Silvan Selecta Spotpak 50L Bedienungsanleitung

Instruction Manual

MANSP50 REV F 01/04/16

Spotpak

50L

100L

200L

SILVAN AUSTRALIA PTY. LTD.

ABN 48 099 851 144

VICTORIA (HEAD OFFICE)

244- 264 Greens Rd,

Dandenong South, 3175 Australia

Telephone: +61 (03) 9215 2700

Facsimile: +61 (03) 9215 2701

www.silvan.com.au

NEW ZEALAND

22 Sunshine Avenue

Te Rapa, Hamilton, 2001 New Zealand

Telephone: +64 (07) 8496033

Fax: +64 (07) 8496070

www.silvannz.co.nz

SilvanWarranty

Our goods come with guarantees that cannot be excluded under the Australian Consumer

Law. You are entitled to a replacement or refund for a major failure and for compensation

for any other reasonably foreseeable loss or damage. You are also entitled to have the

goods repaired or replaced if the goods fail to be of acceptable quality and the failure does

not amount to a major failure.

Wewarrantourgoodstobefreefromdefectsinmaterialsandworkmanshipforthewarrantyperiodof

12monthsfromthedatetheproductisdeliveredtotheconsumer.

SilvanwarrantsitsauthorisedDealer,whointurnwarrantstheoriginalpurchaser(consumer)ofeach

newSilvanproductthatitwillrepairorreplacetheproduct,or,paythecostofrepairorreplacement,

asdeterminedbySilvanwithoutchargeforlabouroranydefectiveormalfunctioningpartsin

accordancewiththewarrantylimitationsbelow.

ThisWarrantyisinadditiontoanyotherrightsandremediesavailabletoconsumersunderthelaw



This Warranty Covers

Onlyconditionsresultingdirectlyfromdefectsinworkmanshipormaterialundernormaluseand

service.



Warranty Exclusions

TheWarrantydoesnotcover:

• Conditionsresultingfrommisuse,useofincompatiblechemicals,exceedingmachine

specificationsincludingoverloading,impactdamage,negligence,accidentaldamageorfailure

toperformrecommendedmaintenanceservicesasspecifiedintheOwner/OperatorManual

applicabletotheproduct.

• Damagecausedbycontinueduseofaproductafterinitialfailure

• AnyproductwhichhasbeenrepairedbyotherthananauthorisedSilvanserviceoutletinaway

which,inthesoleandabsolutejudgmentofSilvan,adverselyaffectitsperformanceor

reliability.

• Thereplacementofmaintenanceitemssuchasdiaphragms,batteries,Vbeltsandground

engagingcomponents,etc.



How to claim Warranty

Returnthegoodstotheplaceofpurchaseatyourcostandwithinthewarrantyperiodalongwith

evidenceofthepurchasedate.IftheoriginalsuppliercannotbecontactedthencontactSilvanasbelow

andwecandirectyouonhowtoproceedwithyourwarrantyclaim.



How your claim will be managed

Therepairofadefectiveproductqualifyingunderthiswarrantywillbeperformedbyanyauthorised

Silvanserviceoutletwithinareasonabletimefollowingthedeliveryoftheproduct,atthecostofthe

owner,totheserviceoutlet’splaceofbusiness.Theproductwillberepairedorreplaceddependingon

theextentoftheproblematthediscretionofSilvanandtheSilvandealer.

New Product Warranty

Warnings !

You need to read carefully and take note of the following warnings before attempting to operate or install this sprayer.

Failure to comply with these warnings may result in serious injury or death.

Warning ! This sprayer is designed and manufactured solely for the purpose of applying agricultural chemicals to plants.

Under no circumstances may it be used for any other purposes.

Warning ! Prior to sprayer usage all users and operators must have read and fully understand the contents of this

operation manual

Warning ! Do not exceed the the vehicle manufacturer’s specified safe load and carrying capacity.

Warning ! Exercise extreme care when operating in hilly or uneven terrain to ensure proper stability. Refer also to the

vehicle manufacturer’s operating and safety instructions

Warning ! Refer to the chemical manufacturer’s label for correct use and safe handling instructions of chemicals before

use

Warning ! Never allow inadequately trained personnel to attach or operate the implement

Warning ! Before carrying out maintenance work, wash the sprayer thoroughly to remove all toxic chemicals that may

contaminate the sprayer.

Warning ! Do not point spray gun at any part of the human body.

Warning ! Do not pump flamable liquids or operate the pump in an explosive environment.

The following “Safety” decal should be fitted to the machine at all times in the location shown in the diagram. If the decal

is missing or unreadable it should be replaced by ordering a new decal from your Silvan dealer by the part number, DEC

90.

P/No DEC48

Safety Information

GENERAL

The Silvan Spotpak is a compact portable sprayer.

Whether you are a commercial grower, or a home gardener you will find many uses for this unit. The tank pump and

wand fittings are corrosion resistant and are suitable for applying weedicides, herbicides, insecticides, fungicides,

miticides, organic and green formulations.

It is designed for spot spraying but may be used in conjunction with a boom for boom spraying.

STANDARD SPECIFICATIONS

IMPORTANT INFORMATION ABOUT SPOT SPRAYERS

Silvan Spotpak’s feature a positive displacement diaphragm pump with a pressure sensing switch. The pressure switch

interrupts power to the pump when the system pressure builds towards maximum and power is resumed to the motor

when the pressure falls.

When the spray lance trigger is depressed fluid is released and the pressure will drop allowing the pressure switch to

resume power to the pumps motor.

Depending on your spraying requirements you may need to change or adjust the nozzle to suit your desired droplet size or

spray pressure.

Spotpak’s fitted with the Smoothflo model pump are designed not to pulsate and should stop pumping when the valve or

spray gun trigger is released. If the pump fails to stop pumping see the trouble shooting section.

TANK

50, 100 or 200 liter molded translucent U.V. stabilized

and impact resistant polyethylene. Screw on lid has

anti-spill breather.

PUMP

Smoothflo 12 volt DC electric, 7 L/min open

flow, Max 120psi on demand electric

pressure switch. Valves: Viton, Diaphragm:

Santoprene. The Smoothflo pump is designed

with adaptive pressure sensing technology that

prevents pressure spikes while maintaining

higher pressures and flows

CONTROLS

On/Off power switch.

The pump is fitted with an automatic electric pressure

sensing switch which automatically starts the pump

when the pressure falls and stops the pump when the

pressure reaches 120 psi

HOSE

6 metre delivery hose standard.

LANCE

Lightweight lance with adjustable nozzle.

FILTRATION

Suction line foot filter.

DIMENSIONS

50 LITRE 100 LITRE 200 LITRE

Length 700 mm 800 mm 1000 mm

Width 400 mm 475 mm 540 mm

Height 300 mm 395 mm 530 mm

Capacity 50 liters 100 liters 200 liters

Weight 6 kg 10 kg 14 kg

Specifications

Do not exceed the vehicle manufacturer’s specified safe load and carrying capacity.

SETTING UP YOUR SPOTPAK

The hose is supplied fitted at one end to the spray lance.

Fit the white elbow fitting to the outlet of the pump and finger tighten.

FITTING INSTRUCTIONS

Position the sprayer so as to minimise contamination to the operator. With the pump mounted away from operator the

risk of contamination due to hose failure can be minimised. It is recommended that the sprayer be securely attached to

any ATV or other vehicle. Refer to manufacturer’s instructions for appropriate load limits and fitting positions.

Note : 1 litre of water = 1 kg.

Never fill spray tank to a capacity beyond the specified overall weight limits set by your vehicle manufacturer. Recesses

in the top of the tank allow for tie down straps. When fitted these should be firmly secured to approved attachment

points on the ATV or other vehicle.

The sprayer should be mounted centrally and as near to the centre of gravity of the ATV as possible. It should not

protrude so as to cause an obstruction.

CONNECT GUN AND TRIGGER

For 50L spotpak sprayer, there is a gasket which

should fit between lance and trigger. The small

side is positioned face to trigger.

SPRAY LANCE HOLDER

Supplied with the Spotpak is a pair of clips for holding the

Spray lance to the tank for easy storage and transport. To fit

orientate the clip as shown and pres to the locating lug in the

tank. Below the Lug is a threaded brass insert embedded in

the tank; attach the provided screw to tank using a phillips

head screwdriver.

Installation

CONNECTING TO 12 VOLT DC SUPPLY

The Sprayer requires a 12 volt DC power source. A three metre loom is provided

with the sprayer to allow the sprayer to be connected to the 12 volt DC source

available. Connect the alligator clips remembering the brown or red wire is positive

and the blue or black is negative. The other end of the power loom features a plug

with keyway to ensure connection with correct polarity that connects to the pump. If

you extend the wire use wire of the same gauge or larger.

An on/off switch is fitted to the sprayer to allow the sprayer to be switched off from

the 12 volt DC source to prevent accidental drain of power. The switch also allows

the pump to be shut down when the tank is empty preventing overheating and damage

to the pump.

The wiring loom is installed with a 10 amp blade fuse to prevent any potential

damage to the electrical system of the vehicle.

SETUP AND TESTING.

It is always recommended that you first test all spray equipment thoroughly with clean water.

Silvan Spotpaks are supplied with a blue adjustable nozzle containing a large orifice which when twisting the tip can

allow for a greater flow of liquid. It is recommended that adjustable nozzle is used first and can be changed later if you

require.

1. Be sure to wear safety equipment as recommended by the chemical manufacturer before adding chemical to the

sprayer

2. Check the suction line foot filter is clean and undamaged (see Maintenance section).

3. Fill the tank with clean water.

4. With the 12 volt supply connected and the 6 meter spray hose and spray lance connected. Fit the blue adjustable

nozzle or any large orifice nozzle you may wish to use.

5. Check all pipes, hoses, hose clamps and connections for leaks or damage.

6. Switch the pump ON.

7. Depress the spray lance trigger. The pump is self priming and will start spraying within 30 seconds.

8. Check the hose connections for leaks, if any are found stop the pump and rectify the problem before continuing.

9. Slowly twist the tip of the nozzle from a course droplet size to a fine droplet to your preference. You can check the

spray pattern by spray pattern by spraying water on to a dry concrete floor.

Maintenance

Dispose of unused chemical and water used for rinsing in a manner that will not endanger people animals or

the environment.

After spraying rinse out the spray lines and tank with clean water

The foot filter should be checked and cleaned if necessary each time the tank is filled. To check the filter hook it out with

a bent piece of wire. Appropriate protective equipment including gloves should be used whenever maintenance is carried

out.

If heavy frosts are experienced, run the pump to make sure pump and spray lines are dry. This will prevent water

freezing in the pump or spray lines and damaging sprayer.

TROUBLE SHOOTING GUIDE

tom Remed

Pump does not operate

• Ensurebatterywiresareconnectedtobatteryproperly.

• ChecktheinlineFuseinthepowerloom

• Checkbatteryisnotflatorlow

• CheckterminalsarefittedtoOn/Offpowerswitch

• Checkthat2wiresareconnectedtopumppressureswitch

The pump continues to run when

the spray gun is off

• Checkifthereisaslowleakofliquid.Checkallhoseconnectionsand

thespraygunforanyleaks.

• Checkthetankisnotemptyorthesuctionfilterisnotfullyimmersed.

• Thepressureswitchmayneedadjusting,thepumpwillneedtobe

removedandgenerally1turnanticlockwisewitha1/16”allenkeywill

correcttheproblem

Pump operates with no flow or

reduced flow

• Thepumpwillonlyprimeiftheguntriggerison.

• Checkthefilterintankornozzleisnotblockedorthesprayhose

kinked.

• Pumpvalvesmaybestuckorblocked.Applyasmallamountof

pressuretothesuctionlinebyremovingthefilterandplacinga

gardenhoseoverthesuctionhoseinsidethetankwhilethepumpis

running.

Pump it getting very hot in

operation

• Voltagedrop/restrictioncausingexcessiveheat.Checkthatvoltageat

pumpis12Vwhenoperating.Removeextendedpowerloomif

requiredoruseheaviergaugewire.

• Pumpingatmaximumpressurewillusemoreampsandgenerate

moreheat.Checknozzleforrestriction

• Whenambienttemperatureisover21°Callpumpsoperatingat

higherpressureswillhaveadditionaltroubletokeepcool.Ifspraying

onhotdayconsiderusingforshorterperiodsoftimeorpumpingat

lowerpressure.

Spray Gun is leaking at lance or

nozzle • Checkiffittingisloose

• Washer/gasketbelongebetweenfittings;Checkthatparthas

notbeenlost.

Notes

SILVAN AUSTRALIA PTY. LTD.

ABN 48 099 851 144

244 – 264 Greens Rd

Dandenong South 3175

Australia

Telephone: +61 (03) 9215 2700

Facsimile: +61 (03) 9215 2701

www.silvan.com.au

SILVAN NEW ZEALAND PTY.LTD.

22 Sunshine Avenue

Te Rapa, Hamilton, 2001

New Zealand

Telephone: +64 (07) 8496030

Fax: +64 (07) 8496070

www.silvannz.co.nz

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Silvan Selecta Spritzpistole Handbücher

Silvan Selecta

Silvan Selecta WP12-1 Bedienungsanleitung

Silvan Selecta

Silvan Selecta TR13-1 Bedienungsanleitung

Silvan Selecta

Silvan Selecta TGS Bedienungsanleitung

Silvan Selecta

Silvan Selecta Rakpak Plus Bedienungsanleitung

Silvan Selecta

Silvan Selecta Utepak 100L Bedienungsanleitung

Silvan Selecta

Silvan Selecta RP50-P1 Bedienungsanleitung

Silvan Selecta

Silvan Selecta TR25-2 Bedienungsanleitung

Silvan Selecta

Silvan Selecta DEC101213P Bedienungsanleitung

Silvan Selecta

Silvan Selecta TR12-2 Bedienungsanleitung

Silvan Selecta

Silvan Selecta SPOTPAK SP50-S7 Bedienungsanleitung

Silvan Selecta

Silvan Selecta RP70N-S7 Bedienungsanleitung

Silvan Selecta

Silvan Selecta Supaflo 3500 Bedienungsanleitung

Silvan Selecta

Silvan Selecta 190545 Bedienungsanleitung

Silvan Selecta

Silvan Selecta 190547 Bedienungsanleitung

Silvan Selecta

Silvan Selecta Oktopus 500L Bedienungsanleitung

Silvan Selecta

Silvan Selecta LT30-S8 Bedienungsanleitung

Silvan Selecta

Silvan Selecta REDLINE SPOTPAK Series Bedienungsanleitung

Silvan Selecta

Silvan Selecta Super 400L Series Bedienungsanleitung

Silvan Selecta

Silvan Selecta TR25-S7 Bedienungsanleitung

Silvan Selecta

Silvan Selecta Supaflo 2000L Bedienungsanleitung

Silvan Selecta

Silvan Selecta 200 litres Bedienungsanleitung

Silvan Selecta

Silvan Selecta WP16-6 Bedienungsanleitung

Silvan Selecta

Silvan Selecta UP100-S7 Bedienungsanleitung

Silvan Selecta

Silvan Selecta K02A Bedienungsanleitung

Beliebte Spritzpistole Handbücher anderer Marken

SNOWJOE

SNOWJOE Sunjoe 24V-GS-LTW-RM Bedienungsanleitung

Graco

Graco 246737 Gebrauchs- und Pflegehandbuch

Binks

Binks SV100 Bedienungsanleitung

Fimco

Fimco LG-4-3-1 Bedienungsanleitung

AG SPRAY

AG SPRAY FS-ATV-25BL Bedienungsanleitung

Nordson

Nordson MicroMax 2 Bedienungsanleitung

Bonide

Bonide 051 Bedienungsanleitung

zogics

zogics Z-DAS Bedienungsanleitung

KISANKRAFT

KISANKRAFT KK-KBS-165 Bedienungsanleitung

Matrix

Matrix SG 650 Bedienungsanleitung

Anest Iwata

Anest Iwata SGA-3 Kurzanleitung

paasche

paasche VV Datenblatt

Carlisle

Carlisle DeVilbiss JGA-510 Bedienungsanleitung

Gardena

Gardena 11120 Bedienungsanleitung

Conrad

Conrad Hobby Airbrush K3 Bedienungsanleitung

wiwa

wiwa 14025 R/F Bedienungsanleitung

Graco

Graco EM 390 Bedienungsanleitung

DeVilbiss

DeVilbiss LUNA2i Bedienungsanleitung