Roda 810 Bedienungsanleitung

810 BUSHEL

MANURE SPREADER 2009

2009 Model Year2006-2008 Model Years

RODA MANUFACTURING

338 MAIN ST.

HULL, IA. 51239

712-439-2366

WWW.RODAMFG.COM

INTRODUCTION

Thank you for purchasing a Roda Spreader. We appreciate your business. Here at Roda, we do our best to

provide you with a rugged and durable unit, which is easy to maintain. If you have any suggestions for any of

our products, please let us know.

Roda Manufacturing Inc.

USING THIS MANUAL

This manual should be considered a permanent part of your machine, and should remain with the machine when

you sell it.

This manual has been designed to help you become familiar with your unit. Before you operate your unit, be

sure you understand and follow all the operation, safety, and lubrication instructions on the following pages in

this manual. These have been written for your safety and convenience, and to help keep your unit running

trouble-free for many years.

ADDITIONAL OPERATORS MANUALS, SERVICE PARTS LISTINGS and safety decals may be

obtained through your dealer, or Roda Manufacturing.

TABLE OF CONTENTS

Introduction 3

Safety 4-6

Safety Decals & Location 6-8

Manure Spreader Safety 9-10

Pre-Operation 11

Lubrication 12

Inspection & Adjustments 13-14

Spreader Operation 14-15

Frame and Shields Breakdown 16-17

Apron Drive Breakdown 18-19

Front and Side Driveline Breakdown 20-21

Beater Panel Breakdown 22-23

Slop Gate Breakdown 24

Hub City Gearbox Breakdown 25

Wheel and Hub Breakdown 26-27

Worm Gear Breakdown 28-29

Apron Hydraulics Breakdown 30

Slop Gate Hydraulics Breakdown 31

LimitedWarranty 33

Warranty Registration 35

SAFETY

UNDERSTAND SAFETY WORDS AND SYMBOLS

THIS SAFETY ALERT SYMBOL is used in this manual whenever personal safety is involved

and means ATTENTION! BECOME ALERT! It stresses an attitude of “HEADS UP” for safety.

Read and understand all pages in this manual that bear this safety symbol and…TAKE TIME TO BE

CAREFUL!

The Signal Word or Message areas of all safety decals are color coded to indicate the level of hazard.

CAUTION:Is used to direct attention to unsafe practices, and uses the color yellow.

WARNING:Denotes a specific potential hazard, and uses the color yellow or orange.

DANGER:Denotes a most serious specific potential hazard, and uses the color red.

READ THE OPERATORS MANUAL

Any person who will be operating or maintaining this manure spreader should first read and understand this

manual and all safety warnings on the unit.

This instruction manual should always be available to those responsible for the operation and maintenance of

this manure spreader. It is the owner’s responsibility to provide this safety information to his operators and

employees.

Any person who does not understand the safety and operation instructions contained in this manual should not

be considered qualified to operate this manure spreader.

FOLLOW SAFETY INSTRUCTIONS

Specialized procedures and instructions are required and must be adhered to when working on this equipment.

Failure to follow the instructions contained in this manual could result in severe personal injury, death, and/or

product or property damage. Personnel when operating or maintaining this equipment must use all applicable

safety procedures such as OSHA requirements, regional and local safety codes and requirements, safe working

practices, and good judgment.

SAFETY

OPERATING SAFETY PRECAUTIONS

WHEN THE SPREADER IS IN OPERATION, IT HAS MANY MOVING PARTS,

WHICH COULD CAUSE SEVERE INJURY OR DEATH TO PERSONS COMING IN

CONTACT WITH THESE PARTS. TO HELP AVOID SERIOUS ACCIDENTS, THE

FOLLOWING GUIDELINES MUST BE FOLLOWED.

•BE SURE ALL SAFETY SHIELDS are in place before operating, including any truck and driveline

shields. Exposed machinery, due to missing shielding, can cause severe injury or death. Repair or replace

any damaged or missing shielding.

•NEVER PUT ARMS OR FEET INSIDE UNIT, or near discharge areas, nor climb on or in the spreader

while it is running. NEVER allow anyone to position themselves over or near the top, or near the discharge

area of the spreader while it is running. Rotating beaters, shafting, belts, pulleys, and sprockets can grab

clothing or create pinch points, which can cause severe injury or death to the operator or bystanders.

Always stop engine and remove ignition key so that the spreader cannot be accidentally turned on while

inspection, servicing, repairing, or cleaning the spreader.

•NEVER ATTEMPT TO RELEASE JAMMED MATERIALS OR CLEAN MATERIALS from any

area of the spreader of discharge without turning the spreader off first. Materials can hide moving parts and

stopped parts can start unexpectedly, causing severe injury. Always stop engine and remove ignition key

before attempting to remove jammed material or clean the spreader.

•DO NOT ALLOW OPERATION OF THIS UNIT BY AN INEXPERIENCED OR UNQUALIFIED

PERSON. Keep all unqualified people away from spreader during operation. Operators of this unit must

be alert and use good judgment at all times and must have fully read and understand this manual.

•DO NOT WEAR LOOSE OR FLOPPY CLOTHING while operating this unit. Loose clothing may

become entangled in moving machinery.

•BE SURE THE INSIDE OF SPREADER IS CLEAR of any obstructions before loading.

•SHOULD A PROBLEM OCCUR DURING THE OPERATION OF SPREADER, always turn off

engine and remove ignition key before investigating problem. If power source has not been turned off,

the spreader may start unexpectedly, causing severe injury or death.

SAFETY

TRANSPORTING SAFETY PRECAUTIONS

WHEN TRANSPORTING A LOADED SPREADER, USE REDUCED SPEED AND BE

SURE THE VEHICLE HAS ADEQUATE BRAKES TO STOP.

•DO NOT ALLOW ANYONE TO RIDE ON OR INSIDE THE SPREADER.

•REDUCE SPEED WHEN TRAVELING loaded and/or over rough, soft, or wet terrain. Exercise caution

on side slopes and when turning corners.

•AVOID OPERATING THE SPREADER CROSSING GULLIES OR DITCHES.

•WHEN WORKING ON SLOPES or inclines, travel uphill or downhill. Keep the transmission in gear

when going downhill.

•AVOID DRIVING ON loose fill, rocks, inclines, ditches, and holes.

•ALWAYS PARK the spreader on level ground and block the tires.

•IF UNIT IS FOR HIGHWAY TRANSIT the end user is responsible for federal, state and local vehicle

safety regulation compliance (example: under ride requirements, lighting and weight limitations).

SAFETY DECALS

SAFETY DECALS ARE PLACED ON THIS UNIT FOR THE PROTECTION OF THE

OPERATOR OR ANY PERSON NEAR THE UNIT.

•BE SURE EVERYONE WHO OPERATES THE SPREADER UNDERSTANDS ALL THE

INFORMATION, WARNING, CAUTION AND DANGER DECALS.

•KEEP THE DECALS CLEAN so they are readable. This applies to all caution, warning, and danger

decals.

•It is the OWNER’S RESPONSIBILITY to provide information for safe operation of this machine.

•REPLACE ANY DAMAGED OR WORN DECAL. Once any part of a decal becomes non-readable, it

should be replaced. Replacement decals may be ordered through your dealer or Roda Manufacturing.

•WHEN REPLACING DECALS, be sure the surface area is clean and dry, peel the backing off the decal,

and apply to the unit. Be sure to wipe with a clean cloth to rub out all air bubbles to assure a good seal. For

best adhesion decals should be applied in temperatures of 50°(f) or warmer.

SAFETY

SAFETY DECALS

1.) 2.) 3.)

4.) 5.) 6.)

7.) 8.) 9.)

10.) 11.)

SAFETY

SAFETY DECAL LOCATION

MODEL AND SERIAL NUMBER INFORMATION is located in the upper center area of the front panel.

This is the number to give service personnel for parts and service questions.

MANURE SPREADER SAFETY

THERE ARE INHERENT HAZARDS ASSOCIATED WITH THE OPERATION OF A

MANURE SPREADER. FOR YOUR SAFETY:

•ONLY PROPERLY INSTRUCTED PEOPLE SHOULD OPERATE THE SPREADER. Do not allow

children or inexperienced persons to operate spreader.

•KEEP ALL GUARDS AND SHEILDS IN PLACE. Moving parts can crush and dismember.

•CLEAR THE AREA before equipment start up.

•KEEP HANDS, FEET, AND LOOSE CLOTHING AWAY FROM ANY MOVING PARTS.

•DO NOT GO NEAR THE SPREADER WHILE THE MACHINE IS OPERATING.

•MAKE SURE THE PTO IS SECURELY LOCKED to both the tractor and spreader before operating this

unit.

•DO NOT OPERATE PTO AT SPEEDS HIGHER than manufacturer’s recommendations.

•HIGHWAY TRAFFIC IS NOT TO EXCEED 10 MPH. The tires supplied are for farm use only and are

not designed for use above this speed.

•USE ADEQUATE SAFETY CHAINS when towing the spreader.

•USE OF A SLOW MOVING VEHICLE SIGN IS REQUIRED on all public roads. Obey all applicable

highway safety laws and rules.

•ALWAYS USE A TRACTOR LARGE ENOUGH TO PROVIDE SUFFICIENT BRAKING assistance

when towing a loaded spreader.

•USE CAUTION WHEN TRAVELING over uneven terrain and when approaching stops.

•DO NOT LOAD THE SPREADER unless it is hitched to the tractor.

•DO NOT UNHITCH A LOADED SPREADER from the tractor. Leaving it supported by only the jack.

•PARK THE SPREADER ON LEVEL GROUND and place blocks ahead of and behind the wheels before

unhooking from tractor to avoid unexpected rolling when separated from vehicle

•DO NOT ALLOW RIDERS ON THE SPREADER.

FAILURE TO HEED MAY RESULT IN SERIOUS PERSONAL INJURY OR DEATH

THERE ARE ADDITIONAL HAZARDS ASSOCIATED WITH THE SERVICE AND MAINTENENCE

OF YOUR SPREADER.

FOR YOUR SAFETY:

•INSPECT when first delivered and regularly thereafter; that all connections and bolts are tight and secure

before operating.

•RETIGHTEN ALL WHEEL BOLTS after the first hour of towing. Check periodically thereafter.

•MAINTAIN PROPER TIRE AIR PRESSURE at all times.

•ALWAYS WEAR EYE PROTECTION when operating or servicing spreader.

•BE SURE ALL MOVEMENT HAS STOPPED and that the PTO is disconnected and the tractor is shut

off before servicing the spreader or components.

•ESCAPING HYDRAULIC FLUID UNDER PRESSURE can penetrate skin and cause serious injury.

Relieve all pressure from the hydraulic system before connecting of disconnecting the lines or making

repairs. Check all hoses and fittings before start-up and periodically during operation.

•NEVER MAKE ANY ALTERATIONS or modifications to this equipment.

FAILURE TO HEED MAY RESULT IN SERIOUS PERSONAL INJURY OR DEATH

Inhaltsverzeichnis

Andere Roda Streuer Handbücher

Roda

Roda R2000 Truck Bedienungsanleitung

Beliebte Streuer Handbücher anderer Marken

PEQUEA

PEQUEA GT-100 Bedienungsanleitung

Herculano

Herculano H2RS9 Bedienungsanleitung

Epoke

Epoke SKE8 Bedienungsanleitung

GEA

GEA EL44 Technisches Datenblatt

Boss Snowplow

Boss Snowplow TGS 800 Bedienungsanleitung

Fisher

Fisher EMERSON 168 Series Bedienungsanleitung

Fisher

Fisher POLY-CASTER 78601 Bedienungsanleitung

TurfEx

TurfEx RS7200 Betriebsanleitung

Ferris

Ferris Pathfinder Series Bedienungsanleitung

Fayat Group

Fayat Group DYNAPAC S100 Fehlerbehebungshandbuch

Art's-Way Manufacturing

Art's-Way Manufacturing X700 Installations- und Betriebshandbuch

EASTMAN

EASTMAN CR 500 Bedienungsanleitung

Nogueira

Nogueira RoyalFlow-600 Bedienungsanleitung

Buyers

Buyers TGS05B Bedienungsanleitung

Magnum

Magnum V-BOX PV Series Beilage

Meyer's

Meyer's VB280 Bedienungsanleitung

SnowEx

SnowEx VX-4210 Bedienungsanleitung

Kramer

Kramer VM-400HDCP Bedienungsanleitung