-08 Replaces: 4-1-05

Raytherm - Type H

Hydronic Heating Boilers - Indoor Model

(C)

INDOOR

DRAFT

38"

13-1/4"

GAS

CONNECTION

26-1/2" 10-1/4

3-7/8

26-1/2"

40"

21-1/4"

ELECT.

CONN

STACKLESS

OUTDOOR TOP

PUMP

(OPTIONAL)

PUMP COVER

(OPTIONAL)

3/4 NPT

GAS CONNECTION

(OUTDOOR

MODELS ONLY)

11"

Dimensions (Inches) Shipping Weight

(Lbs.) – Approx.

Model

No. MBTU

Input MBTU

Output AFUE*

(%) Width

A Height

J Flue Dia.

K No Pump w/ Pump

H-182 181 148 82.6 18-1/4 62-5/8 12-1/16 6 191 221

H-260 264 216 82.7 22-3/8 62-7/8 11-1/8 7 214 244

H-330 334 274 N/A 25-3/4 63-3/4 10-3/4 8 234 264

H-400 399 327 N/A 29-1/4 65-3/8 12-1/2 9 253 283

* With Vent Damper

NOTE: Ratings shown are for elevations up to 2,000 feet. For elevations over 2,000, reduce ratings at the rate of 4% for each

1,000 feet above sea level.

BOILER RATE OF FLOW AND PRESSURE DROP

10° ∆T 20° ∆T 30° ∆T

Model

No. GPM ∆P FT GPM ∆P FT GPM ∆P FT

H-182 30 4.2 N/A N/A N/A N/A

H-260 43 8.5 22 2.2 N/A N/A

H-330 N/A N/A 27 3.4 N/A N/A

H-400 N/A N/A 33 5.2 22 2.3

N/A – Not Applicable

Raypak, Inc. 2151 Eastman Avenue, Oxnard, CA 93030 (805) 278-5300 Fax (800) 872-9725 www.raypak.com

Dieses Handbuch passt für folgende Modelle

Andere Raypak Kessel Handbücher

Raypak

Raypak Hi Delta FlexGas 992BD Bedienungsanleitung

Raypak

Raypak 0090B 0135B Bedienungsanleitung

Raypak

Raypak DELTA LIMITED 989B-2339B Bedienungsanleitung

Raypak

Raypak XPAK 85 Leitfaden

Raypak

Raypak RAYTHERM 0042B Handbuch

Raypak

Raypak 2342BE Bedienungsanleitung

Raypak

Raypak MVB 504A Montageanleitung

Raypak

Raypak RAYTHERM H-962 Bedienungsanleitung

Raypak

Raypak 0133-4001 Bedienungsanleitung

Raypak

Raypak Xtherm 1005 Einrichtungshandbuch

Raypak

Raypak 0180B Type H Bedienungsanleitung

Raypak

Raypak XFYRE 500 Bedienungsanleitung

Raypak

Raypak Hi Delta 302A-902A Bedienungsanleitung

Raypak

Raypak 399B-2339B Handbuch

Raypak

Raypak 503-2003 Bedienungsanleitung

Raypak

Raypak XFYRE 500 Bedienungsanleitung

Raypak

Raypak XVers 856-3006 Leitfaden

Raypak

Raypak Hydronic Space Heating 42-180 Bedienungsanleitung

Raypak

Raypak 180B Bedienungsanleitung

Raypak

Raypak RAYTHERM 133-4001 Handbuch

Raypak

Raypak Raytherm H-181 Bedienungsanleitung

Raypak

Raypak 503A Handbuch

Raypak

Raypak 500 Technisches Datenblatt

Raypak

Raypak 1005-2005 Bedienungsanleitung

Beliebte Kessel Handbücher anderer Marken

Vaillant

Vaillant uniSTOR VIH SW GB 500 BES Bedienungsanleitung

Radijator

Radijator BIO max 23.1 Bedienungsanleitung

Brunner

Brunner BSV 20 Bedienungsanleitung

Buderus

Buderus Logamax GB062-24 KDE H V2 Bedienungsanleitung

Potterton

Potterton 50e Datenblatt

UTICA BOILERS

UTICA BOILERS TriFire Bedienungsanleitung

Joannes

Joannes LADY Series Handbuch

ECR International

ECR International UB90-125 Gebrauchsanweisung

Froling

Froling FHG Turbo 3000 Bedienungsanleitung

Froling

Froling P4 Pellet 8 - 105 Bedienungsanleitung

U.S. Boiler Company

U.S. Boiler Company K2 Bedienungsanleitung

Henrad

Henrad C95 FF Bedienungsanleitung

NeOvo

NeOvo EcoNox EF 36 Bedienungsanleitung

Potterton

Potterton PROMAX SL 12 Bedienungsanleitung

Eco Hometec

Eco Hometec EC 25 COMPACT Bedienungsanleitung

Viessmann

Viessmann VITODENS 200 Leitfaden

Baxi

Baxi Prime 1.24 Bedienungsanleitung

REXNOVA

REXNOVA ISA 20 BITHERMAL Bedienungsanleitung