Town & Country Fireplaces 22150050 Bedienungsanleitung

180416-12 SKU# 22150050 100005922

TCWS54

BLACK DIAMOND

BURNER KIT

INSTRUCTIONS

SKU# 22150050

For TCWS Series D

Fireplaces

These instructions are supplementary to the Installation

and Operating Instructions supplied with the replace

and should be kept together. Refer to the Installation

and Operating Instructions for proper gas supply, safety

requirements and operating instructions.

INSTALLER: Leave this manual with the appliance.

CONSUMER: Retain this manual for future reference.

Visit www.townandcountryﬁreplaces.net for the most up-to-date version of this manual

Figure 1: TCWS54 Black Diamond Burner parts.

SKU# 22150050_270223-12

Contents of Package

1 BURNER TRAY

2 BURNER ASSEMBLIES

Figure 2: Instruction book. Figure 3: Glass media.

Figure 4: Installing right burner. Figure 5: Attaching pilot to burner tray.

Figure 6: Tilting burner tray to install. Figure 7: Screwing down the burner tray.

SKU# 22150050_270223-12

Black Diamond Burner Installation

FIRST HOLE POSITION

If converting to propane see conversion instructions on page #5 before proceeding.

Install panels according to the TCWS.54D Installation and Operating manual prior to burner installa-

tion. (Page 28)

NOTE: check air shutter for

correct fuel setting before

proceeding further. Both burner

shutters are to be set the same,

fully closed for natural gas. 13/64

(0.2)” open for LP.

1. Install one of the two burners into the right side of the rebox by laying into location trough and sliding to the

right to engage the venturi tube over the orice. Insert the 2nd burner from the left so that it butts up to the

previously placed right side burner (Figure 4).

2. Ensure that the Pilot is attached to the burner support rail with a screw in the rst hole (Figure 5).

3. Tilt the burner tray into the unit and place on top of the manifold brackets and over top of the pilot (Figure 6).

4. Secure the burner tray to manifold brackets using eight screws (Figure 7).

CAUTION: The burners should

be tightly butted up against each

other at the center to ensure

correct operation.

Figure 8: Applying glass media. Figure 9: Placing rear trim.

Figure 10: Positioning front trim. Figure 11: Front trim.

SKU# 22150050_270223-12

WIDE EDGE TO FRONT OF

FIREPLACE WITH FRONT

TRIM, TO THE REAR OF THE

FIREBOX FOR REAR TRIM.

5. Place glass media into the burner tray and brush smooth so that a very light layer covers the burners

(Figure 8).

6. Place rear porcelain trim, wide edge, against the back panel and press down over the pre-bent tabs on

the burner tray (Figure 9).

7. Place the front porcelain trim so that it rests on the front shelf of the rebox and is snug against the rebox

frame (Figure 10). Ensure that the wide edge of the trim is against the rebox frame (Figure 11).

NOTE: Too much glass media will cause sooting and improper ﬂame pattern.

Figure 12: Burner tray removal. Figure 13: Removing the orice.

SKU# 22150050_270223-12

WARNING

This conversion kit shall be installed by a qualiﬁed service agency in accordance with the

manufacturer's instructions and all applicable codes and requirements of the authority having

jurisdiction.

If the information in these instructions is not followed exactly, a ﬁre, explosion or production of

carbon monoxide may result causing property damage, personal injury or loss of life.

The qualiﬁed service agency is responsible for the proper installation of this kit.

The installation is not proper and complete until the operation of the converted appliance is

checked as speciﬁed in the manufacturer's instructions supplied with the kit.

If the unit is to be used with propane, convert as follows using the components supplied with the

TCWS 54 Propane Conversion Kit, SKU# 22180010 which includes Propane oriﬁce and Conversion

Label.

CAUTION

The gas supply and electrical power shall be shut off before proceeding with the conversion.

Note:

Factory supplied components must be used to ensure correct input. After conversion, conrm proper manifold pressure.

Propane Conversion

1. If installed remove the glass media from the burners.

2. If installed remove the burner tray from the manifold brackets (Figure 12).

3. Remove burners.

4. Using a 1/2” wrench, undo the natural gas burner orice (Figure 13). Apply a small amount of pipe joint

compound to the threads of the propane burner orice (marked “LC”) to ensure a good seal, before

screwing it into the tting.

Figure 16: Natural gas position.

Figure 14: Air shutter gap. Figure 15: Loosening the pilot.

For complete conversion valve installation instructions, refer

to the instruction book included in the SIT conversion kit.

SKU# 22150050_270223-12

WARNING: Both the control box shield and the access panel must be reinstalled after conversion/

installation or servicing has been completed. Failure to do so will cause overheat ing and premature

failure of the control system.

5. Loosen the primary air shutter screw, open shutter to give a gap of 13/64” (0.2”) and re-tighten. Repeat

on other burner (Figure 14).

6. With a 7/16” wrench loosen the pilot head on the pilot assembly (Figure 15).

7. Slide the pilot adjustment band over and ensure that the hole in the orice band is showing (Figure 17).

8. Update Propane Conversion Sticker with date and name after conversion is nished (Figure 19).

Figure 17: Liquid propane position.

ADJUSTMENT BAND

Cet appareil a été converti en gaz propane

Numéro d'assemblage

j m a

Firme

Adresse

l'entreprise désignée

ci-dessus accepte la

responsabilité que cette

conversion a été

correctement faite.

Kit Number

dd mm yy

Company

Address

The above accepts the

responsibility that this

conversion has been

properly performed.

This appliance was converted to propane gas

5052.52001-B

Figure 19: Conversion label

Figure 20: Gas pressure adjustment

tting.

Figure 21: Gas pressure adjustment

location.

Figure 22: Gas pressure test ports.

Figure 18: Main burner orice.

MAIN BURNER ORIFICE

marked “LC”

SKU# 22150050_270223-12

Note: To test the gas pressure, turn off the gas supply before removing the plug from the supply

pressure test port or manifold pressure test port.

Verify gas pressures with the ﬁreplace lit and on the highest setting.

Supply

Pressure

Manifold

Pressure

Correct gas pressure requirement:

Supply Pressure Natural Gas Propane

Min. Pressure 5.0" WC 12.5" WC

(For purpose of input adjustment)

Max. Pressure 13.9" WC 13.9" WC

Manifold Pressure

Maximum 3.5" WC 10" WC

Minimum 1.6" WC 6.4" WC

Gas Pressure Check

Figure 23: Example of desired ame appearance.

SKU# 22150050_270223-12

The air shutter on the burner tube controls the primary combustion air. It is set to the closed position at the

factory for natural gas fuel. For LP see Pg.6. Some adjustment may be necessary to obtain desired ame and

to eliminate carbon deposits. Evaluate ame appearance after the replace has reached operating tempera-

ture. See Fig. #25 for proper ame pattern.

Open primary air if the window glass and rebox have carbon accumulation and/or the ames are long, dark

and stringy. The shutter may also be opened to lessen the ame height.

Burner Flame Adjustment

NOTE:

Proper air shutter setting is required.

The ﬂame should be just orange and “lazy”. It should NEVER be set to create sooting on internal parts

and window glass. Allow the ﬁreplace to run for 30 minutes before evaluating ﬂame appearance.

NOT SHOWN

SKU# 22150050_270223-12

ITEM.......DESCRIPTION......................................................... PART NO.

#1..........BLACK DIAMOND BURNER ........................ 22150050

#2..........GLASS MEDIA (2 required).................... TCRP.501201

(WHEN ORDERING, INCLUDE PART NUMBER WITH DESCRIPTION)

Parts Diagram

SKU# 22150050_270223-12

Inhaltsverzeichnis

Andere Town & Country Fireplaces Kaminzubehör Handbücher

Town & Country Fireplaces

Town & Country Fireplaces 22150017 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC30 Black Diamond Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCWS.54NGST03D Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC54 SERIES DMODULAR Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces 22150014 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCWS.38CE2 Technisches Handbuch

Town & Country Fireplaces

Town & Country Fireplaces TC30 Black Diamond Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces 22150052 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC54 SERIES DMODULAR Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC54 SERIES DMODULAR Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC42 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC42 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC42 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCWS.38NG08C Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces 22150033 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces 22150019 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC30 Black Diamond Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces 22080040 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC30 Black Diamond Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces King-TC Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCVT.PVCV Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCWS.38CE2 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces 22150051 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC42 Bedienungsanleitung

Beliebte Kaminzubehör Handbücher anderer Marken

Valor

Valor L2 1700K Bedienungsanleitung

Exodraft

Exodraft Xzense Bedienungsanleitung

Whalen

Whalen Ruso MNFP62BF23-6 Bedienungsanleitung

Lopi

Lopi Hearthview 864 Bedienungsanleitung

Woodstock Soapstone

Woodstock Soapstone Fireview 201 Bedienungsanleitung

EdilKamin

EdilKamin SERBATOIO 250 Kurzanleitung

Bronpi

Bronpi KIT-1 Bedienungsanleitung

Travis Industries

Travis Industries 33 DVI Bedienungsanleitung

Superior

Superior ASD3628-TI Bedienungsanleitung

pleasant hearth

pleasant hearth OFP28WG Bedienungsanleitung

IHP

IHP Astria Series Bedienungsanleitung

Firegear

Firegear FG-H-2110SS Bedienungsanleitung

Nibe

Nibe Contura C i31 Bedienungsanleitung

kozy heat

kozy heat KZK-052 Bedienungsanleitung

SimpliFire

SimpliFire SF-WM36 Bedienungsanleitung

Bluegrass Living

Bluegrass Living BC18NR Kurzanleitung

pleasant hearth

pleasant hearth IRIS SCROLL Bedienungsanleitung

Cooke

Cooke Glass Wind Guard Bedienungsanleitung