Sierra Wireless AirPrime AR7582 Kurzanleitung zur Einrichtung

4111xxxx

0.2

July 6, 2018

AirPrime AR7582

Hardware Integration Guide

41110461XXXX Rev 0.12 January 16, 2017 2

Hardware Integration Guide

Important Notice

Due to the nature of wireless communications, transmission and reception of data can never be

guaranteed. Data may be delayed, corrupted (i.e., have errors) or be totally lost. Although significant

delays or losses of data are rare when wireless devices such as the Sierra Wireless modem are used

in a normal manner with a well-constructed network, the Sierra Wireless modem should not be used

in situations where failure to transmit or receive data could result in damage of any kind to the user or

any other party, including but not limited to personal injury, death, or loss of property. Sierra Wireless

accepts no responsibility for damages of any kind resulting from delays or errors in data transmitted or

received using the Sierra Wireless modem, or for failure of the Sierra Wireless modem to transmit or

receive such data.

Safety and Hazards

Do not operate the Sierra Wireless modem in areas where cellular modems are not advised without

proper device certifications. These areas include environments where cellular radio can interfere such

as explosive atmospheres, medical equipment, or any other equipment which may be susceptible to

any form of radio interference. The Sierra Wireless modem can transmit signals that could interfere

with this equipment. Do not operate the Sierra Wireless modem in any aircraft, whether the aircraft is

on the ground or in flight. In aircraft, the Sierra Wireless modem MUST BE POWERED OFF. When

operating, the Sierra Wireless modem can transmit signals that could interfere with various onboard

systems.

Note: Some airlines may permit the use of cellular phones while the aircraft is on the ground and the door

is open. Sierra Wireless modems may be used at this time.

The driver or operator of any vehicle should not operate the Sierra Wireless modem while in control of

a vehicle. Doing so will detract from the driver or operator’s control and operation of that vehicle. In

some states and provinces, operating such communications devices while in control of a vehicle is an

offence.

Limitations of Liability

This manual is provided “as is”. Sierra Wireless makes no warranties of any kind, either expressed or

implied, including any implied warranties of merchantability, fitness for a particular purpose, or

noninfringement. The recipient of the manual shall endorse all risks arising from its use.

The information in this manual is subject to change without notice and does not represent a

commitment on the part of Sierra Wireless. SIERRA WIRELESS AND ITS AFFILIATES

SPECIFICALLY DISCLAIM LIABILITY FOR ANY AND ALL DIRECT, INDIRECT, SPECIAL,

GENERAL, INCIDENTAL, CONSEQUENTIAL, PUNITIVE OR EXEMPLARY DAMAGES INCLUDING,

BUT NOT LIMITED TO, LOSS OF PROFITS OR REVENUE OR ANTICIPATED PROFITS OR

REVENUE ARISING OUT OF THE USE OR INABILITY TO USE ANY SIERRA WIRELESS

PRODUCT, EVEN IF SIERRA WIRELESS AND/OR ITS AFFILIATES HAS BEEN ADVISED OF THE

POSSIBILITY OF SUCH DAMAGES OR THEY ARE FORESEEABLE OR FOR CLAIMS BY ANY

THIRD PARTY.

Notwithstanding the foregoing, in no event shall Sierra Wireless and/or its affiliates aggregate liability

arising under or in connection with the Sierra Wireless product, regardless of the number of events,

occurrences, or claims giving rise to liability, be in excess of the price paid by the purchaser for the

Sierra Wireless product.

41110461XXXX Rev 0.12 January 16, 2017 3

Hardware Integration Guide

Patents

This product may contain technology developed by or for Sierra Wireless Inc.

This product includes technology licensed from QUALCOMM®.

This product is manufactured or sold by Sierra Wireless Inc. or its affiliates under one or more patents

licensed from InterDigital Group and MMP Portfolio Licensing.

Trademarks

Sierra Wireless®, AirPrime®, AirLink®, AirVantage®, WISMO®, ALEOS®and the Sierra Wireless and

Open AT logos are registered trademarks of Sierra Wireless, Inc. or one of its subsidiaries.

Watcher®is a registered trademark of Netgear, Inc., used under license.

Windows®and Windows Vista®are registered trademarks of Microsoft Corporation.

Macintosh®and Mac OS X®are registered trademarks of Apple Inc., registered in the U.S. and other

countries.

QUALCOMM®is a registered trademark of QUALCOMM Incorporated. Used under license.

Other trademarks are the property of their respective owners.

Contact Information

Sales information and technical support,

including warranty and returns

Web: sierrawireless.com/company/contact-us/

Global toll-free number: 1-877-687-7795

6:00 am to 6:00 pm PST

Corporate and product information

Web: sierrawireless.com

41110461XXXX Rev 0.12 January 16, 2017 4

Hardware Integration Guide

Document History

Version

Date

Updates

0.1

May 12, 2017

Creation

0.2

July 7, 2018

Add one more compliance information in section 5

41110461 Rev 0.1 January 16, 2017 5

Contents

1. INTRODUCTION ..................................................................................................9

1.1. General Features ..............................................................................................................9

1.2. Power ................................................................................................................................9

1.3. RF......................................................................................................................................9

1.3.1. GSM RF Interface ....................................................................................................10

1.3.1.1. GSM TX Output Power..................................................................................................10

1.3.1.2. GSM RX Sensitivity.......................................................................................................10

1.3.2. WCDMA RF Interface ..............................................................................................11

1.3.2.1. WCDMA TX Output Power............................................................................................11

1.3.2.2. WCDMA RX Sensitivity.................................................................................................11

1.3.3. LTE RF Interface......................................................................................................12

1.3.3.1. LTE TX Output Power...................................................................................................12

1.3.3.2. LTE RX Sensitivity ........................................................................................................12

1.3.4. WWAN Antenna Interface........................................................................................13

1.3.4.1. WWAN Antenna Recommendations .............................................................................14

1.4. GNSS ..............................................................................................................................15

1.4.1. GNSS Receiver........................................................................................................15

1.4.2. GNSS Antenna Interface..........................................................................................16

1.4.2.1. GNSS Antenna Recommendations...............................................................................17

1.5. Electrical Specifications...................................................................................................17

1.5.1. Absolute Maximum Ratings .....................................................................................17

1.5.2. Digital IO Characteristics..........................................................................................17

2. AUDIO SPECIFICATION....................................................................................20

2.1. Digital Audio ....................................................................................................................20

3. ROUTING CONSTRAINTS AND RECOMMENDATIONS .................................21

3.1. RF Routing Recommendations.......................................................................................21

3.2. USB Routing Recommendations.....................................................................................23

3.3. Power and Ground Recommendations...........................................................................23

3.4. Antenna Recommendations............................................................................................24

3.5. Interface Circuit Recommendations................................................................................24

4. FIRMWARE AND TOOLS..................................................................................25

4.1. Modem Firmware.............................................................................................................25

4.2. Tools................................................................................................................................25

5. APPROVAL........................................................................................................26

5.1. Important Notice..............................................................................................................26

5.2. Safety and Hazards.........................................................................................................26

5.3. Important Compliance Information..................................................................................26

5.4. IC Regulations.................................................................................................................28

5.4.1. Radiation Exposure Statement ................................................................................28

6. REFERENCES ...................................................................................................29

41110461XXXX Rev 0.12 January 16, 2017 6

Hardware Integration Guide

7. ABBREVIATIONS..............................................................................................30

41110461 Rev 0.1 January 16, 2017 7

List of Figures

Figure 1. AppCAD Screenshot for Microstrip Design Power Mode Diagram.................................21

Figure 2. RF Routing Examples .....................................................................................................22

Figure 3. Coplanar Clearance Example .........................................................................................22

Figure 4. Antenna Microstrip Routing Example..............................................................................23

Figure 5. AirPrime AR758x Series Interface Reference Circuit......................................................24

41110461 Rev 0.1 January 16, 2017 8

List of Tables

Table 1. AirPrime AR758x Series Embedded Modules ..................................................................9

Table 2. AirPrime AR758x Series Supported Carrier Aggregation Combinations1.........................9

Table 3. Power Supply Requirements.............................................................................................9

Table 4. Power Supply Pads...........................................................................................................9

Table 5. Conducted TX (Transmit) Max output Power Tolerances –GSM/EDGE Bands............10

Table 6. Conducted RX (Receive) Sensitivity –GSM/EDGE Bands ............................................10

Table 7. Conducted TX (Transmit) Max output Power Tolerances –WCDMA Bands .................11

Table 8. Conducted Primary RX (Receive) Sensitivity –UMTS Bands1.......................................11

Table 9. Conducted Secondary RX (Receive) Sensitivity –UMTS Bands1..................................11

Table 10. Conducted TX (Transmit) Max output Power Tolerances –LTE Bands.........................12

Table 11. Conducted RX Sensitivity 3GPP (BW: 10MHz) –LTE Bands1, 4.....................................13

Table 12. Conducted RX Sensitivity SISO (BW: 10MHz) –LTE Bands1........................................13

Table 13. WWAN Antenna Interface Pads......................................................................................13

Table 14. AirPrime AR758x Series WWAN Antenna Recommendations.......................................14

Table 15. GNSS Specifications.......................................................................................................15

Table 16. GNSS Antenna Interface Pads........................................................................................16

Table 17. AirPrime AR758x Series Absolute Maximum Ratings.....................................................17

Table 18. Digital IO Characteristics for VCC=1.8V Nominal...........................................................17

Table 19. Digital IO Characteristics for SDIO VCC=1.8V Nominal .................................................18

Table 20. Digital IO Characteristics for SDIO VCC=2.85V Nominal ...............................................19

Table 21. Digital IO Characteristics for UICC_VCC=1.8V Nominal ................................................19

Table 22. Digital IO Characteristics for UICC_VCC=2.85V Nominal ..............................................19

Table 23. Digital Audio Interface Pads1...........................................................................................20

Table 24. Approved Antenna Types................................................................................................28

Table 25. Reference Specifications.................................................................................................29

Table 26. Abbreviations...................................................................................................................30

41110461 Rev 0.1 January 16, 2017 9

1. Introduction

1.1. General Features

The AirPrime AR7582 embedded modules are designed for the automotive industry. It support LTE,

WCDMA and GSM air interface standards. It also have Global Navigation Satellite System (GNSS)

capabilities including GPS, GLONASS, Galileo, BeiDou, and QZSS

The AirPrime AR7582 embedded modules are based on the Qualcomm MDM9628 wireless chipset

and support the following bands.

Table 1. AirPrime AR758x Series Embedded Modules

Product

Description

Band Support

Target

Region1

AR7582

LTE-CA / WCDMA / GSM /

GPRS / EDGE embedded

module

LTE: B2, B4, B5, B7*, B12, B13*, B17

WCDMA: B2, B4, B5, B6

GSM/GPRS/EDGE: 850/1900

North America

(Canada, US,

Mexico)

1 Other regions or operators which use the same frequency bands may also be supported, subject to review and

confirmation by Sierra Wireless.

* Optional band

1.2. Power

The AirPrime AR7582 are powered via a single regulated DC power supply, 3.7V nominal.

Table 2. Power Supply Requirements

Power Supply

Min

Typ

Max

Units

Main DC Power Input Range (VBATT)

3.4

3.7

4.2

Power Supply

Ripple

0 to 1kHz

200

mVpp

>1kHz

mVpp

Peak Current

AR758x

2000

3000

Table 3. Power Supply Pads

Pad

Name

Direction

Function

If Unused

EA2

VBATT

Input

Power Supply Input

Must Be Used

EB2

VBATT

Input

Power Supply Input

Must Be Used

EC2

VBATT

Input

Power Supply Input

Must Be Used

1.3. RF

This section presents the WWAN RF interface of the AirPrime AR7582. The specifications for the

LTE, GSM and WCDMA interfaces are defined.

41110461XXXX Rev 0.12 January 16, 2017 10

Hardware Integration Guide

Introduction

1.3.1. GSM RF Interface

This section presents the GSM RF Specification for the AirPrime AR7582.

1.3.1.1. GSM TX Output Power

The GSM Maximum Transmitter Output Power of the AirPrime AR7582 are specified in the following

table.

Note: All values presented in the table below are preliminary.

Table 4. Conducted TX (Transmit) Max output Power Tolerances –GSM/EDGE Bands

Band

Standard 1

(dBm)1

Standard 2

(dBm)2

TX Power @

Room (dBm)

TX Power @

Class A (dBm)3

Notes

GSM 850

33±2dB

33±2.5dB

33±2dB

33±2.5dB

GMSK mode,

connectorized(Class 4;

2 W, 33 dBm)

EGSM

900

33±2dB

33±2.5dB

33±2dB

33±2.5dB

GSM

1800

30±2dB

30±2.5dB

30±2dB

30±2.5dB

GMSK mode,

connectorized(Class 1;

1 W, 30 dBm)

GSM

1900

30±2dB

30±2.5dB

30±2dB

30±2.5dB

GSM 850

27±3dB

27±4dB

27±2.5dB

27±3.5dB

8PSK mode,

connectorized(Class

E2; 0.5 W, 27 dBm)

EGSM

900

27±3dB

27±4dB

27±2.5dB

27±3.5dB

GSM

1800

26±3dB

26±4dB

26 ±2.5dB

26±3.5dB

8PSK mode,

connectorized(Class

E2; 0.4 W, 26 dBm)

GSM

1900

26±3dB

26±4dB

26 ±2.5dB

26±3.5dB

1 Per 3GPP TS 51.010-1 Requirement for Normal condition.

2 Per 3GPP TS 51.010-1 Requirement for Extreme conditions

3 Test at Class A extreme condition

1.3.1.2. GSM RX Sensitivity

The GSM Receiver Sensitivities of the AirPrime AR758x Series are specified in the following table.

Table 5. Conducted RX (Receive) Sensitivity –GSM/EDGE Bands

GSM/EDGE Bands

Limit (dBm)1

Room

Typical

(dBm)

Class A

(Extreme)

Typical (dBm)2

Class A

Limit (dBm)

GSM 850

2% BER CS

-102

-108,5

-108

-103

10% BLER

GMSK CS1

-104

-108

-107

-105

10% BLER

EDGE MCS5

-98

-103.5

-102

-99

PCS 1900

2% BER CS

-102

-108.5

tbd

-103

10% BLER

GMSK CS1

-104

-108.5

-107.5

-105

10% BLER

EDGE MCS5

-98

-103.5

-102

-99

1 Per 3GPP specification

2 Test at Class A extreme condition

Inhaltsverzeichnis

Andere Sierra Wireless Modem Handbücher

Sierra Wireless

Sierra Wireless AirCard 595 Bedienungsanleitung

Sierra Wireless

Sierra Wireless AirLink Raven XT Bedienungsanleitung

Sierra Wireless

Sierra Wireless iPASS Bedienungsanleitung

Sierra Wireless

Sierra Wireless AirPrime MC8775 Bedienungsanleitung

Sierra Wireless

Sierra Wireless AirCard 402 Bedienungsanleitung

Sierra Wireless

Sierra Wireless Sprint AirCard 580 Bedienungsanleitung

Sierra Wireless

Sierra Wireless AIRPRIME WISMO218 Bedienungsanleitung

Sierra Wireless

Sierra Wireless AirPrime EM7355 Kurzanleitung zur Einrichtung

Sierra Wireless

Sierra Wireless AirCard Bedienungsanleitung

Sierra Wireless

Sierra Wireless AT&T USBConnect Shockwave Bedienungsanleitung

Sierra Wireless

Sierra Wireless AIRCARD 595U Bedienungsanleitung

Sierra Wireless

Sierra Wireless PinPoint X Bedienungsanleitung

Sierra Wireless

Sierra Wireless MP 880W Bedienungsanleitung

Sierra Wireless

Sierra Wireless U598 Bedienungsanleitung

Sierra Wireless

Sierra Wireless USB 598 Bedienungsanleitung

Sierra Wireless

Sierra Wireless 306 Bedienungsanleitung

Sierra Wireless

Sierra Wireless Bell 313U Bedienungsanleitung

Sierra Wireless

Sierra Wireless Raven 1x Bedienungsanleitung

Sierra Wireless

Sierra Wireless 305 Bedienungsanleitung

Sierra Wireless

Sierra Wireless MP 875 Bedienungsanleitung

Sierra Wireless

Sierra Wireless AIRCARD 595U Bedienungsanleitung

Sierra Wireless

Sierra Wireless AirLink GL7 00 Series Bedienungsanleitung

Sierra Wireless

Sierra Wireless AirCard 330U Bedienungsanleitung

Sierra Wireless

Sierra Wireless MP597 Bedienungsanleitung

Beliebte Modem Handbücher anderer Marken

Davicom

Davicom DM562AP Bedienungsanleitung

EpiValley

EpiValley TATA indicom SXC-1080 Bedienungsanleitung

Zte

Zte WiMAX Bedienungsanleitung

Intelimax

Intelimax MA-2060 Bedienungsanleitung

SMC Networks

SMC Networks D3CM1604V Gebrauchs- und Pflegehandbuch

Telstra

Telstra Wi-Fi 4G Advanced Pro X Bedienungsanleitung

Thrane&Thrane

Thrane&Thrane imarsat EXPLORER 300 Bedienungsanleitung

Samsung

Samsung AceLink SAM-335A Bedienungsanleitung

Enfora

Enfora Enabler-G Kurzanleitung zur Einrichtung

iRZ

iRZ ATM2-232 Bedienungsanleitung

Zhone

Zhone 6310 Bedienungsanleitung

Paradyne

Paradyne Hotwire 7976 Bedienungsanleitung

US Robotics

US Robotics 3453C Bedienungsanleitung

MaxTech

MaxTech Plug & Play Internal Voice/FAX/Data/SVD... Bedienungsanleitung

Zte

Zte MF823 Bedienungsanleitung

Four-Faith

Four-Faith F1403 Bedienungsanleitung

Gemtek

Gemtek WiMAX WIXFBR-103 Bedienungsanleitung

Zoom

Zoom 1070 Series Bedienungsanleitung