Swegon EXP Free b Bedienungsanleitung

kpq



( )2

EXP Free x

Tomelilla

Sweden

XXX

k = XX

Installation

The air diffuser is normally suspended from the ceiling.

An M8 pop nut, i.e. a threaded grommet that facilitates

installation, is provided at the top and in the centre of the

air diffuser. On sizes 315 and 400, there are two M8 pop

nuts for more stable mounting, see ﬁgure 1 and 3.

Alternative installation in pre-punched Ø10 mm hole, see

ﬁgure 3b.

Commissioning

Commissioning should be carried out with the wall dif-

fuser face mounted. Pull the measuring tubes and damper

adjustment cords out of the air diffuser through the hole

in the front. Then connect the manometer to the cor-

rect measuring tube(s); A transparent measuring tube for

extract air. The rated coefﬁcient of performance of the

air diffuser can be used in a calculation to determine the

required commissioning pressure. Conclude commissio-

ning by adjusting the damper to the correct blade posi-

tion, tie a commissioning knot in the damper cords to

indicate the damper position. See Figure 1.

The K-factor is speciﬁed on the product’s identiﬁcation

label and last in these instructions.

Maintenance

• Clean the air diffuser if needed with lukewarm water

and dishwashing detergent added.

• The duct system can be accessed by lightly pulling

the spring-loaded diffuser face downwards and then

tilting, see ﬁgure 4.

• Dismantle the perforated air distribution plate located

on the inlet as shown in ﬁgure 5.

• Loosen the damper in the inlet from its bayonet fastening

by rotating to the side.

Figure 1. Installation. Commissioning. Maintenance.

q= measured ﬂow l/s

p= current pressure reading (Pa)

k= commissioning factor

k-factor

0xD / ±5% 0xD / ±5% 2xD / ±10%

Figure 2. Length of straight section of duct

EXP Free b

Installation – Commissioning – Maintenance 20220217

Figure 5. Dismantling the distribution plate.

Figure 3a. Extra M8 pop nut, size 315 and 400.

Figure 4. Spring-loaded front.

Applies only for

size 315 & 400.

We recommend wearing gloves as there is

a risk of cut injuries to the hands/ﬁngers.

Figure 3b. Alternative installation in pre-punched Ø10 mm hole.

M8 threaded rod

for oscillation

Installed directly on the

ceiling

EXP Free

2Swegon reserves the right to alter specications. 20220217

Figure 6. Damper installation and dismantling.

The number holes in the damper

must correspond with the number

of holes in the sleeve plate

The damper is turned anticlockwise and

pulled out.

The number holes in the damper

must correspond with the number

of holes in the sleeve plate

We recommend wearing gloves as there is

a risk of cut injuries to the hands/ﬁngers.

20220217 Swegon reserves the right to alter specications.

EXP Free

Figure 7. EXP Free.

K-factor (COP)

EXP F extract air

Size EXP F extract air Colour of the tube

100 5,3 Transparent

125 8,6 Transparent

160 14,5 Transparent

200 24,1 Transparent

250 36,3 Transparent

315 57,5 Transparent

400 82,4 Transparent

Number of measuring tubes: 1

NOTE! The blue tubes can be used if the product is converted

for supply air with the distributor being replaced with nozzles

for COLIBRI Fb and EAGLE Fg.

Dimensions and weight

Size A B C D E Weight, kg

100 304 192 118 99 96 2,8

125 380 217 210 124 108 3,7

160 456 252 220 159 126 5,0

200 568 288 230 199 144 7,5

250 568 338 275 249 169 8,5

315 700 388 330 314 194 12,4

400 700 488 350 399 244 15,4

EXP Free

4Swegon reserves the right to alter specications. 20220217

Inhaltsverzeichnis

Andere Swegon Lüfter Handbücher

Swegon

Swegon REACT Parasol Zenith 600 Leitfaden

Swegon

Swegon WISE Parasol a Bedienungsanleitung

Swegon

Swegon PELICAN Ceiling Extract a Leitfaden

Swegon

Swegon GOLD PX Bedienungsanleitung

Swegon

Swegon COLIBRI Ceiling b Leitfaden

Swegon

Swegon WISE Parasol Zenith 600 Bedienungsanleitung

Swegon

Swegon ILTO 400M Stücklistenhandbuch

Swegon

Swegon PARASOL Zenith 1200 Bedienungsanleitung

Swegon

Swegon ILTO X100 Premium Stücklistenhandbuch

Swegon

Swegon WISE Paragon d Bedienungsanleitung

Swegon

Swegon WISE Kite Ceiling a Bedienungsanleitung

Swegon

Swegon PARASOL c Series Leitfaden

Swegon

Swegon PARAGONc Bedienungsanleitung

Swegon

Swegon ADAPT Sphere c Bedienungsanleitung

Swegon

Swegon PARASOL EXc Leitfaden

Swegon

Swegon CDHb Leitfaden

Swegon

Swegon PARASOL EXc 690 MF Leitfaden

Swegon

Swegon ADAPT Free b Leitfaden

Swegon

Swegon ADAPT Free Leitfaden

Swegon

Swegon HAWK Ceiling a Leitfaden

Swegon

Swegon EAGLE Ceiling Bedienungsanleitung

Swegon

Swegon GOLD SD 004/005 Bedienungsanleitung

Swegon

Swegon COMPACT Air Bedienungsanleitung

Swegon

Swegon COLIBRI Free b Leitfaden

Beliebte Lüfter Handbücher anderer Marken

ELTA FANS

ELTA FANS H03VV-F Bedienungsanleitung

Hunter

Hunter 20714 Gebrauchsanweisung

Emerson

Emerson CARRERA VERANDA CF542ORB00 Bedienungsanleitung

Hunter

Hunter Caraway Gebrauchsanweisung

Panasonic

Panasonic FV-15NLFS1 Bedienungsanleitung

Kompernass

Kompernass KH 1150 Bedienungsanleitung

VES

VES FALA100/12V/TR Bedienungsanleitung

Vertiv

Vertiv Liebert DCD Bedienungsanleitung

Westinghouse

Westinghouse GFP Series Bedienungsanleitung

Venmar

Venmar KUBIX HRV PLUS Series Bedienungsanleitung

Maico

Maico ECR 31 Bedienungsanleitung

Sonnenkonig

Sonnenkonig Dinky Bedienungsanleitung

S&P

S&P ECOWATT HXBR Bedienungsanleitung

Wider

Wider IMP03369BH Bedienungsanleitung

Panasonic

Panasonic F-60DHN Bedienungsanleitung

Hinkley

Hinkley HIGHLAND Bedienungsanleitung

Broan

Broan 766BN Bedienungsanleitung

Premium

Premium PFS16022 Montageanleitung