SnowEx 7500 Bedienungsanleitung

4 — 1

Owner / Operator’s Manual

Spreaders for Snow & Ice Control

FOR MODEL

7500

This Manual Must Be Read Before Operating The Equipment

CUSTOMER COPY

Warren, Michigan 48089

800-800-800-725-8377725-8377725-8377

Protected by the following patents, #6,089,478, #6,088,865, #Des.425,915

and other pending U.S. and foreign patent applications.

See Back Page for Details!

Warm Up to

with a

Winter Hat!

FREE

Rev. 07

4 — 2

Table of Contents

Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3

General Information and Registration . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Safety Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

5-7

Spreader Assembly and Exploded Views. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

8-17

Wiring Instructions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Electrical System Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

19-22

Spreader Mounting System. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

23-26

Spreader Operating Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

27-30

Troubleshooting Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

31-33

Spreader Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Determine Vehicle Payload Chart . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

Blank Pages . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

36-37

Warranty . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .

38-39

Rev. 07

Introduction

This manual has been designed for your help. It will assist you and instruct you on the proper set-up, installation and use of

this spreader.

Refer to the table of contents for an outline of this manual.

We require that you read and understand the contents of this manual completely (especially all safety information) before

attempting any procedure contained herein.

THIS SIGN SHOULD ALERT YOU:

The Society of Automotive Engineers has adopted this SAFETY ALERT SYMBOL to pinpoint characteristics

that, if NOT carefully followed, can create a safety hazard. When you see this symbol in this manual or on the

machine itself, BE ALERT! Your personal safety and the safety of others is involved

Dened below are the SAFETY ALERT messages and how they will appear in this manual:

(RED)

Information that, if not carefully followed,

can cause death!

(ORANGE)

Information that, if not carefully followed,

can cause serious personal injury or death!

(YELLOW)

Information that, if not carefully followed,

can cause minor injury or damage to equipment.

Rev. 07

L1184 © Trynex International 2008

4 — 4

General Information

CONGRATULATIONS!

The spreader you have purchased is an example of snow and ice control technology at its nest! Your spreader’s, sel

f-contained

design is a trademark of all Snowex products. Here’s why...

SIMPLICITY: Fewer moving parts manufactured of higher quality means minimal maintenance for your SnowEx spreader.

RELIABILITY:

High impact linear low density polyethelyne hopper, state-of-the-art electronic dual variable speed control, custom engineered

powder coated frame, maximum torque 12 volt motor coupled to a custom engineered transmission found only on SnowEx products.

VERSATILITY:

Multi-use capabilities allows spreading of a variety of materials for snow and ice control.

WARRANTY:

Two years from date of installation.

The benets you are about to recognize are that of time, money and eort.

We welcome you to the world of Snowex Performance.

Registration

Record the following information in this manual for quick reference.

Spreader Model Number _____________________________________________________________________________________

Spreader Serial Number________________________________ Controller Serial Number _______________________________

Date of Purchase___________________________________________________________________________________________

Dealer Where Purchased _____________________________________________________________________________________

When ordering parts, the above information is necessary. This will help to insure

that you receive the correct parts.

At the right is a diagram of the ID tag. This tag on the spreader is located

on the frame.

Please ll out the warranty card with all the necessary information to validate it. This will also give us a record so that

any safety or service information can be communicated to you.

SER. NO.______________________

TRYNEX INTERNATIONAL

Warren, MI 48089 (800) 725-8377

Rev. 07

Safety

Before attempting any procedure in this book, these safety instructions must be read and understood by all workers who

have any part in the preparation or use of this equipment.

For your safety warning and information decals have been placed on this product to remind the operator of safety precautions.

If anything happens to mark or destroy the decals, please request new ones from Snowex.

Unit must be strapped down and locked into position before operating vehicle.

Never exceed the Gross Vehicle Weight Rating of vehicle. Failure to do so may limit a vehicles handling

characteristics.

Never attempt to take a unit o a truck with material in it.

Never exceed 45 m.p.h. when loaded spreader is attached to vehicle. Braking distances may be increased

and handling characteristics may be impaired at speeds above 45 m.p.h.

Never allow children to operate or climb on equipment.

Always check areas to be spread to be sure no hazardous conditions or substances are in the area.

Always inspect unit for defects: broken, worn or bent parts, weakened areas on spreader or mount.

Always shut o vehicle and power source before attempting to attach or detach or service spreader

unit. Be sure vehicle/power source is properly braked or chocked.

Always keep hands, feet, and clothing away from power-driven parts. Remember it is the owner’s

responsibility to communicate information on safe usage and proper maintenance of all equipment.

Always make sure personnel are clear of areas of danger when using equipment. Maintain 60'

distance from all bystanders when operating the spreader.

Inspect the unit periodically for defects. Parts that are broken, missing, or worn out must be replaced

immediately. The unit, or any part of it should be altered without prior written permission from the

manufacturer.

Never use 7500 with foreign debris in the spreader. These units are designed to handle clean,

free-owing material. Note: Can not spread water softner salt.

Rev. 07

L1184 © Trynex International 2008

4 — 6

Safety

(continued)

Always inspect pins and latches whenever attaching or detaching spreader, and before traveling.

Never leave material in hopper for long periods of time. Be aware that all ice melters are hygroscopic

and will attract atmospheric moisture and harden up.

Remember, most accidents are preventable and caused by human error. Exercising of care and

precautions must be observed to prevent the possibility of injury to operator or others!

Never operate equipment when under the inuence of alcohol, drugs, or medication that might alter your

judgment and/or reaction time.

Before working with the spreader, secure all loose tting clothing and unrestrained hair.

Always wear safety glasses with side shields when servicing spreader. Failure to do this could result in

serious injury to the eyes.

Rev. 07

Safety and Warning Labels

D 6546

D 6548

D 6335

D 6544

D 6545

D 6859

UNDER COVER

SERIAL NUMBER

ON REVERSE SIDE

Rev. 07

L184 © Trynex International 2008

4 — 8

7550

Component Assembly Views

Spinner Drive

Assembly

Auger Drive

Assembly

Electrical System

Assembly

Hopper

Assembly

Frame

Assembly

Rev. 07

7500

Side and Bottom Views

Rev. 07

L1184 © Trynex International 2008

4 — 10

7500 Auger Drive Assembly

Parts Breakdown

Rev. 07

Inhaltsverzeichnis

Andere SnowEx Streuer Handbücher

SnowEx

SnowEx SP-100-1 Bedienungsanleitung

SnowEx

SnowEx Bulk-Pro 1875 Bedienungsanleitung

SnowEx

SnowEx Sidewalk-Pro SD-95 Betriebsanleitung

SnowEx

SnowEx SP-7550 Betriebsanleitung

SnowEx

SnowEx Vee Pro 3000 Bedienungsanleitung

SnowEx

SnowEx V-Maxx G2 Bedienungsanleitung

SnowEx

SnowEx SP-85 Betriebsanleitung

SnowEx

SnowEx SP-225-1 Betriebsanleitung

SnowEx

SnowEx K1-131116 Betriebsanleitung

SnowEx

SnowEx VX-4200 Bedienungsanleitung

SnowEx

SnowEx SP-7000 Bedienungsanleitung

SnowEx

SnowEx VX-3210 Bedienungsanleitung

SnowEx

SnowEx SP-65 Betriebsanleitung

SnowEx

SnowEx SP-9500X Bedienungsanleitung

SnowEx

SnowEx V-Pro 32300 Bedienungsanleitung

SnowEx

SnowEx VX-1500 Bedienungsanleitung

SnowEx

SnowEx SP-325 Betriebsanleitung

SnowEx

SnowEx SR-210 Betriebsanleitung

SnowEx

SnowEx Precision Pro SP-1675 Bedienungsanleitung

SnowEx

SnowEx SP-1675 Bedienungsanleitung

SnowEx

SnowEx V-Pro 32300 Bedienungsanleitung

SnowEx

SnowEx Bulk Pro SP-1575 Betriebsanleitung

SnowEx

SnowEx SP-3000 Bedienungsanleitung

SnowEx

SnowEx HELIXX Bedienungsanleitung

Beliebte Streuer Handbücher anderer Marken

PEQUEA

PEQUEA GT-100 Bedienungsanleitung

Herculano

Herculano H2RS9 Bedienungsanleitung

Epoke

Epoke SKE8 Bedienungsanleitung

GEA

GEA EL44 Technisches Datenblatt

Boss Snowplow

Boss Snowplow TGS 800 Bedienungsanleitung

Fisher

Fisher EMERSON 168 Series Bedienungsanleitung

Fisher

Fisher POLY-CASTER 78601 Bedienungsanleitung

TurfEx

TurfEx RS7200 Betriebsanleitung

Fayat Group

Fayat Group DYNAPAC S100 Fehlerbehebungshandbuch

Art's-Way Manufacturing

Art's-Way Manufacturing X700 Installations- und Betriebshandbuch

Ferris

Ferris Pathfinder Series Bedienungsanleitung

EASTMAN

EASTMAN CR 500 Bedienungsanleitung

Nogueira

Nogueira RoyalFlow-600 Bedienungsanleitung

Buyers

Buyers TGS05B Bedienungsanleitung

Magnum

Magnum V-BOX PV Series Beilage

Meyer's

Meyer's VB280 Bedienungsanleitung

Kramer

Kramer VM-400HDCP Bedienungsanleitung

H&S

H&S 5134 Bedienungsanleitung