Sony XR-C5103R Bedienungsanleitung

MICROFILM

SERVICE MANUAL

FM/MW/LW CASSETTE CAR STEREO

AEP Model

UK Model

XR-C5100R

East European Model

XR-C5103R

Model Name Using Similar Mechanism NEW

Tape Transport Mechanism Type MG-25G-136

Cassette player section

Tape track 4-track 2-channel stereo

Wow and flutter 0.08 % (WRMS)

Frequency response 30 – 18,000 Hz

Signal-to-noise ratio TYPE II, IV 61 dB

TYPE I 58 dB

Tuner section

Tuning range 87.5 – 108.0 MHz

(XR-C5100R)

FM1, FM2: 87.5 – 108.0 MHz

FM3: 65.0 – 74.0 MHz

(XR-C5103R)

Antenna terminal External antenna connector

Intermediate frequency 10.7 MHz

Usable sensitivity 8 dBf

Selectivity 75 dB at 400 kHz

Signal-to-noise ratio 65 dB (stereo), 68 dB (mono)

(XR-C5100R)

63 dB (stereo), 65 dB (mono)

(XR-C5103R)

Harmonic distortion at 1 kHz 0.5 % (stereo), 0.3 % (mono)

Separation 35 dB at 1 kHz

Frequency response 30 – 15,000 Hz

Capture ratio 2 dB

MW/LW

Tuning range MW: 531 – 1,602 kHz

LW: 153 – 281 kHz

Antenna terminal External antenna connector

Intermediate frequency 10.71 MHz/450 kHz

Sensitivity MW: 30 µV

LW: 50 µV

Power amplifier section

Outputs Speaker outputs

(sure seal connectors)

Speaker impedance 4 – 8 ohms

Maximum power output 40 W ×4 (at 4 ohms)

General

Outputs Telephone ATT control lead

Power amplifier control lead

Rear line out (1)

Tone controls Bass ±8 dB at 100 Hz

Treble ±8 dB at 10 kHz

Power requirements 12 V DC car battery (negative ground)

Dimensions Approx. 188 ×53 ×181 mm (w/h/d)

Mounting dimensions Approx. 182 ×53 ×164 mm (w/h/d)

Mass Approx. 1.2 kg

Supplied accessories Parts for installation and connections

(1 set)

Rotary commander RM-X4S

Front panel case (1)

Design and specifications are subject to change without notice.

SPECIFICATIONS

XR-C5100R/C5103R

Photo: XR-C5103R

– 2 –

TABLE OF CONTENTS

1. GENERAL

Location of Controls ....................................................... 3

Setting the Clock ............................................................. 3

Using the Rotary Commander ........................................ 4

Adjusting the Sound Characteristics .............................. 4

Attenuating the Sound .................................................... 4

Changing the Sound and Beep Tone............................... 4

Installation....................................................................... 5

Connections ..................................................................... 6

2. DISASSEMBLY ......................................................... 9

3. ASSEMBLY OF MECHANISM DECK........... 11

4. MECHANICAL ADJUSTMENTS....................... 14

5. ELECTRICAL ADJUSTMENTS

Test Mode ........................................................................ 14

Tape Deck Section .......................................................... 14

Tuner Section .................................................................. 15

6. DIAGRAMS

6-1. Printed Wiring Boards – MAIN Section – .................... 18

6-2. Schematic Diagram – MAIN Section –.......................... 21

6-3. Printed Wiring Board – PANEL Section – .................... 26

6-4. Schematic Diagram – PANEL Section – ....................... 29

6-5. IC Pin Function Description ........................................... 31

7. EXPLODED VIEWS................................................ 37

8. ELECTRICAL PARTS LIST ............................... 40

Flexible Circuit Board Repairing

• Keep the temperature of the soldering iron around 270 ˚C dur-

ing repairing.

• Do not touch the soldering iron on the same conductor of the

circuit board (within 3 times).

• Be careful not to apply force on the conductor when soldering

or unsoldering.

Notes on chip component replacement

• Never reuse a disconnected chip component.

• Notice that the minus side of a tantalum capacitor may be dam-

aged by heat.

– 3 –

SECTION 1

GENERAL This section is extracted from

instruction manual.

– 4 –

– 5 –

– 6 –

– 7 –

– 8 –

– 9 –

FRONT PANEL ASS’Y

COVER ASS’Y

Note: Follow the disassembly procedure in the numerical order given.

SECTION 2

DISASSEMBLY

Push the button

(release).

Remove the front panel ass’y

to the direction of the arrow

cover ass’y

– 10 –

SUB PANEL, MECHANISM DECK (MG-25G-136)

MAIN BOARD, HEAT SINK

three screws

(PTT2.6

three screws

(PTT2.6

sub panel

connector

(CN352)

screw

(PTT2.6

mechanism deck

(MG-25G-136)

flexible flat cabl

(CN351)

three screws

(PTT2.6

10)

two screws

(PTT2.6

14)

three screws

(PTT2.6

10)

screw

(PTT2.6

heat sink

main board

two ground point

screws

rubber cap (25)

two screws

(PTT2.6

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Sony Autoempfänger Handbücher

Sony

Sony MEX-N4200BT Bedienungsanleitung

Sony

Sony CDX-M7810 - Fm/am Compact Disc Player Bedienungsanleitung

Sony

Sony MEX-R1 Produkthandbuch

Sony

Sony XR-CA330 Installation/Connection Bedienungsanleitung

Sony

Sony CDX-GT180 Bedienungsanleitung

Sony

Sony XR-CA665EE Bedienungsanleitung

Sony

Sony ST-SA50ES - Am/fm Tuner Benutzerhandbuch

Sony

Sony CDX-CA710X Addendum to Bedienungsanleitung

Sony

Sony XAV-601BT Bedienungsanleitung

Sony

Sony XR-C457 Bedienungsanleitung

Sony

Sony CDX-M730 Bedienungsanleitung

Sony

Sony CDX-C610 Bedienungsanleitung

Sony

Sony CDX-3100 Bedienungsanleitung

Sony

Sony GT630UI - CDX Radio / CD Bedienungsanleitung

Sony

Sony ST-SDB900 Bedienungsanleitung

Sony

Sony CDX-GT300MP Bedienungsanleitung

Sony

Sony CDX-R3300 - Fm/am Compact Disc Player Bedienungsanleitung

Sony

Sony Xplod CDX-GT430IP Bedienungsanleitung

Sony

Sony CDX-MP450X Primary User Manual (English Bedienungsanleitung

Sony

Sony HCD-DZ300 Bedienungsanleitung

Sony

Sony CDX-F5505X - Fm/am Compact Disc Player Bedienungsanleitung

Sony

Sony BluetoothH MEX-BT5100 Bedienungsanleitung

Sony

Sony XR-C5120R Bedienungsanleitung

Sony

Sony CDX-S2050EE Bedienungsanleitung

Beliebte Autoempfänger Handbücher anderer Marken

Motorola

Motorola VWA63 Bedienungsanleitung

Nextar

Nextar D3201 Bedienungsanleitung

Alpine

Alpine CDE-163BT Bedienungsanleitung

Pioneer

Pioneer DEH-P645R Bedienungsanleitung

Axxera

Axxera XDMA7600 Betriebsanleitung

XM OnyX Bedienungsanleitung

Sound Storm

Sound Storm STM93R Bedienungsanleitung

Soundstream

Soundstream VIR-5000 Bedienungsanleitung

Avson

Avson MKT Platform Bedienungsanleitung

Pioneer

Pioneer DVH-P500UB Bedienungsanleitung

JVC

JVC KD-AHD69 Bedienungsanleitung

Blaupunkt

Blaupunkt SANTIAGO CR 87 Bedienungsanleitung

XFIRE AUDIO

XFIRE AUDIO BMW42S Bedienungsanleitung

VDO

VDO CD 2253 Bedienungsanleitung

Volvo

Volvo 13 84 580 Bedienungsanleitung

ZENEC

ZENEC ZE-160DVD Bedienungsanleitung

Medion

Medion Car Audio Bedienungsanleitung

Philips

Philips CEM5000 Bedienungsanleitung