Sailor 100 Handbuch

TRAINING, INSTALLATION & SERVICE MANUAL

SAILOR 100 Satellite TV

Training, installation and service manual

Document number: 98-137654-A

Release date: 29 January 2013

SAILOR100TM.book Page i Tuesday, January 29, 2013 2:44 PM

ii 98-137654-A

Disclaimer

Any responsibility or liability for loss or damage in connection with the use of this product and the

accompanying documentation is disclaimed by Thrane & Thrane. The information in this manual is

provided for information purposes only, is subject to change without notice and may contain errors

or inaccuracies. Manuals issued by Thrane & Thrane are periodically revised and updated. Anyone

relying on this information should acquire the most current version e.g. from thrane.com or from the

distributor.Thrane & Thrane is not responsible for the content or accuracy of any translations or

reproductions, in whole or in part, of this manual from any other source.

Thrane & Thrane trading as Cobham SATCOM.

Trademark acknowledgements

•Thrane & Thrane is a registered trademark of Thrane & Thrane A/S in the European Union and the

United States.

•SAILOR is a registered trademark of Thrane & Thrane A/S in the European Union and the United

States.

•Windows is a registered trademark of Microsoft Corporation in the United States and other

countries.

• Other product and company names mentioned in this manual may be trademarks or trade names

of their respective owners.

GPL notification

The software included in this product contains copyrighted software that is licensed under the

GPL/LGPL. The verbatim licenses can be found online at:

http://www.gnu.org/licenses/old-licenses/gpl-2.0.html

http://www.gnu.org/licenses/old-licenses/lgpl-2.1.html

You may obtain the complete corresponding source code from us for a period of three years after

our last shipment of this product, which will be no earlier than 2021, by sending a money order or

check for DKK 50 to:

SW Technology/GPL Compliance,

Thrane & Thrane A/S,

Lundtoftegaardsvej 93D

2800 Lyngby

DENMARK

Please write "source for product SAILOR 100 Satellite TV" in the memo line of your payment. You

may also find a copy of the source at http://www.thrane.com/foss. This offer is valid to anyone in

receipt of this information.

SAILOR100TM.book Page ii Tuesday, January 29, 2013 2:44 PM

98-137654-A iii

Safety summary

The following general safety precautions must be observed during all phases of operation,

service and repair of this equipment. Failure to comply with these precautions or with

specific warnings elsewhere in this manual violates safety standards of design,

manufacture and intended use of the equipment. Thrane & Thrane A/S assumes no liability

for the customer's failure to comply with these requirements.

Distance to other equipment

Do not move the Above Deck Unit closer to radars than the minimum safe distance

specified in section Interference on page 3-12 — it may cause damage to the Above Deck

Unit.

Compass Safe Distance:

SAILOR 100 Satellite TV antenna or ADU (Above Deck Unit): min. 130 cm (IEC 945).

SAILOR 100 Satellite TV ACU (Antenna Control Unit): min. 10 cm (IEC 945)

Service

User access to the interior of the ACU is prohibited. Only a technician authorized by Thrane

& Thrane A/S may perform service - failure to comply with this rule will void the warranty.

Access to the interior of the Above Deck Unit is allowed. Replacement of certain modules -

as described in Service & maintenance on page 8-1 and general service may only be

performed by a technician authorized by Thrane & Thrane A/S.

Do not service or adjust alone

Do not attempt internal service or adjustments unless another person, capable of

rendering first aid resuscitation, is present.

Grounding, cables and connections

To minimize shock hazard and to protect against lightning, the equipment chassis and

cabinet must be connected to an electrical ground. The ACU must be grounded to the ship.

For further grounding information refer to the Installation manual.

Do not extend the cables beyond the lengths specified for the equipment. The cable

between the ACU and Above Deck Unit can be extended if it complies with the specified

data concerning cable losses etc.

Rx cables for the SAILOR 100 Satellite TV system are shielded and should not be affected by

magnetic fields. However, try to avoid running cables parallel to high power and AC/RF

wiring as it might cause malfunction of the equipment.

Power supply

The voltage range for the SAILOR 100 Satellite TV is 20 — 32 VDC. Note that the Above Deck

Unit is powered by the ACU.

If a 24 VDC power bus is not available, an external 115/230 VAC to 28 VDC power supply can

be used, for example a SAILOR 6080 Power Supply.

SAILOR100TM.book Page iii Tuesday, January 29, 2013 2:44 PM

iv 98-137654-A

Do not operate in an explosive atmosphere

Do not operate the equipment in the presence of flammable gases or fumes. Operation of

any electrical equipment in such an environment constitutes a definite safety hazard.

Keep away from live circuits

Operating personnel must not remove equipment covers. Component replacement and

internal adjustment must be made by qualified maintenance personnel. Do not replace

components with the power cable connected. Under certain conditions, dangerous

voltages may exist even with the power cable removed. To avoid injuries, always

disconnect power and discharge circuits before touching them.

Failure to comply with the rules above will void the warranty!

SAILOR100TM.book Page iv Tuesday, January 29, 2013 2:44 PM

98-137654-A v

Table of contents

Chapter 1 About this manual

1.1 Intended readers ................................................................................ 1-1

1.2 Manual overview ...............................................................................1-1

1.3 Software version ................................................................................ 1-1

1.4 Related documents ............................................................................ 1-2

1.5 Typography ....................................................................................... 1-2

1.6 Precautions ....................................................................................... 1-3

Chapter 2 Introduction

2.1 SAILOR 100 Satellite TV system ......................................................... 2-1

2.1.1 Above Deck Unit (ADU) ....................................................................2-3

2.1.2 Antenna Control Unit (ACU) .............................................................2-7

2.1.3 Control Panel for setup and operation .............................................2-9

2.1.4 Multiswitch (optional) .....................................................................2-9

2.1.5 SAILOR Transmodulator (optional) ..................................................2-9

2.1.6 Power supply (optional) ................................................................ 2-10

2.1.7 System configuration example ...................................................... 2-10

2.2 Part numbers and options ................................................................ 2-11

2.2.1 Applicable Thrane & Thrane model and part numbers .................... 2-11

2.2.2 Options for SAILOR 100 Satellite TV ................................................. 2-11

SAILOR100TM.book Page v Tuesday, January 29, 2013 2:44 PM

Table of contents

vi 98-137654-A

Chapter 3 Installation

3.1 Unpacking .........................................................................................3-1

3.1.1 What’s in the box .............................................................................3-1

3.1.2 Control Panel .................................................................................. 3-2

3.1.3 Initial inspection ............................................................................. 3-2

3.1.4 Tools needed .................................................................................. 3-2

3.2 Site preparation ................................................................................ 3-3

3.2.1 General site considerations ............................................................. 3-3

3.2.2 Obstructions (ADU shadowing) ....................................................... 3-4

3.2.3 Blocking zones — azimuth and elevation .........................................3-5

3.2.4 Ship motion and offset from the ship’s motion centre .....................3-6

3.2.5 ADU mast design: Foundation and height ....................................... 3-7

3.2.6 Interference ...................................................................................3-12

3.2.7 Other precautions ..........................................................................3-16

3.3 Installation of the ADU .....................................................................3-17

3.3.1 Installing the ADU ..........................................................................3-18

3.3.2 Opening and removing the service hatch .......................................3-21

3.3.3 Grounding the ADU ....................................................................... 3-22

3.3.4 Alternative ADU cable ................................................................... 3-23

3.4 Installation of the ACU .................................................................... 3-23

3.4.1 Installing the ACU ......................................................................... 3-23

3.4.2 Grounding the ACU ....................................................................... 3-24

3.5 Installation of the Control Panel ...................................................... 3-25

SAILOR100TM.book Page vi Tuesday, January 29, 2013 2:44 PM

Table of contents

98-137654-A vii

Chapter 4 Interfaces

4.1 Interfaces of the SAILOR 100 Satellite TV ACU ................................... 4-1

4.1.1 LEDs, display and keypad ................................................................ 4-1

4.1.2 Connector panel — overview ............................................................4-2

4.1.3 DC Input connector ..........................................................................4-2

4.1.4 ADU connector ................................................................................4-3

4.1.5 Rx connector ..............................................................................4-3

4.1.6 TV output connectors (x4) ................................................................4-4

4.1.7 DC output connector ........................................................................4-4

4.1.8 NMEA 0183 connector (RS-422) .......................................................4-5

4.1.9 DB9 connector ................................................................................4-6

4.1.10 LAN1, LAN2, LAN3 and LAN4 connectors ..........................................4-6

4.2 Interfaces of the Control Panel ..........................................................4-7

4.3 Interfaces of the SAILOR Transmodulator (optional) ..........................4-7

Chapter 5 Connecting power

5.1 Power source .................................................................................... 5-1

5.2 Power cable selection .......................................................................5-2

5.2.1 Source impedance ...........................................................................5-2

5.2.2 Measuring the ship source impedance ............................................5-2

5.2.3 Power cable recommendations .......................................................5-3

5.3 Connecting power .............................................................................5-4

5.4 Power up ..........................................................................................5-5

Chapter 6 Configuration

6.1 Introduction to the configuration tools .............................................. 6-1

6.1.1 Overview ......................................................................................... 6-1

6.1.2 Connecting to the web interface ......................................................6-2

6.1.3 Connecting the Control Panel ..........................................................6-3

6.2 Calibration of the SAILOR 100 Satellite TV .........................................6-4

6.2.1 Heading and calibration of azimuth ................................................6-4

SAILOR100TM.book Page vii Tuesday, January 29, 2013 2:44 PM

Table of contents

viii 98-137654-A

6.3 Configuration with the web interface ...............................................6-8

6.3.1 Overview and navigation .................................................................6-8

6.3.2 Using the Dashboard ..................................................................... 6-11

6.3.3 Satellite profiles .............................................................................6-14

6.3.4 TV satellites ...................................................................................6-17

6.3.5 Reference satellites ........................................................................6-19

6.3.6 Azimuth adjustment .......................................................................6-21

6.3.7 Setting up Blocking zones ............................................................. 6-23

6.3.8 Configuring the LAN network ........................................................ 6-25

6.3.9 E-mail setup ................................................................................. 6-28

6.3.10 Sending statistics reports .............................................................. 6-29

6.3.11 Sending a diagnostics report ........................................................ 6-32

6.3.12 Upload .......................................................................................... 6-33

6.3.13 Administration .............................................................................. 6-33

6.4 Configuration with the Control Panel .............................................. 6-38

6.4.1 Getting started ..............................................................................6-38

6.4.2 Creating or editing a profile ..........................................................6-40

6.4.3 Selecting the active profile ............................................................ 6-42

6.4.4 Deleting a profile .......................................................................... 6-43

6.4.5 Event list ....................................................................................... 6-43

6.4.6 Help .............................................................................................. 6-44

6.4.7 About ............................................................................................ 6-44

6.5 Keypad and menus of the ACU ........................................................ 6-45

6.5.1 ACU display and keypad ............................................................... 6-45

6.5.2 Navigating the menus ................................................................... 6-46

6.5.3 The menu tree .............................................................................. 6-46

6.5.4 Adjusting brightness of the display ............................................... 6-49

6.5.5 Resetting the system .....................................................................6-50

Chapter 7 Installation check

7.1 Installation check list: Antenna ..........................................................7-1

7.2 Installation check list: ACU, connectors and wiring ........................... 7-3

7.3 Installation check list: Control Panel ................................................. 7-5

7.4 Installation check list: Functional test in harbor ................................ 7-6

SAILOR100TM.book Page viii Tuesday, January 29, 2013 2:44 PM

Andere Handbücher für 100

Inhaltsverzeichnis

Andere Sailor Satellitenfernsehsystem Handbücher

Sailor

Sailor 100 Bedienungsanleitung

Beliebte Satellitenfernsehsystem Handbücher anderer Marken

Dish TV

Dish TV DVB-S6800PLUS Bedienungsanleitung

Avermedia

Avermedia AVer3D R889 Bedienungsanleitung

Kathrein

Kathrein MobiSet 2 Digital CAP 600 Bedienungsanleitung

KVH Industries

KVH Industries TracVision R5SL Bedienungsanleitung

Philips

Philips DSX 5250 Bedienungsanleitung

Winegard

Winegard RMFLDM4 Bedienungsanleitung

DefineSat

DefineSat VM55 Bedienungsanleitung

Dish Network

Dish Network 112182 Bedienungsanleitung

Thrane&Thrane

Thrane&Thrane sailor 60 Technisches Handbuch

KVH Industries

KVH Industries TracVision L2 Bedienungsanleitung

KVH Industries

KVH Industries TracVision TV1 Bedienungsanleitung

JRC

JRC NJT8304 Series Bedienungsanleitung

Bell

Bell EXPRESSVU Bedienungsanleitung

Promax

Promax SATHUNTER Bedienungsanleitung

SatKing

SatKing PRO MAX Bedienungsanleitung

KVH Industries

KVH Industries TracVision M5 Bedienungsanleitung

KVH Industries

KVH Industries TracVision R5SL Bedienungsanleitung

Dish Network

Dish Network Satellite Television Bedienungsanleitung