Sunred GH12 Series Bedienungsanleitung

Sunred Gas Heater

GH12 Series

EN PATIO HEATER

NL TERRASVERWARMER

DE TERRASSENHEIZSTRAHLER

FR RADIATEUR DE TERRASSE

0063/19

2 years warranty

MADE IN P.R.C.

EN Gas Pao Heater

User instrucons - please keep for future references

IMPORTANT

Carefully remove the

packaging before use, but

keep the safety instruments.

These are part of the pro-

duct. Please note all safety

warnings menoned in this

manual.

Read the instrucons in their

enrety and keep them for

future reference.

These must be stored with

the product. This product is

for household use and may

not be used for commercial

or contractual purposes.

WARNING

Use in closed spaces can be

dangerous and is FORBIDDEN

WARNING

Please read the manual

before usage

FOR YOUR SAFETY

If you smell gas:

1. Shut o gas to the appliance.

2. Exnguish any open ame.

3. If odor connues, immediately call your gas supplier or your re department.

WARNING SAFETY RULES

PLEASE READ THE FOLLOWING SAFETY RULES PRIOR TO OPERATION OF THE HEATER

FOR YOUR SAFETY

1. Do not store or use gasoline or other ammable vapors and liquids in the vicinity of this or any other appliance.

2. An LP cylinder not connected for use shall not be stored in the vicinity of this or any other appliance.

WARNING

1) For use outdoors or in amply venlated areas.

2) An amply venlated area must have a minimum of 25 % of the surface area open.

3) The surface area is the sum of the walls surface. (See gure 2)

WARNING

Improper installaon, adjustment, alteraon, service or maintenance can cause injury or

property damage. Read the installaon, operang and maintenance instrucons thoroughly before installing or servicing this equip-

ment.

WARNING

This appliance must be installed and the gas cylinder stored in accordance with the regulaons in force;

• Do not obstruct the venlaon holes of the cylinder housing;

• Do not move the appliance when in operaon;

• Shut o the valve at the gas cylinder or the regulator before moving the appliance;

• The tubing or the exible hose must be changed within the prescribed intervals;

• Use only the type of gas and the type of cylinder specied by the manufacturer;

The LP tank used with your pao heater must meet the following requirements:

Purchase LP tanks only with these required measurements: (30.5cm) (diameter) x 57.1 cm) (tall) with 23kg capacity maximum.

• In case of violent wind parcular aenon must be taken against lng of the appliance;

Fig. 2

Table of contents

Cauon 2

Heater Stand and Locaon 5

Gas Requirements 6

Operaon and Storage 7

Cleaning and Care 7

Parts and Specicaons 9

Assembly Parts and Procedures 10

Leakage Test 17

Problems Check Test 18

Do not use the pao heater for indoors, as it may cause personal injury or property damage.

This outdoor heater is not intended to be installed on recreaonal vehicles and/or boats. Installaon and repair should

be done by a qualied service person.

Improper installaon, adjustment, alteraon can cause personal injury or property damage. Do not aempt to alter the unit in

any manner.

Never replace or substute the regulator with any regulator other than the factory-suggested replacement.

Do not store or use gasoline or other ammable vapors or liquids in the heater unit.

The whole gas system, hose, regulator, pilot or burner should be inspected for leaks or damage before use, and at least annually

by a qualied service person.

All leak tests should be done with a soap soluon. Never use an open ame to check for leaks. Do not use the heater unl all

connecons have been leak tested.

Turn o the gas valve immediately if smell of gas is detected. Turn Cylinder Valve OFF. If leak is at Hose/Regulator connecon:

ghten connecon and perform another leak test. If bubbles connue appearing should be returned to hose’s place of purchase.

If leak is at Regulator/Cylinder Valve connecon: disconnect, reconnect, and perform another leak check. If you connue to see

bubbles aer several aempts, cylinder valve is defecve and should be returned to cylinder’s place of purchase.

Do not transport heater while it’s operang.

Do not move the heater aer it has been turned o unl the temperature has cooled down. Keep the venlaon opening of the

cylinder enclosure free and clear of debris.

Do not paint the radiant screen, control panel or top canopy reector.

Control compartment, burner and circulaon air passageways of the heater must be kept clean. Frequent cleaning may be requi-

red as necessary.

The LP tank should be turned o when the heater is not in use. Check the heater immediately if any of the following occurs:

- The heater does not reach temperature.

- The burner makes popping noise during use (a slight noise is normal when the burner is exnguished).

- Smell of gas in conjuncon with extreme yellow pping of the burner ames.

CAUTION

PLEASE READ CAREFULLY THE FOLLOWING SAFETY GUIDELINES BEFORE OPERATION

WARNING

The user assumes all risks of assembling and operang gas heater. Not heeding the warnings and instrucons of this manual can result in

sever bodily harm, death or material damage. If you don’t read this user manual or if you cannot fully understand it, please ask your spe-

cialized dealer. The manufacturer or supplier assumes no liability for negligent user behavior.

WARNING

When not heeding the instrucons and informaon in this manual or in case of improper usage outside of the intended usage purposes,

• The LP regulator/hose assembly must be located out of pathways where people may trip over it or in area where the hose

will not be subject to accidental damage.

• Any guard or other protecve device removed for servicing the heater must

be replaced before operang

• the heater. Adults and children should stay away from high temperature

surface to avoid burns or clothing ignion.

• Children should be carefully supervised when they are in the area of the

heater.

• Clothing or other ammable materials should not be hung on the heater or

placed on or near the heater.

• To change the gas cylinder in a amply venlated area, away from any ignion

• source (candle, cigarees, other ame producing appliances, ...);

• To check that the regulator seal is correctly ed and able to fulll its

funcon showed as photo right;

• To not obstruct the venlaon holes of the cylinder housing;

• To close the gas supply at the valve of the gas cylinder or the regulator aer

use;

• In the event of gas leakage, the appliance shall not be used or if alight, the

gas supply shall be shut o and the appliance shall be invesgated and

reced before it is used again;

• To check the hose at least once per month, each me the cylinder is

changed, or each me before long me no use.

• If it shows signs of cracking, spling or other deterioraon it shall be

exchanged for new hose of the same length and of the equivalent quality;

• The use of this appliance in enclosed areas can be dangerous and is

PROHIBITED;

• Read the instrucons before using this appliance. The appliance must be

installed in accordance with the instrucons and local regulaons.

• For connecon of hose and regulator,and connecon of regulator and hose,

please refer to photo showed above.

HEATER STAND AND LOCATION

The heater is primarily for outdoor use only. Always ensure that adequate fresh air

venlaon is provided.

Always maintain proper clearance to non protected combusble materials i.e. top

100 cm and sides 100 cm minimum.

Heater must be placed on level rm ground.

Never operate heater in an explosive atmosphere like in areas where gasoline or

other ammable liquids or vapors are stored.

To protect heater from strong wind, anchor the base securely to the ground with

screws.

CAUTION

PLEASE READ CAREFULLY THE FOLLOWING SAFETY GUIDELINES BEFORE OPERATION

Minimum distance must be 100 cm

Seal

Hose

Regulator

Cylinder

GAS REQUIREMENTS

• Use propane, butane or their mixtures gas only.

• The pressure regulator and hose assembly to be used must conform to local standard codes.

• The installaon must conform to local codes, or in the absence of local codes, with the standard for the storage and han-

dling of liquid petroleum gases.

• A dented, rusted or damaged tank may be hazardous and should be checked by your tank supplier. Never use a tank with a

damaged valve connecon.

• The tank must be arranged to provide for vapor withdrawal from the operang cylinder.

• Never connect an unregulated tank to the heater.

LEAKAGE TEST

• Gas connecons on the heater are leak tested at the factory prior to shipment. A complete gas ghtness check must be

performed at the installaon site due to possible mishandling in shipment or excessive pressure being applied to the heat-

er.

• Make a soap soluon of one part liquid detergent and one part water. The soap soluon can be applied with a spray bole,

brush or rag. Soap bubbles will appear in case of a leak.

• The heater must be checked with a full cylinder.

• Make sure the safety control valve is in the OFF posion.

• Turn the gas supply ON.

• In case of a leak, turn o the gas supply. Tighten any leaking ngs, then turn the gas supply on and re- check.

• Never leak test while smoking.

CAUTION

PLEASE READ CAREFULLY THE FOLLOWING SAFETY GUIDELINES BEFORE OPERATION

WARNING

Do not aempt any changes to the device in any way to apply. Incorrect installaon, improper use,

TO TURN ON THE HEATER

1. Depress and turn control knob clockwise to OFF posion.

2. Fully open gas valve.

3. Depress control knob and turn knob counter-clockwise to IGNITE posion, then to PILOT posion (you will hear 2 clicks).

4. With the pilot light lit, keep control knob depressed for 30 seconds.

5. Aer depressing the control knob for 30 seconds, turn control knob to LOW. To increase the temperature, turn towards HIGH.

TO TURN OFF THE HEATER

1. Fully close gas valve.

2. Turn control knob clockwise to OFF posion.

STORAGE

1. Always close the gas value of the gas cylinder aer use or in

case of a disturbance.

2. Remove the pressure regulator and the hose.

3. Check the ghtness of the gas valve and if you suspect a damage,

have it changed by your gas dealer.

4. Never store liquid gas cylinder in a sub-terrain, or at places

without adequate air venlaon.

CLEANING AND CARE

• Wipe o powder coated surfaces with so, moist rag. Do not clean heat-

er with cleaners that are combusble or corrosive.

• Remove debris from the burner to keep it clean and safe for use.

• Cover the burner unit with the oponal protecve cover when the heat-

er is not in use.

CAUTION

PLEASE READ CAREFULLY THE FOLLOWING SAFETY GUIDELINES BEFORE OPERATION

NOTE

If the pilot light has not ignited, turn heater control knob to OFF posion, fully close gas valve, wait 5 minutes, then repeat steps 2–4 of

the Lighng Instrucons.

NOTE

If the pilot light ignites but does not stay lit, turn heater control knob to OFF posion, fully close propane gas valve, wait 5 minutes, then

repeat steps 2–3. Now, using a lighter, ignite the pilot light through the ignion hole on the emier screen. Once the pilot light is lit, de-

press control knob for 30 seconds.

WARNING

Check that no broken on the glass is found before operaon.

O: The heater stop working

Hi: Maximum temperature posion

Lo: Minimum temperature posion

Variable control knob

Igniter

Control panel may dier slightly

CAUTION

PLEASE READ CAREFULLY THE FOLLOWING SAFETY GUIDELINES BEFORE OPERATION

DURING PERIODS OF EXTENDED INACTIVITY OR WHEN TRANSPORTING:

• Turn the control to “OFF” posion.

• Disconnect LPG cylinder and move to a secure, well-venlated locaon outdoors. DO NOT store in a

• locaon that will exceed 50 degrees C.

• Store heater upright in an area sheltered away from weather condions (such as rain, sleet, hail, snow)

• If desired, cover heater to protect exterior surfaces and to help prevent dust and debris collecng in air passages.

WARNING—FOR YOUR SAFETY

• DO NOT touch or move heater for at least 45 minutes aer use.

• Allow all burner elements to cool before touching.

NOTE

In a salt-air environment (such as near an Ocean) corrosion occurs more quickly than normal.

• Frequently check for corroded areas and repair them promptly.

• Wait unl heater is cooled down before covering.

A. Construcon and characteriscs

• Transportable terrace/garden heater with tank housing.

• Casing in steel with powder-coang or in stainless steel.

• Gas hose connecons with metal clamp (screw caps for Germany). Heat emission from reector.

B. Specicaons

• Use propane, butane or their mixtures gas only.

• Max. waage: 14000 was

• Min. waage: 5000 was

• Consumpon:

C. Table of injector

• The hose and regulator assembly must conform to local standard codes.

• Regulator outlet pressure should meet the corresponding appliance category in B. Specicaon.

• The appliance requires approved hose in 1.4m length.

A regulator (compliees with EN16129:2013 and the naonal regulaon) of the correct pressure corresponding to the appliance category.

Use 30mbar regulator for butane/propane under the category I3B/P(30). Use 30mbar regulator for butane under the category I3+(28-30/37).

Use 37mbar regulator for propane under the category I3+(28-30/37).

Use 50mbar regulator for butane/propane under the category I3B/P(50).

It’s recommended to use exible hose that approved by EN16436: 2014.

PARTS AND SPECIFICATIONS

APPLIANCE CATEGORY: I3+(28-30/37) I3B/P(30) I3B/P(50)

TYPES OF GAS: Butane Propane Butane, propane or

their mixtures

Butane, propane or

their mixtures

GAS PRESSURE 28-30 mbar 37 mbar 30 mbar 50 mbar

OUTLET PRESSURE

OF REGULATOR: 30 mbar 30 mbar 30 mbar 50 mbar

Using the proper regulator according to outlet pressure of regulator as showed in the table above.

APPLIANCE CATEGORY: I3+(28-30/37) I3B/P(30) I3B/P(50)

TYPES OF GAS: Butane Propane Butane, propane or

their mixtures

Butane, propane or

their mixtures

GAS PRESSURE 28-30 mbar 37 mbar 30 mbar 50 mbar

TOTAL HEAT

INPUT

(Hs): (Qn)

14 kW (1000 g/h)

INJECTOR SIZE

1.90 mm for main burner

0.18 mm for pilot burner

1.70 mm for main burner

0.18 mm for pilot burner

The marking, for example, 1.90 on the injector, indicates that the size of injector is 1.90 mm

Andere Handbücher für GH12 Series

Inhaltsverzeichnis

Sprachen:

Andere Sunred Terrassenheizung Handbücher

Sunred

Sunred BAR-1500H Bedienungsanleitung

Sunred

Sunred SLH12 Bedienungsanleitung

Sunred

Sunred RD-SILVER-3000W Bedienungsanleitung

Sunred

Sunred RD-DARK-15-20-25 Bedienungsanleitung

Sunred

Sunred IND-3000H Bedienungsanleitung

Sunred

Sunred GS09 Bedienungsanleitung

Sunred

Sunred Indus Bedienungsanleitung

Sunred

Sunred CELC Bedienungsanleitung

Sunred

Sunred LH15G Bedienungsanleitung

Sunred

Sunred Bright RSS16 Bedienungsanleitung

Sunred

Sunred IND-2500H Bedienungsanleitung

Sunred

Sunred CE09B/K Bedienungsanleitung

Sunred

Sunred RD-SILVER-2000W Bedienungsanleitung

Sunred

Sunred TSL15 Bedienungsanleitung

Sunred

Sunred HS15 Bedienungsanleitung

Sunred

Sunred Retro Sphere 2100 Bedienungsanleitung

Sunred

Sunred GS15B Bedienungsanleitung

Sunred

Sunred RD-SILVER-2000S Bedienungsanleitung

Sunred

Sunred RSH16L Bedienungsanleitung

Sunred

Sunred CE09B Bedienungsanleitung

Sunred

Sunred RSS19 Bedienungsanleitung

Sunred

Sunred GS11 Bedienungsanleitung

Sunred

Sunred GS17K Bedienungsanleitung

Sunred

Sunred Sound-2000W Bedienungsanleitung

Beliebte Terrassenheizung Handbücher anderer Marken

empasa

empasa HMXD-E-NHS Bedienungsanleitung

HEAT1

HEAT1 ECO pro-line 2300W Bedienungsanleitung

Heatmaxx

Heatmaxx SRPH98 Bedienungsanleitung

Sunjoy

Sunjoy A30600640 Bedienungsanleitung

Event Furniture

Event Furniture 16091 Fehlerbehebungshandbuch

Prem-I-Air

Prem-I-Air EH1462 Bedienungsanleitung

Blumfeldt

Blumfeldt 10028637 Bedienungsanleitung

Sunjoy

Sunjoy L-PH011PSS-2 Bedienungsanleitung

Melissa

Melissa 670-202 Bedienungsanleitung

Quality Heating

Quality Heating THE-12DW Bedienungsanleitung

DCS

DCS PHFS-P4 Installationsanleitung

EUROM

EUROM 334241 Bedienungsanleitung

Lava Heat

Lava Heat Venetian Bedienungsanleitung

EHS Ltd.

EHS Ltd. HQH-2000W Bedienungsanleitung

VONROC

VONROC ALICUDI PH515AC Bedienungsanleitung

OZONA

OZONA Heatflow IF010997 Bedienungs- und Wartungshandbuch

theBBQshop

theBBQshop 51611010 Einrichtungshandbuch

Endless Summer

Endless Summer EWTS9151M Bedienungsanleitung