System air KPB Series Bedienungsanleitung

KPB

Operating Instructions

KPB

GENERAL INSTRUCTIONS

The following instructions must be considered as an integral component

of this product, and the installer person must take care to abide by

them, and be sure that this manual is kept and its instructions respected

for further manipulations of the product.

The manufacturer, Systemair, stress the point of his request, that the

product must be installed by a qualified person.

Always remember that wrong installation might cause important

troubles or damages to people, animals or objects, in which case,

Systemair would not accept claims or responsibilities for such damages,

if the instructions of this manual are not respected.

Once the product is unwrapped, make sure that it is in good shape. If

you are not sure of it, please contact the supplier.

All packing elements, palettes, plastics, staples, etc, must be thrown to

the corresponding recycling binds, and in case of not possibility, to

insure that they are not leave at random, since these elements are a

potential source of danger, and always bearing in mind to harm as less

as possible the natural environment.

When proceed for a cleaning or maintenance operation, the product

must be disconnected from the electric supply.

Never block the inlet or outlet, and protect both from involuntary

contact, and do the same with the shaft(s), pulley(s), belt(s), and rest

of turning/moving components. Systemair has a wide range of

protection articles for these purposes, and you are invited to consult

them in our catalogue (www.systemair.com).

In case any damage or bad function of the product happens, do not try

direct repair or manipulation, and contact the supplier. The not

compliance of this rule means the loss of the product guarantee.

KPB

When it is decided the life product is finished, all components or the

product itself, susceptible of being dangerous, must be recycled of

destroyed, always taken into account to damage as less as possible the

environment.

This product must be used only for the purpose it has been designed,

and therefore it must be considered unsuitable or dangerous for any

other purpose.

Mistakes in the installation or use of the product, will be considered as

not compliance of the indications of the manufacturer, and therefore

Systemair will not accept any claim or responsibility for this.

INSTALLATION AND MOUNTING INSTRUCTIONS

The maximum R.P.M indicated on the technical label of the product

must never be exceeded. If not, the product can cause harm to people,

animals or objects, and the manufacturer will not accept responsibility

for this.

Previous check

This product left the manufacturer premises in perfect working

conditions.

However, check it before installation, because damages could have

occurred while it was transported.

Pulleys

Take care that pulleys are perfectly aligned with each other, and in

perfect perpendicularity with the shaft where it is mounted.

Belts

It must be tightened to the V-belt manufacturer recommended

specifications.

KPB

Check control of the product components

Make the shaft(s) turning by hand and make sure they turn freely.

Clean the product before installation.

Check that motor(s) turn on the right direction.

Maintenance

Check always the product before putting it at work, and after having

remained at stand still for a long period of time.

Check all bearings once a month, and if necessary, apply the suitable

grease.

Revise the belt(s) tightened once a month.

Revise the fan impeller and housing once a month.

Bearings

Bearings of the different components on this product are already

lubricated, and therefore the must not be lubricated before the first

installation of the product. Under normal working conditions, bearings

must be lubricated after 20.000 working hours or 2 years, wathever is

first, and for lubrication, it must be used Lithium based grease with the

specifications Type K3K-30 DIN 51825 and consistency NLGI-3. Bearings

must not be removed from their housing for lubrication purposes.

ATTENTION

All products equipped with electric and moving rotors with IP protection

degree (CEI Standard) must be kept out of people reaching, and in case

of need protected by the necessary elements. Systemair manufactures a

wide range of components for protection. Please consult our catalogue.

Installation of the product, must be done according to the rules applying

in each country.

KPB

GENERAL RULES REGARDING THE ELECTRIC SUPPLY TO THE PRODUCT

According to the safety rules, products using electricity must be

connected to an efficient ground electric gateaway. In case of doubt ask

for a deep electric installation check and be sure that it is carried out by

a qualified person. The manufacturer of this product will not accept any

claim for damages caused by the lack of a ground wire in the

installation.

Check that the electric installation is the right one according to the

maximum product electric input, and make sure that the wire section of

the installation is suitable for the product electric input.

According to the safety rules, an unipolar switch is required for

connection to the electric supply.

When using products consuming electric energy, it is obligatory to

respect the following fundamental rules:

Do not touch the product when part of the body is humid or wet, or

when bare feet.

Do not pull from the electric wires.

Avoid the product exposure to atmospheric agents (snow, rain, sun,

etc).

Never allow the product manipulation by unqualified persons.

The person(s) installing this product must make sure that once it will be

at work, this complies with the following directives:

Low voltage directive (2006/95/EC and EC/93/68).

Machinery directive (2006/42/EC).

Electromagnetic compatibility directive (2004/108/EC).

KPB

Size Approx. weight without min./max. motor

output in kg

9/9 38

10/10 45

12/12 64

15/15 105

18/18 148

20/20 250

22/22 315

25/25 325

30/28 390

Systemair HVAC Spain S.L.U. • C\ Montecarlo, 14 P.I. Uranga • ES-28942

Fuenlabrada Tel.: +34 (0) 91 600 29 00 • Fax: +34 (0) 91 607 03 09

general@systemair.es •www.systemair.es

Inhaltsverzeichnis

Andere System air Lüfter Handbücher

System air

System air VR 400 DCV Bedienungsanleitung

System air

System air MAXK Series Bedienungsanleitung

System air

System air SAVE VTC 200 Bedienungsanleitung

System air

System air BF Silent 100 Bedienungsanleitung

System air

System air ZRS 170 Handbuch

System air

System air KBR 355EC Bedienungsanleitung

System air

System air fantech FIT 120E Bedienungsanleitung

System air

System air AW 630D EC sileo Bedienungsanleitung

System air

System air SAVE VTR 150/B R 1000W Bedienungsanleitung

System air

System air Topvex TR 09 Series Fehlerbehebungshandbuch

System air

System air Fantech FQ 80 Bedienungsanleitung

System air

System air SAVE VSR 150 Bedienungsanleitung

System air

System air DVCompact DXR-10 Handbuch

System air

System air fantech VHR150 Bedienungsanleitung

System air

System air fantech ProPLUS Series Bedienungsanleitung

System air

System air fantech FIT 70E Bedienungsanleitung

System air

System air SAVE VTR 200/B Kurzanleitung

System air

System air Topvex SoftCooler SR11 Bedienungsanleitung

System air

System air K 100 M Handbuch

System air

System air BF 100 Series Bedienungsanleitung

System air

System air fantech FG Series Bedienungsanleitung

System air

System air KFB Handbuch

System air

System air Fantech FR Series Bedienungsanleitung

System air

System air Fantech DPV22-2 Handbuch

Beliebte Lüfter Handbücher anderer Marken

ELTA FANS

ELTA FANS H03VV-F Bedienungsanleitung

Hunter

Hunter 20714 Gebrauchsanweisung

Emerson

Emerson CARRERA VERANDA CF542ORB00 Bedienungsanleitung

Hunter

Hunter Caraway Gebrauchsanweisung

Panasonic

Panasonic FV-15NLFS1 Bedienungsanleitung

Kompernass

Kompernass KH 1150 Bedienungsanleitung

VES

VES FALA100/12V/TR Bedienungsanleitung

Vertiv

Vertiv Liebert DCD Bedienungsanleitung

Westinghouse

Westinghouse GFP Series Bedienungsanleitung

Venmar

Venmar KUBIX HRV PLUS Series Bedienungsanleitung

Maico

Maico ECR 31 Bedienungsanleitung

Sonnenkonig

Sonnenkonig Dinky Bedienungsanleitung

S&P

S&P ECOWATT HXBR Bedienungsanleitung

Wider

Wider IMP03369BH Bedienungsanleitung

Panasonic

Panasonic F-60DHN Bedienungsanleitung

Hinkley

Hinkley HIGHLAND Bedienungsanleitung

Broan

Broan 766BN Bedienungsanleitung

Premium

Premium PFS16022 Montageanleitung