Raypak AVIA 264 Bedienungsanleitung

AVIA Pool & Spa Heater

Tool Box Quick Reference Guide

Water Chemistry

GENERAL

Recommended Levels Fiberglass Pools Fiberglass Spas Other Pool & Spa Types

Water Temp. 68 to 88°F (20 to 31°C) 89 to 104°F (31 to 40°C) 68 to 104°F (20 to 40°C)

pH 7.3 to 7.4 7.3 to 7.4 7.6 to 7.8

Total Alkalinity (PPM) 120 to 150 120 to 150 80 to 120

Calcium Hardness (PPM) 200 to 300 150 to 200 200 to 400

Salt (PPM) 4500 MAXIMUM 4500 MAXIMUM 4500 MAXIMUM

Free Chlorine (PPM)22 to 3 2 to 3 2 to 3

Total Dissolved Solids (PPM) 3000 MAXIMUM33000 MAXIMUM33000 MAXIMUM3

For your health and the protection of your pool equipment, it is essential that your water be chemically balanced1.

The following levels must be used as a guide for balanced water.

1 Damage from corrosive water is not covered under warranty. Consult your product manual for more information.

2 Free Chlorine MUST NOT EXCEED 5PPM.

3 In salt water chlorinated pools, the total TDS can be as high as 6000PPM.

• Occasional chemical shock dosing of the pool or spa water should not damage the heater providing the water is

balanced.

• Automaticchemicaldosingdevicesandsaltchlorinatorsareusuallymoreecientinheatedwater,unlesscontrolled,

they can lead to excessive chlorine level which can damage your heater.

• Check valve should be installed between the heater outlet and a chlorinator or other chemical dosing device.

• Further advice should be obtained from your pool or spa builder, accredited pool shop, or chemical supplier for the

correct levels for your water.

• Warning: Electrolytic Corrosion and pH instability may be present with salt chlorinated pools.

Model Number and Serial Number Location

Before you call Raypak service, make sure you have the MODEL NUMBER and SERIAL NUMBER.

Model & Serial

number can also

be found inside the

bezel above digital

display.

Model & Serial

number located

on rating plate.

Model & Serial number located on

carton label.

GENERAL

Minimum Clearances

CLEARANCES

FLOORING: THIS UNIT CAN BE INSTALLED ON COMBUSTIBLE FLOORING.

See product manual for more information.

Location Indoor Installation

Top Unobstructed

Front 0”

Floor 0”

Back 0”

Right Side 3” (76 mm) from Panel - Water Side

Left Side 3” (76 mm) from Panel - Vented Side

Location Outdoor Installation

Top Unobstructed

Front 0”

Floor 0”

Back 0”

Right Side 3” (76 mm) from Panel - Water Side

Left Side 6” (152 mm) from Vent Cap

Minimum Clearances* – Outdoor

DO NOT install near

sprinklers.

DO NOT install within

3 feet (0.9 m) of a heat

pump or an outdoor

condensing unit.

*Check state and local codes before

proceeding. The minimum clearances

providedaredenedbyNFGC

(National Fuel Gas Code).

CLEARANCES

Minimum Clearances – Indoor

CLEARANCES

The heater must have both combustion air and

ventilation air.

• Ventilation air opening 12”(305 mm) max from

the ceiling

• Combustion air opening 12”(305 mm) max

fromtheoor

All air from outdoors, each opening shall have a

net free area as shown in table.

Check state and local codes before proceeding. Some states do not recognize the NFGC and require larger openings.

Model

Unrestricted

Opening

Sq. In. (m2)

Typical

Screened or

Louvered

opening

Sq. In. (m2)

Typical

Screened and

Louvered

opening

Sq. In. (m2)

264 66 (0.04) 99 (0.06) 132 (0.09)

404 100 (0.06) 150 (0.1) 200 (0.13)

Gas Line Sizing

Maximum Equivalent Pipe Length ft (m)

Natural Gas 1000 BTU/FT3

0.60SpecicGravity@0.5in.WCPressureDrop

Propane Gas 2500 BTU/FT3

1.53SpecicGravity@0.5in.WCPressureDrop

Model No.

Size 3/4” Size 1” Size 1-1/4” Size 1-1/2”

NAT PRO NAT PRO NAT PRO NAT PRO

264 15

(4.6)

(10.7)

(12.2)

125

(38.1)

210

(64.0)

480

(146.3)

445

(135.6)

404 *15

(4.6)

(8.8)

(16.8)

(29.0)

225

(68.6)

215

(65.5)

280

(85.3)

GAS SUPPLY

EFFECTS OF LOW GAS PRESSURE

• Pulsatingburnerame/Flamelost

• DelayedIgnition/Hardlighto

• Exposure to condensation

• Emissions not at compliance levels

• Damage burner

• Sooting

• Ignition failure

*A3/4”gaslinecanbeusedforupto5’(1.5m)maximumlengthfromthegasvalveinadditiontothesedimenttrap.

Gas Pressure Test

Gas Required Pressure Manifold

Pressure

Min. Max.

Natural Gas 3.5”

(Dynamic)

10.5”

(Static) -0.3”

Propane Gas 8.0”

(Dynamic)

13.0”

(Static) -0.3”

GAS SUPPLY

• Propane requires an external “pounds

to inches” regulator

Inlet Gas Pressure

Gas Valve

Manifold

Gas Pressure

Gas Valve

Gas Line Sediment Trap

GAS SUPPLY

Check state and local codes before proceeding. Some states do not recognize the NFGC.

Sediment Trap should be located as close

to the inlet of the appliance as practical.

ELECTRICAL

Model 264

Model 404

Printed circuit board. Boards cannot be

interchanged.

Circuit Board

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Raypak Schwimmbadheizung Handbücher

Raypak

Raypak CHX Einrichtungshandbuch

Raypak

Raypak Versa 055 Gebrauchsanweisung

Raypak

Raypak ECONOPAK 203A Bedienungsanleitung

Raypak

Raypak Raytherm P-1826 Handbuch

Raypak

Raypak ELS 1102-2 Einrichtungshandbuch

Raypak

Raypak RP2100 ASME R185B Bedienungsanleitung

Raypak

Raypak 105A VERSA Bedienungsanleitung

Raypak

Raypak CROSSWIND Series Bedienungsanleitung

Raypak

Raypak SpaPak 552 & 1102 Gebrauchsanweisung

Raypak

Raypak 106 Handbuch

Raypak

Raypak HI DELTA 2002B Bedienungsanleitung

Raypak

Raypak raytherm P-1223 Bedienungsanleitung

Raypak

Raypak HI DELTA 302B Bedienungsanleitung

Raypak

Raypak HI DELTA 652B Handbuch

Raypak

Raypak X94 Handbuch

Raypak

Raypak Gemini 53 Einrichtungshandbuch

Raypak

Raypak XTherm Series Handbuch

Raypak

Raypak VERSA 155C Bedienungsanleitung

Raypak

Raypak HI DELTA 2072B Bedienungsanleitung

Raypak

Raypak Xtherm 1505 Bedienungsanleitung

Raypak

Raypak R410A Series Stücklistenhandbuch

Raypak

Raypak HIDELTA 992B Bedienungsanleitung

Raypak

Raypak 018222F Original Betriebsanleitung

Raypak

Raypak P Bedienungsanleitung

Beliebte Schwimmbadheizung Handbücher anderer Marken

Nibe

Nibe S Series Benutzerhandbuch

Zodiac

Zodiac JXi 200 Bedienungsanleitung

Texsun

Texsun El Niño Bedienungsanleitung

Aqua Comfort

Aqua Comfort AC110 Bedienungsanleitung

HeatPRO

HeatPRO pool heat pump Bedienungsanleitung

Dickinson

Dickinson NEWPORT Bedienungsanleitung

Pentair Pool Products

Pentair Pool Products MiniMax CH 150 Bedienungsanleitung

Jandy

Jandy LJ Bedienungsanleitung

Pentair Pool Products

Pentair Pool Products MiniMax NT Series Bedienungsanleitung

Hayward Pool Products

Hayward Pool Products HP40A Service-Handbuch

Laars

Laars Lite 2 LC Bedienungsanleitung

SUPREME

SUPREME Heatseeker Solar Pool Heating Bedienungsanleitung

UTC

UTC ICP HMP-03 Montageanleitung

Pentair

Pentair ETi 400 Bedienungsanleitung

Hayward

Hayward ENP2M-9A Service-Handbuch

BriskHeat

BriskHeat TOT Series Bedienungsanleitung

Hayward

Hayward C-SPA-XI 5.5 Bedienungsanleitung

Aquacal

Aquacal AEROTEMP Bedienungsanleitung