Sony ECM-T115 Bedienungsanleitung
ECM-T115/T145
US Model
Canadian Model
AEP Model
E Model
SERVICE MANUAL
ELECTRET CONDENSER MICROPHONE
MICROFILM
SPECIFICATIONS
PHOTO : ECM-T115 PHOTO : ECM-T145
Ver 1.0 1999. 02
— 2 —
Notes on Chip Component Replacement
• Never reuse a disconnected chip component.
• Notice that the minus side of a tantalum capacitor may be
damaged by heat
SERVICE NOTE
— 3 —
SECTION 1
GENERAL This section is extracted
from instruction manual.
— 4 —
SECTION 2
DIAGRAMS
2-1. SCHEMATIC DIAGRAM
TOTAL CURRENT : 0.21mA
LITHIUM BATTERY
Note on Schematic Diagram:
• All capacitors are in µF unless otherwise noted. pF: µµF
50 WV or less are not indicated except for electrolytics
and tantalums.
• All resistors are in Ωand 1/4W or less unless otherwise
specified.
• % : indicates tolerance.
•C: panel designation.
• Signal path.
F: MIC
ECM-T115/T145
— 5 —
2-2. PRINTED WIRING BOARD
12
A
B
C
D
E
F
G
H
34567
AMP BOARD
(SIDE B)
UNIT BOARD
(SIDE B)
UNIT BOARD
(SIDE A)
AMP BOARD
(SIDE A)
1-671-999-
11
(11)
1-671-999- 11
(11)
1-672-000-
11
(11)
1-672-000-
11
(11)
J1
MIC IN
S1
POWER
D10
D10
D3
R13
JC1
D1
C14
C1 C2
R1
D2
C10
R3
ON
OFF
S1
(MIC OUT) MINI
PLUG
(MIC OUT)
MIC1
MINI
PLUG
MIC
OUT MINI
PLUG
MIC1
LITHUM
BATTERY
CR-2025
3V
T145 MODEL
T115 MODEL
BATTERY
CHECK
LAMP
16
Note on Printed Wiring Board:
•X: parts extracted from the component side.
•®:Through hole.
•b: Pattern from the side which enables seeing.
Caution:
Pattern face side: Partsonthepattern faceside seen from
(SIDE B) the pattern face are indicated.
Parts face side: Parts on the parts face side seen from
(SIDE A) the parts face are indicated.
Ref. No. Location
D1 F-2
D2 F-2
D3 D-2
D10 B-4, A-6
• Semiconductor
Location
ECM-T115/T145
— 6 —
SECTION 3
EXPLODEDVIEWS
3-1. BATTERY BOX SECTION
NOTE:
• -XX, -X mean standardized parts, so they may have some differences
from the original one.
• Items marked “*” are not stocked since they are seldom required for
routine service. Some delay should be anticipated when ordering these
items.
• The mechanical parts with no reference number in the exploded views
are not supplied.
1
2
6
7
8
9
10
11
12
3
4
5
#1
Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
1 1-790-104-11 CORD, MICROPHONE (1 CORE)
2 2-545-592-01 BUSHING
3 2-545-593-01 SHEET, SHIELD
4 X-2542-165-1 CASE (UPPER) ASSY, BATTERY
5 2-545-588-01 KNOB, SWITCH
*6 A-4542-561-A AMP BOARD, COMPLETE
7 2-545-589-01 TERMINAL, PLUS
8 2-545-590-01 TERMINAL, MINUS
9 2-545-599-01 SHEET, BLIND
10 2-545-586-01 CASE (LOWER), BATTERY
11 2-545-587-01 HOLDER, BATTERY
12 2-545-601-01 LABEL, MODEL NUMBER (T115)
12 2-545-606-01 LABEL, MODEL NUMBER (T145)
#1 7-685-103-19 SCREW +P 2 ×5 TYPE2 NON-SLIT
— 7 —
3-2. MIC SECTION (T115 MODEL)
51
54
55
53
56
57
59
52
58
MIC1
not supplied
not supplied
Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
51 1-790-102-11 CORD, MICROPHONE (1 CORE)
52 X-2542-079-1 CLIP ASSY
53 3-704-197-72 SCREW (M1.4X4.5), LOCKING
54 2-545-584-01 BASE, MICROPHONE
*55 4-916-272-01 SPACER
56 2-543-437-01 REGISTER
57 3-309-597-31 SCREW (1.4), TAPPING,PRECISION
58 2-545-583-01 COVER, MICROPHONE
*59 1-671-999-11 UNIT BOARD
MIC1 8-814-294-00 MICROPHONE CAPSULE C-1053
— 8 —
3-3. MIC SECTION (T145 MODEL)
101
102
103
105
106
107 108
109
110
111
112
104
MIC1
D10
not supplied
Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
101 A-4540-185-A CLIP ASSY, HOLDER
102 X-2542-079-1 CLIP ASSY
103 3-704-197-12 SCREW (M1.4X2.0), LOCKING
104 3-309-597-51 SCREW (1.4), TAPPING,PRECISION
105 X-2542-166-1 SCREEN ASSY, WINDOW
106 2-545-564-01 CASE, MICROPHONE
107 2-545-595-01 NET, INNER
108 2-545-596-01 SPACER
109 2-536-803-01 STOPPER
110 2-545-592-01 BUSHING
111 2-545-591-01 CASE, BUSHING
112 1-790-103-11 CORD, MICROPHONE (1 CORE)
D10 8-719-056-29 DIODE 015AZ4.7-TPL3
MIC1 8-814-294-00 MICROPHONE CAPSULE C-1053
— 9 —
SECTION 4
ELECTRICAL PARTS LIST
NOTE:
• Due to standardization, replacements in the
parts list may be different from the parts
specifiedin thediagrams orthe components
used on the set.
• -XX, -X mean standardized parts, so they
may have some difference from the original
one.
• Items marked “*” are not stocked since they
are seldom required for routine service.
Some delay should be anticipated when
ordering these items.
• CAPACITORS:
uF: µF
• RESISTORS
All resistors are in ohms.
METAL: metal-film resistor
METAL OXIDE: Metal Oxide-film resistor
F: nonflammable
• COILS
uH: µH
• SEMICONDUCTORS
In each case, u: µ, for example:
uA...: µA... , uPA... , µPA... ,
uPB... , µPB... , uPC... , µPC... ,
uPD..., µPD...
When indicating parts by reference number,
please include the board name.
Ref. No. Part No. Description Remarks Ref. No. Part No. Description Remarks
*A-4542-561-A AMP BOARD, COMPLETE
********************
< CAPACITOR >
C1 1-119-749-11 TANTAL. CHIP 33uF 20% 4V
C2 1-104-908-11 TANTAL. CHIP 47uF 20% 4V
C14 1-164-222-11 CERAMIC CHIP 0.22uF 25V
< DIODE >
D1 8-719-072-95 DIODE 015AZ3.9-X-TPL3
D2 8-719-064-07 LED SML-310LTT86
(BATTERY CHECK LAMP)
D3 8-719-056-29 DIODE 015AZ4.7-TPL3
< JACK >
J1 1-764-624-51 JACK(MIC IN)
< RESISTOR >
JC1 1-216-864-11 METAL CHIP 0 5% 1/16W
< RESISTOR >
R1 1-216-833-11 METAL CHIP 10K 5% 1/16W
R3 1-216-813-11 METAL CHIP 220 5% 1/16W
R13 1-216-828-11 METAL CHIP 3.9K 5% 1/16W
< SWITCH >
S1 1-692-397-21 SWITCH, SLIDE (POWER)
************************************************************
*1-671-999-11 UNIT BOARD (T115)
**********
< CAPACITOR >
C10 1-163-009-11 CERAMIC CHIP 0.001uF 10% 50V (T115)
< DIODE >
D10 8-719-056-29 DIODE 015AZ4.7-TPL3 (T115)
************************************************************
MISCELLANEOUS
***************
1 1-790-104-11 CORD, MICROPHONE (1 CORE)
51 1-790-102-11 CORD, MICROPHONE (1 CORE) (T115)
112 1-790-103-11 CORD, MICROPHONE (1 CORE) (T145)
D10 8-719-056-29 DIODE 015AZ4.7-TPL3 (T145)
MIC1 8-814-294-00 MICROPHONE CAPSULE C-1053
************************************************************
ACCESSORIES & PACKING MATERIALS
********************************
3-865-088-11 MANUAL, INSTRUCTION
(ENGLISH, FRENCH, GERMAN, SPANISH, DUTCH,
SWEDISH, ITALIAN, PORTUGAL)
AMP UNIT
ECM-T115/T145
— 10 —
Sony Corporation
Personal A&V Products Company
99B1677-1
Printed in Japan ©1999.2
Published by Quality Engineering Dept.
(Shinagawa)
9-924-973-11
Andere Handbücher für ECM-T115
3
Dieses Handbuch passt für folgende Modelle
1
Inhaltsverzeichnis
Andere Sony Mikrofon Handbücher
Sony
Sony ECM-T110 Bedienungsanleitung
Sony
Sony ECM-R300 Bedienungsanleitung
Sony
Sony ECM CZ10 Bedienungsanleitung
Sony
Sony ECM-350BC Bedienungsanleitung
Sony
Sony ECM-673 Bedienungsanleitung
Sony
Sony ECM-55B Bedienungsanleitung
Sony
Sony ECMMS907 - Stereo Type Mic Bedienungsanleitung
Sony
Sony F115B Bedienungsanleitung
Sony
Sony DWM-01 Bedienungsanleitung
Sony
Sony ECM-T115 Bedienungsanleitung
Sony
Sony WRT-807B Bedienungsanleitung
Sony
Sony ECM-SST1 Bedienungsanleitung
Sony
Sony ECM-SST1 Bedienungsanleitung
Sony
Sony ECM-PC60 Bedienungsanleitung
Sony
Sony ECM-C115 Bedienungsanleitung
Sony
Sony F-112 Bedienungsanleitung
Sony
Sony ECM-T115 Bedienungsanleitung
Sony
Sony PCM-M10 Bedienungsanleitung
Sony
Sony C800GPAC Bedienungsanleitung
Sony
Sony ECM S80 Bedienungsanleitung
Beliebte Mikrofon Handbücher anderer Marken
IK Multimedia
IK Multimedia iRig Stream MIC PRO Bedienungsanleitung
DAPAudio
DAPAudio RM-101 Bedienungsanleitung
AKG
AKG CHM 21 Bedienungsanleitung
Sennheiser
Sennheiser evolution wireless series EM 100 Bedienungsanleitung
GIGAMEDIA
GIGAMEDIA GGM PAMICUHFG Bedienungsanleitung
Shure
Shure WH30TQG Bedienungsanleitung
