Toshiba Tecra A3 Bedienungsanleitung

Toshiba Personal Computer

TECRA A3/S2

Maintenance Manual

TOSHIBA CORPORATION

ii Tecra A3/S2 Maintenance Manual

manual cannot be reproduced in any form without the prior written permission of

Toshiba. No patent liability is assumed with respect to the use of the information

contained herein.

Toshiba Personal Computer Tecra A3/S2 Maintenance Manual

First edition December 2004

Disclaimer

The information presented in this manual has been reviewed and validated for accuracy.

The included set of instructions and descriptions are accurate for the Tecra A3/S2 Series

at the time of this manual's production. However, succeeding computers and manuals are

subject to change without notice. Therefore, Toshiba assumes no liability for damages

incurred directly or indirectly from errors, omissions, or discrepancies between any

succeeding product and this manual.

Trademarks

IBM is a registered trademark, and OS/2 and PS/2 are trademarks of IBM Corporation.

Microsoft, MS-DOS, Windows, DirectSound and DirectMusic are registered trademarks

of Microsoft Corporation.

Intel and Pentium are registered trademarks, and SpeedStep is a trademark of Intel

Corporation.

Sound Blaster is a registered trademark of Creative Technology Ltd.

Centronics is a registered trademark of Centronics Data Computer Corporation.

Photo CD is a trademark of Eastman Kodak.

All other properties are trademarks or registered trademarks of their respective holders.

Preface

This maintenance manual describes how to perform hardware service maintenance for the

Toshiba Personal Computer Tecra A3/S2, referred to as the Tecra A3/S2 in this manual.

The procedures described in this manual are intended to help service technicians isolate

faulty Field Replaceable Units (FRUs) and replace them in the field.

SAFETY PRECAUTIONS

Four types of messages are used in this manual to bring important information to your

attention. Each of these messages will be italicized and identified as shown below.

DANGER: ........“Danger” indicates the existence of a hazard that could result in death or

serious bodily injury if the safety instruction is not observed.

Tecra A3/S2 Maintenance Manual iii

WARNING:......“Warning” indicates the existence of a hazard that could result in bodily

injury if the safety instruction is not observed.

CAUTION: ... “Caution” indicates the existence of a hazard that could result in property

damage if the safety instruction is not observed.

NOTE: .......... “Note” contains general information that relates to your safe maintenance

service. Improper repair of the computer may result in safety hazards. Toshiba requires

service technicians and authorized dealers or service providers to ensure the following

safety precautions are adhered to strictly.

Be sure to fasten screws securely with the right screwdriver. If a screw is not fully

fastened, it could come loose, creating a danger of a short circuit, which could cause

overheating, smoke or fire.

If you replace the battery pack or RTC battery, be sure to use only the same model battery

or an equivalent battery recommended by Toshiba. Installation of the wrong battery can

cause the battery to explode.

iv Tecra A3/S2 Maintenance Manual

The manual is divided into the following parts:

Chapter 1 ...............................................................................................................................

Hardware Overview describes the Tecra A3/S2 Series system unit and each FRU.

Chapter 2 ...............................................................................................................................

Troubleshooting Procedures explains how to diagnose and resolve FRU problems.

Chapter 3 ...............................................................................................................................

Test and Diagnostics describes how to perform test and diagnostic operations for

maintenance service.

Chapter 4 ...............................................................................................................................

Replacement Procedures describes the removal and replacement of the FRUs.

Appendices............................................................................................................................

The appendices describe the following:

Handling the LCD module

Board layout

Pin assignments

Keyboard scan/character codes

Key layout

Screw torque list

Reliability

Tecra A3/S2 Maintenance Manual v

Conventions

This manual uses the following formats to describe, identify, and highlight terms and operating

procedures.

Acronyms

On the first appearance and whenever necessary for clarification acronyms are enclosed in

parentheses following their definition. For example:

Read Only Memory (ROM)

Keys

Keys are used in the text to describe many operations. The key top symbol as it appears on the

keyboard is printed in boldface type.

Key operation

Some operations require you to simultaneously use two or more keys. We identify such

operations by the key top symbols separated by a plus (+) sign. For example, Ctrl + Pause

(Break) means you must hold down Ctrl and at the same time press Pause (Break). If three

keys are used, hold down the first two and at the same time press the third.

User input

Text that you are instructed to type in is shown in the boldface type below:

DISKCOPY A: B:

The display

Text generated by the computer that appears on its display is presented in the type face below:

Format complete

System transferred

vi Tecra A3/S2 Maintenance Manual

Table of Contents

Chapter 1 Hardware Overview

1.1 Features ............................................................................................................................1-1

1.2 System Unit......................................................................................................................1-5

1.3 2.5-inch Hard Disk Drive.................................................................................................1-9

1.4 Removable Drives..........................................................................................................1-10

1.5 Power Supply .................................................................................................................1-16

1.6 Batteries..........................................................................................................................1-18

Chapter 2 Troubleshooting Procedures

2.1 Troubleshooting Introduction............................................Error! Bookmark not defined.

2.2 Troubleshooting Flowchart ...............................................Error! Bookmark not defined.

2.3 Power Supply Troubleshooting.........................................Error! Bookmark not defined.

2.4 Display Troubleshooting......................................……….Error! Bookmark not defined.

2.5 Keyboard Troubleshooting.............................................................................................2-15

2.6 External USB Devices Troubleshooting ........................................................................2-17

2.7 TV-Out Failure Troubleshooting ...................................................................................2-19

2.8 Printer Port Troubleshooting..........................................................................................2-21

2.9 TouchPad Troubleshooting ............................................................................................2-23

2.10 Speaker Troubleshooting................................................................................................2-25

2.11 Modem Troubleshooting................................................................................................2-27

2.12 PCMCIA Troubleshooting.............................................................................................2-29

2.13 IEEE 1394 Troubleshooting...........................................................................................2-31

2.14 Wireless LAN Troubleshooting .....................................................................................2-33

Tecra A3/S2 Maintenance Manual vii

Chapter 3 Tests and Diagnostics

3.1 The Diagnostic Test...........................................................Error! Bookmark not defined.

3.2 Executing the Diagnostic Test...........................................Error! Bookmark not defined.

3.3 Config Check Test .............................................................Error! Bookmark not defined.

3.4 DMI Check Test.................................................................Error! Bookmark not defined.

3.5 PIO Loopback Test............................................................Error! Bookmark not defined.

3.7 Speaker Audio Test............................................................Error! Bookmark not defined.

3.8 Fan ON/OFF Test ..............................................................Error! Bookmark not defined.

3.9 Main Battery Charge Test..................................................Error! Bookmark not defined.

3.10 FDD Test............................................................................Error! Bookmark not defined.

3.11 CD-ROM Test....................................................................Error! Bookmark not defined.

3.12 Keyboard Test....................................................................Error! Bookmark not defined.

3.13 Mouse (Pad) Test...............................................................Error! Bookmark not defined.

3.14 LCD Pixels Mode Test ......................................................Error! Bookmark not defined.

3.15 Lid Switch Test..................................................................Error! Bookmark not defined.

3.16 HDD R/W Test ..................................................................Error! Bookmark not defined.

3.17 LAN Test ...........................................................................Error! Bookmark not defined.

3.18 RTC Test............................................................................Error! Bookmark not defined.

viii Tecra A3/S2 Maintenance Manual

Chapter 4 Replacement Procedures

4.1 General .............................................................................................................................4-1

4.2 Battery..............................................................................................................................4-7

4.3 PC Card ............................................................................................................................4-8

4.4 HDD .................................................................................................................................4-9

4.5 Optical Drive Module.....................................................................................................4-12

4.6 Optical Drive..................................................................................................................4-13

4.7 Wireless LAN.................................................................................................................4-15

4.8 Expansion Memory ........................................................................................................4-17

4.9 Keyboard........................................................................................................................4-21

4.10 Bluetooth........................................................................................................................4-21

4.11 Modem............................................................................................................................4-25

4.12 Display Assembly...........................................................................................................4-26

4.13 Top Cover.......................................................................................................................4-28

4.14 Touch Pad.......................................................................................................................4-31

4.15 Speakers..........................................................................................................................4-32

4.16 System Board .................................................................................................................4-33

4.17 Direct Play buttom board ...............................................................................................4-36

4.18 Fan, Hest & CPU............................................................................................................4-37

4.19 Display Mask..................................................................................................................4-38

4.20 LCD Module...................................................................................................................4-42

4.21 FL Inverter Board...........................................................................................................4-44

Tecra A3/S2 Maintenance Manual ix

Appendices

Appendix A Handling the LCD Module .................................................................................A-1

Appendix B Board Layout ...................................................................................................... B-1

Appendix C Pin Assignments.................................................................................................. C-1

Appendix D Keyboard Scan/Character Codes ........................................................................ D-1

Appendix E Key Layout...........................................................................................................E-1

Appendix F Series Screw Torque List.....................................................................................F-1

Appendix G Reliability............................................................................................................ G-1

Chapter 1

Hardware Overview

Andere Handbücher für Tecra A3

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Toshiba Desktop Handbücher

Toshiba

Toshiba Canvio Home Bedienungsanleitung

Toshiba

Toshiba 7130 Bedienungsanleitung

Toshiba

Toshiba Libretto 100CT Bedienungsanleitung

Toshiba

Toshiba TECRA A6 Bedienungsanleitung

Toshiba

Toshiba T-Series T3200 Bedienungsanleitung

Toshiba

Toshiba DX730-ST6N01 Bedienungsanleitung

Toshiba

Toshiba QOSMIO F30 Series Bedienungsanleitung

Toshiba

Toshiba PX30 - A Series Bedienungsanleitung

Toshiba

Toshiba Equium 7000D Bedienungsanleitung

Toshiba

Toshiba Satellite 1400 Series Bedienungsanleitung

Toshiba

Toshiba PORTEGE R300 Bedienungsanleitung

Toshiba

Toshiba A20-S259 - Satellite - Pentium 4 2.66 GHz Bedienungsanleitung

Toshiba

Toshiba KIRABOOK U930 Bedienungsanleitung

Toshiba

Toshiba Satellite A300 Series Bedienungsanleitung

Toshiba

Toshiba LX815-D1210 Bedienungsanleitung

Toshiba

Toshiba 7130 Bedienungsanleitung

Toshiba

Toshiba Equium 7300S SERIES Bedienungsanleitung

Toshiba

Toshiba Satellite R10 Bedienungsanleitung

Toshiba

Toshiba Equium 5230D Bedienungsanleitung

Toshiba

Toshiba Satellite M640 Bedienungsanleitung

Toshiba

Toshiba Satellite T110 Bedienungsanleitung

Toshiba

Toshiba 7130 Firmware-Update

Toshiba

Toshiba T-Series T8500 Bedienungsanleitung

Toshiba

Toshiba Equium 7350D Bedienungsanleitung

Beliebte Desktop Handbücher anderer Marken

HP m9060n - Pavilion - Elite Technisches Datenblatt

Asus

Asus E210 Series Bedienungsanleitung

Dell

Dell Inspiron 600m Bedienungsanleitung

Dell

Dell Inspiron 3662 Bedienungsanleitung

TotalFlow

TotalFlow uFLO Bedienungsanleitung

HP Presario SV7000 - Desktop PC Bedienungsanleitung

HP ProDesk 400 G5 Handbuch

Logitech

Logitech MK320 Bedienungsanleitung

Dell

Dell XPS 730 H2C Bedienungsanleitung

Sony

Sony Vaio Series Bedienungsanleitung

Sony

Sony VGC-LT32E - Vaio All-in-one Desktop Computer Bedienungsanleitung

Alto

Alto MD 250 Bedienungsanleitung

Lenovo

Lenovo ThinkCentre Edge 72 Handbuch

Lenovo

Lenovo ThinkStation D20 Handbuch

Arbor Technology

Arbor Technology FPC-7800 Series Bedienungsanleitung

Sony

Sony VAIO VGX-TP1 Series Bedienungsanleitung

Asus

Asus Eee Box B204 Bedienungsanleitung

Dell

Dell Optiplex 9010 All In One Bedienungsanleitung