Raypak RAYTHERM H-962 Bedienungsanleitung

Catalog No.: 2000.24O Effective: 04-15-10 Replaces: 12-01-07

Job:

Engineer:

Contractor:

Prepared By: Date:

Model:

EFFICIENT

82% efficiency – highest of any atmospheric

boiler available today

THERMAL SHOCK PROOF

Twenty-year warranty against thermal shock damage

up to 150°F differential

Maximum operating temperature: 230°F

LIGHTWEIGHT

A floor load of 70 lbs./sq. ft. or less

HIGH RECOVERY

Cuts fuel costs substantially because the standby and

radiation losses normal to other boilers are eliminated

LOW WATER OPERATING TEMPERATURE

Operates with inlet water temperature as low as 105°F

without condensing

Heat Exchanger

ASME Inspected and Stamped

160 PSIG

National Board Listed

Headers

Glass-lined Cast Iron – Standard

Bronze – Option A-1

Finned Tubing

Copper – Standard

Cupro Nickel – Option A-3

ASME Steel Tube Sheet

Silicone O-Rings

60 PSIG ASME Pressure Relief Valve

Temperature and Pressure Gauge

Water Connections

Left Hand – Standard

Right Hand – Option A-6

Flow Configuration

Two-pass – Standard

Single-pass – Cast Iron Only

Pump - Rear-mounted, 1/2 HP,

120 VAC, 1∅,60 Hz – Optional

4.25” Impeller

4.7” Impeller

Controls

120V, 60Hz, 1 Ph Power Supply

120/24V Transformer

100% Pilot Shut-off/Lockout

Electronic, Intermittent Ignition (IID)

Pilot

High Limit Control, Manual Reset,

240°F

On/Off Switch

Controls (cont.)

Flow Switch

Economaster Pump Time Delay

Gas Train

Manual Main Gas Shut-off Cock

Main Gas Pressure Regulator

Redundant Safety Shut-off Valve

Control Valve

Firing Mode

On/off (H4)

Two-stage Firing (H3)

Four-stage Firing (H9)

Mechanical Modulation,

110-170°F (H5)

Mechanical Modulation,

150-210°F (H1)

Motorized Modulation (H2)

Fuel

Natural Gas

Propane Gas

Design Certified ANSI Z21.13/CSA 4.9

Construction

AB 1953 & VLA 193 Compliant

Front Controls

Stainless Steel Burners

Polytuf Powder Coat Finish

Vent Selection

Draft Diverter – Option D-10

Power Vent, Loose – Option D-2

Base (Optional)

Combustible Floor Shield –

Option J-1

Temperature Controllers

Note: H1 and H5 do not require a

controller

B-6 Two-stage

B-36 TempTracker Mod+ Hybrid

B-40 Motorized Modulation

B-41 Motorized Modulation,

Outdoor Reset

B- Four-stage Digital

Y-241 Electronic Sequencer,

1-4 Stages

Y-281 Electronic Sequencer,

1-8 Stages

Remote Controller

By others:

Additional Safety Controls

F-9 Low Water Cut-off Probe

I-1 High Limit Control, Auto

Reset, 240°F

S-1 Low Gas Pressure Switch,

Manual

S-2 High Gas Pressure Switch,

Manual

Regulatory Agency Requirements

Raytherm

- Type H

Hydronic Heating Boilers

Commercial

Models 962-1826 (Indoor)

INDOOR

Catalog No.: 2000.24O Effective: 04-15-10 Replaces: 12-01-07

Raytherm - Type H

Hydronic Heating Boilers Model

11 3/4

14 1/2

A/2

1 1/8

COMBUSTIBLE FLOOR SHIELD

11 1/8

5 1/82 1/2

GAS

ELEC.

CONN.

27 3/4

11 1/4

32 1/2

(J-BOX)

(OPTIONAL)

OUT

H - INLET

(OPPOSITE SIDE)

7-7/8

15-1/4

H - OUTLET

OPTIONAL ONE PASS

DRAFT HOOD

(OPTIONAL)

19 1/2

(OPTIONAL)

PUMP

MODELS 962 THRU 1826

Dimensions (Inches) Approx.

MBTUH Overall Jacket Gas Water Flue Shipping

Model Natural Gas Width Height Height Conn. Conns. Dia. Weight

Size Input Output A B C G H J K L (Lbs.)

H-962 961.7 788.6 52-3/8 76-1/8 (a) 33-1/2 1 2-1/2 (c) 23-5/8 14 28 705

H-1125 1124.7 922.0 59-1/4 78-1/8 (a) 33-1/2 1 (b) 2-1/2 (c) 23-5/8 16 32 745

H-1223 1222.5 1002.4 63-5/8 78-1/8 (a) 33-1/2 1 (b) 2-1/2 (c) 23-5/8 16 32 805

H-1336 1336.6 1096.0 68-5/8 80-1/8 (a) 33-1/2 1-1/4 2-1/2 (c) 23-5/8 18 36 875

H-1468 1467.0 1203.0 74-7/8 80-1/8 (a) 33-1/2 1-1/4 2-1/2 (c) 23-5/8 18 36 945

H-1631 1630.0 1336.6 81-1/8 83-1/8 (a) 36-1/2 1-1/4 2-1/2 (c) 23-5/8 18 36 985

H-1826 1825.6 1497.0 89-3/8 85-1/8 (a) 36-1/2 1-1/4 2-1/2 (c) 23-5/8 20 40 1035

NOTE: Ratings shown are for elevations up to 2,000 feet. For

elevations over 2,000, reduce ratings at the rate of 4% for each

1,000 feet above sea level.

(a) Add 1-1/8" to overall height for combustible floor shield option

(b) 1" or 1-1/4" contingent on boiler type or code requirements

(d) Propane input/output is 92% of standard values

Raypak, Inc. 2151 Eastman Avenue, Oxnard, CA 93030 (805) 278-5300 Fax (800) 872-9725 www.raypak.com

BOILER RATE OF FLOW AND PRESSURE DROP

10º ΔT 20º ΔT 30º ΔT 40º ΔT Minimum Flow Maximum Flow

Model

No. GPM ΔP

FT GPM ΔP

FT ΔT GPM ΔP

FT ΔT

H-962 80 8.8 53 3.8 40 2.2 40 2.2 38 90 11.0 18

H-1125 90 12.0 61 5.5 47 3.3 45 3.1 40 90 12.0 21

H-1223 76 7.0 51 4.0 51 4.0 40 90 12.5 22

H-1336 73 8.6 55 4.9 55 4.9 40 90 13.2 25

H-1468 80 11.0 61 6.4 61 6.4 40 90 14.0 27

H-1631

Exceeds Maximum Flow

90 14.8 68 8.3 68 8.3 40 90 8.3 30

TWO-

PASS

H-1826 76 10.8 76 10.8 40 90 15.4 34

H-962 157 6.1 90 2.1 18 200 9.7 8

H-1125 184 8.8 92 2.3 90 2.3 20 200 10.3 9

H-1223 200 11.0 100 2.9 90 2.4 22 200 11.0 10

H-1336 110 3.7 90 2.5 24 200 11.7 11

H-1468 120 4.5 90 2.7 27 200 12.2 12

H-1631 134 6.0

Less than Minimum Flow

90 2.8 30 200 13.0 13

ONE-

PASS

H-1826

150 8.0 100 3.7 90 3.0 33 200 14.7 15

NOTES:

•Values represent maximum flows and pressure drops for closed heating systems

•Maximum acceptable flow through heat exchanger tubes is 90 GPM (two-pass); 200 GPM (one-pass)

•Single-pass heat exchangers are to be used only when flow rates exceed the allowable for two-pass

Andere Handbücher für RAYTHERM H-962

Dieses Handbuch passt für folgende Modelle

Andere Raypak Kessel Handbücher

Raypak

Raypak Gas Fired Boiler Leitfaden

Raypak

Raypak XFYRE 500 Bedienungsanleitung

Raypak

Raypak Commercial Space Heating and Domestic Water Bedienungsanleitung

Raypak

Raypak XFYRE 500 Bedienungsanleitung

Raypak

Raypak 2342BE Bedienungsanleitung

Raypak

Raypak DELTA LIMITED 989B-2339B Bedienungsanleitung

Raypak

Raypak RAYTHERM 133 Bedienungsanleitung

Raypak

Raypak H-0030B Leitfaden

Raypak

Raypak 0090B 0135B Bedienungsanleitung

Raypak

Raypak FlexGas 302BD Bedienungsanleitung

Raypak

Raypak 0180B Type H Bedienungsanleitung

Raypak

Raypak Raytherm H-181 Bedienungsanleitung

Raypak

Raypak XVers 856-3006 Leitfaden

Raypak

Raypak 751-1501 Bedienungsanleitung

Raypak

Raypak Hi Delta FlexGas 992BD Bedienungsanleitung

Raypak

Raypak FlexGas 302BD-2342BD Bedienungsanleitung

Raypak

Raypak Xtherm 1505A Handbuch

Raypak

Raypak RAYTHERM H-0042 Bedienungsanleitung

Raypak

Raypak 302BE-902BE Bedienungsanleitung

Raypak

Raypak RAYTHERM 0042B Handbuch

Raypak

Raypak H7 504-2004 Bedienungsanleitung

Raypak

Raypak Raytherm H-182 Bedienungsanleitung

Raypak

Raypak 88AR-398A Handbuch

Raypak

Raypak RAYTHERM 133-4001 Handbuch

Beliebte Kessel Handbücher anderer Marken

Vaillant

Vaillant uniSTOR VIH SW GB 500 BES Bedienungsanleitung

Radijator

Radijator BIO max 23.1 Bedienungsanleitung

Brunner

Brunner BSV 20 Bedienungsanleitung

Buderus

Buderus Logamax GB062-24 KDE H V2 Bedienungsanleitung

Potterton

Potterton 50e Datenblatt

UTICA BOILERS

UTICA BOILERS TriFire Bedienungsanleitung

Joannes

Joannes LADY Series Handbuch

ECR International

ECR International UB90-125 Gebrauchsanweisung

Froling

Froling FHG Turbo 3000 Bedienungsanleitung

Froling

Froling P4 Pellet 8 - 105 Bedienungsanleitung

U.S. Boiler Company

U.S. Boiler Company K2 Bedienungsanleitung

Henrad

Henrad C95 FF Bedienungsanleitung

NeOvo

NeOvo EcoNox EF 36 Bedienungsanleitung

Potterton

Potterton PROMAX SL 12 Bedienungsanleitung

Eco Hometec

Eco Hometec EC 25 COMPACT Bedienungsanleitung

Viessmann

Viessmann VITODENS 200 Leitfaden

Baxi

Baxi Prime 1.24 Bedienungsanleitung

REXNOVA

REXNOVA ISA 20 BITHERMAL Bedienungsanleitung