Toshiba Tecra A3-S711 Bedienungsanleitung

Toshiba Personal Computer

TECRA A3/S2

Maintenance Manual

TOSHIBA CORPORATION

Tecra A3/S2 Maintenance Manual ii

manual cannot be reproduced in any form without the prior written permission of

Toshiba. No patent liability is assumed with respect to the use of the information

contained herein.

Toshiba Personal Computer Tecra A3/S2 Maintenance Manual

First edition December 2004

Disclaimer

The information presented in this manual has been reviewed and validated for accuracy.

The included set of instructions and descriptions are accurate for the Tecra A3/S2 Series

at the time of this manual's production. However, succeeding computers and manuals are

subject to change without notice. Therefore, Toshiba assumes no liability for damages

incurred directly or indirectly from errors, omissions, or discrepancies between any

succeeding product and this manual.

Trademarks

IBM is a registered trademark, and OS/2 and PS/2 are trademarks of IBM Corporation.

Microsoft, MS-DOS, Windows, DirectSound and DirectMusic are registered trademarks

of Microsoft Corporation.

Intel and Pentium are registered trademarks, and SpeedStep is a trademark of Intel

Corporation.

Sound Blaster is a registered trademark of Creative Technology Ltd.

Centronics is a registered trademark of Centronics Data Computer Corporation.

Photo CD is a trademark of Eastman Kodak.

All other properties are trademarks or registered trademarks of their respective holders.

Preface

This maintenance manual describes how to perform hardware service maintenance for the

Toshiba Personal Computer Tecra A3/S2, referred to as the Tecra A3/S2 in this manual.

The procedures described in this manual are intended to help service technicians isolate

faulty Field Replaceable Units (FRUs) and replace them in the field.

SAFETY PRECAUTIONS

Four types of messages are used in this manual to bring important information to your

attention. Each of these messages will be italicized and identified as shown below.

DANGER:.........“Danger” indicates the existence of a hazard that could result in death or

serious bodily injury if the safety instruction is not observed.

Tecra A3/S2 Maintenance Manual iii

WARNING:......“Warning” indicates the existence of a hazard that could result in bodily

injury if the safety instruction is not observed.

CAUTION: ... “Caution” indicates the existence of a hazard that could result in property

damage if the safety instruction is not observed.

NOTE: ...........“Note” contains general information that relates to your safe maintenance

service. Improper repair of the computer may result in safety hazards. Toshiba requires

service technicians and authorized dealers or service providers to ensure the following

safety precautions are adhered to strictly.

Be sure to fasten screws securely with the right screwdriver. If a screw is not fully

fastened, it could come loose, creating a danger of a short circuit, which could cause

overheating, smoke or fire.

If you replace the battery pack or RTC battery, be sure to use only the same model battery

or an equivalent battery recommended by Toshiba. Installation of the wrong battery can

cause the battery to explode.

Tecra A3/S2 Maintenance Manual iv

The manual is divided into the following parts:

Chapter 1................................................................................................................................

Hardware Overview describes the Tecra A3/S2 Series system unit and each FRU.

Chapter 2................................................................................................................................

Troubleshooting Procedures explains how to diagnose and resolve FRU problems.

Chapter 3................................................................................................................................

Test and Diagnostics describes how to perform test and diagnostic operations for

maintenance service.

Chapter 4................................................................................................................................

Replacement Procedures describes the removal and replacement of the FRUs.

Appendices.............................................................................................................................

The appendices describe the following:

Handling the LCD module

Board layout

Pin assignments

Keyboard scan/character codes

Key layout

Screw torque list

Reliability

Tecra A3/S2 Maintenance Manual v

Conventions

This manual uses the following formats to describe, identify, and highlight terms and operating

procedures.

Acronyms

On the first appearance and whenever necessary for clarification acronyms are enclosed in

parentheses following their definition. For example:

Read Only Memory (ROM)

Keys

Keys are used in the text to describe many operations. The key top symbol as it appears on the

keyboard is printed in boldface type.

Key operation

Some operations require you to simultaneously use two or more keys. We identify such

operations by the key top symbols separated by a plus (+) sign. For example, Ctrl + Pause

(Break) means you must hold down Ctrland at the same time press Pause (Break). If three

keys are used, hold down the first two and at the same time press the third.

User input

Text that you are instructed to type in is shown in the boldface type below:

DISKCOPY A: B:

The display

Text generated by the computer that appears on its display is presented in the type face below:

Format complete

System transferred

Tecra A3/S2 Maintenance Manual vi

Table of Contents

Chapter 1 Hardware Overview

1.1 Features ............................................................................................................................1-1

1.2 System Unit......................................................................................................................1-5

1.3 2.5-inch Hard Disk Drive.................................................................................................1-9

1.4 Removable Drives..........................................................................................................1-10

1.5 Power Supply.................................................................................................................1-16

1.6 Batteries .........................................................................................................................1-18

Chapter 2 Troubleshooting Procedures

2.1 Troubleshooting Introduction................................................................................................

2.2 Troubleshooting Flowchart....................................................................................................

2.3 Power Supply Troubleshooting..............................................................................................

2.4 Display Troubleshooting...........................................................................................……….

2.5 Keyboard Troubleshooting ............................................................................................2-15

2.6 External USB Devices Troubleshooting........................................................................2-17

2.7 TV-Out Failure Troubleshooting ...................................................................................2-19

2.8 Printer Port Troubleshooting..........................................................................................2-21

2.9 TouchPad Troubleshooting............................................................................................2-23

2.10 Speaker Troubleshooting ...............................................................................................2-25

2.11 Modem Troubleshooting................................................................................................2-27

2.12 PCMCIA Troubleshooting.............................................................................................2-29

2.13 IEEE 1394 Troubleshooting ..........................................................................................2-31

2.14 Wireless LAN Troubleshooting.....................................................................................2-33

Tecra A3/S2 Maintenance Manual vii

Chapter 3 Tests and Diagnostics

3.1 The Diagnostic Test...............................................................................................................

3.2 Executing the Diagnostic Test ...............................................................................................

3.3 Config Check Test .................................................................................................................

3.4 DMI Check Test.....................................................................................................................

3.5 PIO Loopback Test ................................................................................................................

3.7 Speaker Audio Test................................................................................................................

3.8 Fan ON/OFF Test ..................................................................................................................

3.9 Main Battery Charge Test......................................................................................................

3.10 FDD Test................................................................................................................................

3.11 CD-ROM Test........................................................................................................................

3.12 Keyboard Test........................................................................................................................

3.13 Mouse (Pad) Test...................................................................................................................

3.14 LCD Pixels Mode Test...........................................................................................................

3.15 Lid Switch Test ......................................................................................................................

3.16 HDD R/W Test.......................................................................................................................

3.17 LAN Test................................................................................................................................

3.18 RTC Test................................................................................................................................

Tecra A3/S2 Maintenance Manual viii

Chapter 4 Replacement Procedures

General.............................................................................................................................4-1

4.2 Battery..............................................................................................................................4-7

4.3 PC Card............................................................................................................................4-8

4.4 HDD.................................................................................................................................4-9

4.5 Optical Drive Module ....................................................................................................4-12

4.6 Optical Drive..................................................................................................................4-13

4.7 Wireless LAN ................................................................................................................4-15

4.8 Expansion Memory........................................................................................................4-17

4.9 Keyboard........................................................................................................................4-21

4.10 Bluetooth........................................................................................................................4-21

4.11 Modem...........................................................................................................................4-25

4.12 Display Assembly ..........................................................................................................4-26

4.13 Top Cover ......................................................................................................................4-28

4.14 Touch Pad ......................................................................................................................4-31

4.15 Speakers .........................................................................................................................4-32

4.16 System Board .................................................................................................................4-33

4.17 Direct Play buttom board ...............................................................................................4-36

4.18 Fan, Hest & CPU ...........................................................................................................4-37

4.19 Display Mask .................................................................................................................4-38

4.20 LCD Module ..................................................................................................................4-42

4.21 FL Inverter Board...........................................................................................................4-44

Tecra A3/S2 Maintenance Manual ix

Appendices

Appendix A Handling the LCD Module ................................................................................. A-1

Appendix B Board Layout........................................................................................................B-1

Appendix C Pin Assignments.................................................................................................. C-1

Appendix D Keyboard Scan/Character Codes ........................................................................ D-1

Appendix E Key Layout...........................................................................................................E-1

Appendix F Series Screw Torque List .....................................................................................F-1

Appendix G Reliability............................................................................................................ G-1

Chapter 1

Hardware Overview

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Toshiba Laptop Handbücher

Toshiba

Toshiba A215S7444 - Satellite - Turion 64 X2 1.9 GHz Bedienungsanleitung

Toshiba

Toshiba P305-S8832 Bedienungsanleitung

Toshiba

Toshiba R840-S8420 Bedienungsanleitung

Toshiba

Toshiba A665-S6050 Bedienungsanleitung

Toshiba

Toshiba A215-S5829 - Satellite - Athlon 64 X2 1.9... Bedienungsanleitung

Toshiba

Toshiba Portege S100-S1133 Bedienungsanleitung

Toshiba

Toshiba Satellite C655 Bedienungsanleitung

Toshiba

Toshiba T-Series T3200 Bedienungsanleitung

Toshiba

Toshiba X870-BT3G23 Bedienungsanleitung

Toshiba

Toshiba Qosmio G35-AV660 Series Bedienungsanleitung

Toshiba

Toshiba Satellite A300D Series Bedienungsanleitung

Toshiba

Toshiba Satellite T130D Bedienungsanleitung

Toshiba

Toshiba R830-S8310 Bedienungsanleitung

Toshiba

Toshiba Satellite L750-ST5N02 Bedienungsanleitung

Toshiba

Toshiba Portege 610CT Bedienungsanleitung

Toshiba

Toshiba T-Series T4500 Bedienungsanleitung

Toshiba

Toshiba M55-S2252 Bedienungsanleitung

Toshiba

Toshiba U300-ST3091 Bedienungsanleitung

Toshiba

Toshiba Satellite A205 Series Bedienungsanleitung

Toshiba

Toshiba KIRABook 13 i5 Bedienungsanleitung

Toshiba

Toshiba T1100 PLUS Bedienungsanleitung

Toshiba

Toshiba M645-S4050 Bedienungsanleitung

Toshiba

Toshiba Satellite L755-S5256 Bedienungsanleitung

Toshiba

Toshiba A665-S5181 Bedienungsanleitung

Beliebte Laptop Handbücher anderer Marken

HP ze2401xt - Pavilion Notebook PC Bedienungsanleitung

Velocity

Velocity NoteMagix M10 Bedienungsanleitung

Dell

Dell Alienware 17 R2 Bedienungsanleitung

HP ENVY 17 Handbuch

Winbook

Winbook LM Bedienungsanleitung

Dell

Dell Inspiron 1464 Bedienungsanleitung

Dell

Dell Inspiron 15R 5537 Bedienungsanleitung

HP PROBOOK 4520S Handbuch

Dell

Dell Latitude ATG D620 Bedienungsanleitung

Dell

Dell Latitude 7310 Bedienungsanleitung

Dell

Dell Precision GU806 Bedienungsanleitung

Sony

Sony VAIO PCG-R505JLK Bedienungsanleitung

Lenovo

Lenovo THINKPAD X32 Bedienungsanleitung

HP Compaq tc4200 Kurzanleitung

Sony

Sony VGN-T240P VAIO Bedienungsanleitung

Compaq

Compaq Armada E700 Series Bedienungsanleitung

Fujitsu

Fujitsu Lifebook A6230 Bedienungsanleitung

Acer

Acer Aspire ONE 722 Bedienungsanleitung