Raypak 018222F Original Betriebsanleitung

P/N 241840 Rev 2

E󰀨ective: 08-14-2020

Replaces: NEW

RAYPAK SERVICE INSTRUCTIONS

PROTÉGÉ SERIES SAND FILTERS RPSF, RPSFP

KITS 018216F - 018221F, LATERAL ASSEMBLIES

KITS 018222F, 018223F, LATERALS ONLY

Scope

This kit provides the parts required to replace the Lateral

Assembly for the Protégé Line of sand lters.

Kit Parts

Kit Model No. Parts Provided

018216F RPSF14

Center Pipe

Laterals

Manifold

018217F RPSF16

018218F RPSF18

018219F RPSF21

018220F RPSF25

018221F RPSF28

018222F RPSF14-RPSF18

Laterals only

018223F RPSF21-RPSF28

Required Tools

• Curved-jaw tongue-and-groove pliers

• Phillips head screwdriver

CENTER PIPE

MANIFOLD

LATERAL

DANGER – SHOCK HAZARD: Make sure electrical power to attached pump and

heaters is disconnected to avoid damage to components, potential serious personal

injury or death.

WARNING: Make sure water & power have been turned OFF before making any re-

pairs or service to the unit.

IMPORTANT NOTICE: These instructions are for the use of qualied individuals

specially trained and experienced in the installation and maintenance of this type of

equipment and related system components. Installation and service personnel are re-

quired by some states to be licensed. Persons not qualied shall not attempt to install,

service, or maintain this equipment.

2Raypak, Inc., 2151 Eastman Avenue, Oxnard, CA 93030 1-800-260-2758 Fax (805) 278-5468

Replacing Lateral Pipe Center Assembly

1. Turn off the electrical power at the Pump’s power

switch and/or unplug it at the receptacle.

2. Close the water valves, if installed, to isolate the filter

from the system.

3. Remove multiport valve from the top of the tank, and

all sand media. (Refer to separate instruction sheet

P/N 241838 as needed.)

4. Holding the center pipe assembly inside the tank,

grasp the lateral arm near the center manifold and

turn firmly counter-clockwise to unscrew as shown

in Figure 1.

NOTE: Lateral arms have locking notches to ensure

solid attachment. It may be necessary to use curved jaw

tongue-and-groove pliers to turn the lateral arm. Use

caution to avoid crushing.

Figure 1. Removing Lateral from Manifold

(Counter-Clockwise)

5. Remove all (8) eight lateral arms from the center

manifold in order to remove the manifold from the

tank.

6. The new center pipe and lateral arms must be

assembled inside the tank. Holding the center pipe

and manifold, install each lateral arm, screwing them

in by hand until you hear an audible click.

7. When all 8 laterals are installed into the manifold, the

full assembly may be stood upright so that the top of

the center pipe is centered at the opening of the tank

as shown in Figure 2.

8. Add the appropriate amount of sand media, and

reinstall the multiport valve.

Figure 2. Lateral Assembly Installed into Tank.

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Raypak Schwimmbadheizung Handbücher

Raypak

Raypak AVIA 264 Bedienungsanleitung

Raypak

Raypak RP2100 ASME R185B Bedienungsanleitung

Raypak

Raypak Hi Delta 992B-1262B Handbuch

Raypak

Raypak 183A Bedienungsanleitung

Raypak

Raypak GEMINI 263 Bedienungsanleitung

Raypak

Raypak HI DELTA 652B Handbuch

Raypak

Raypak 6200.90 Gebrauchs- und Wartungshandbuch

Raypak

Raypak HI DELTA 302B Bedienungsanleitung

Raypak

Raypak 206A Handbuch

Raypak

Raypak VERSA 185B Handbuch

Raypak

Raypak els 552-2 Handbuch

Raypak

Raypak RP2100 ASME R185B Handbuch

Raypak

Raypak Versa 105B Brass Bedienungsanleitung

Raypak

Raypak 402 Bedienungsanleitung

Raypak

Raypak VERSA 155C Bedienungsanleitung

Raypak

Raypak 259B Handbuch

Raypak

Raypak 399 Einrichtungshandbuch

Raypak

Raypak Versa 155 Bedienungsanleitung

Raypak

Raypak Raytherm P-1826 Handbuch

Raypak

Raypak 538 To 4224 Bedienungsanleitung

Raypak

Raypak MVB 1104 Einrichtungshandbuch

Raypak

Raypak 153A GEMINI Bedienungsanleitung

Raypak

Raypak 180A Bedienungsanleitung

Raypak

Raypak RAYTHERM P-926 Bedienungsanleitung

Beliebte Schwimmbadheizung Handbücher anderer Marken

Nibe

Nibe S Series Benutzerhandbuch

Zodiac

Zodiac JXi 200 Bedienungsanleitung

Texsun

Texsun El Niño Bedienungsanleitung

Aqua Comfort

Aqua Comfort AC110 Bedienungsanleitung

HeatPRO

HeatPRO pool heat pump Bedienungsanleitung

Dickinson

Dickinson NEWPORT Bedienungsanleitung

Pentair Pool Products

Pentair Pool Products MiniMax CH 150 Bedienungsanleitung

Jandy

Jandy LJ Bedienungsanleitung

Pentair Pool Products

Pentair Pool Products MiniMax NT Series Bedienungsanleitung

Hayward Pool Products

Hayward Pool Products HP40A Service-Handbuch

Laars

Laars Lite 2 LC Bedienungsanleitung

SUPREME

SUPREME Heatseeker Solar Pool Heating Bedienungsanleitung

UTC

UTC ICP HMP-03 Montageanleitung

Pentair

Pentair ETi 400 Bedienungsanleitung

Hayward

Hayward ENP2M-9A Service-Handbuch

BriskHeat

BriskHeat TOT Series Bedienungsanleitung

Hayward

Hayward C-SPA-XI 5.5 Bedienungsanleitung

Aquacal

Aquacal AEROTEMP Bedienungsanleitung