Town & Country Fireplaces 22150052 Bedienungsanleitung

060323-28 SKU# 22150052 100005917

TCWS54

SEE THRU

DIAMOND BURNER

INSTALLATION KIT

INSTRUCTIONS

SKU# 22150052

For TCWS54ST and

TCWS54ST Indoor/Outdoor

Series D Fireplaces

These instructions are supplementary to the Installation

and Operating Instructions supplied with the replace

and should be kept together. Refer to the Installation

and Operating Instructions for proper gas supply, safety

requirements and operating instructions.

Visit www.townandcountry.com for the most recent version of this manual

INSTALLER: Leave this manual with the appliance.

CONSUMER: Retain this manual for future reference.

SKU# 22150052_060323-28

100005917

Table of Contents

Contents of Package ................................................................. 3

Diamond Burner Installation ...................................................... 4

Propane Conversion ................................................................ 13

Orice conversion procedure........................................... 13

Accessing the gas valve for conversion........................... 16

Gas Pressure Check ................................................................ 19

Correct gas pressure requirement:................................... 19

Burner Flame Adjustment ........................................................ 20

Optional Long Beach Log Set Installation ............................... 21

Log Placement ................................................................. 21

Lights Wiring Diagram ............................................................. 25

Replacement Parts .................................................................. 26

SKU# 22150015_060323-28 100005917

Contents of Package

Secondary oor panels

Glass media tray

Burners

160517-28 TCWS.54NGST03D 5056.425181D

TCWS54

SEE THRU

DIAMOND BURNER

INSTALLATION KIT

INSTRUCTIONS

PART# TCWS.54NGST03D

For TCWS54ST and

TCWS54ST Indoor/Outdoor

Series D Fireplaces

These instructions are supplementary to the Installation

and Operating Instructions supplied with the replace

and should be kept together. Refer to the Installation

and Operating Instructions for proper gas supply, safety

requirements and operating instructions.

Visit www.townandcountry.com for the most recent version of this manual

INSTALLER: Leave this manual with the appliance.

CONSUMER: Retain this manual for future reference.

3 x 5lb bags Diamond Glass Media

1. With the control compartment to your left, place one of the two secondary oor panels in the right side

of the rebox (Figure 1) and route the two wires from the lights underneath the plate over to the left hand

side of the rebox (Figure 2).

SKU# 22150052_060323-28

100005917

If converting to propane see “Propane Conversion” on page 13 before proceeding.

Diamond Burner Installation

Figure 1: Inserting secondary oor panel into the right side.

Figure 2: Right hand panel in place with its wires brought out from

under it.

NOTE: For purposes of clarity, the “Front” of the ﬁreplace shall be the side which has

access to the electrical connection compartment cover, the connection to the gas valve and

the side which places the control compartment cover and the coaxial vent located on top of

the ﬁreplace to your left.

2. Feed the two wires from the right side secondary oor panel down through the left most grommet over the

gas control compartment cover (Figure 3).

3. Insert the other secondary oor panel into the left side of the rebox. As the panel is lowered, feed its two

lights wires into the same grommet as was done with the wires from the right hand oor panel. Also feed

the pilot assembly through the square opening in the panel (Figure 4).

Grommet

Figure 3: Wires through grommet.

Figure 4: Inserting secondary oor panel into the left side.

SKU# 22150015_060323-28 100005917

4. Guide the four light wires from the bottom of the gas control compartment out through the opening as

shown in Figure 5.

5. From inside the control compartment, punch out one of two available knockouts located in the electrical

connection compartment, install a plastic grommet (not included) to protect the wires and feed the wires

into the compartment. (Figure 6).

Figure 5: Lights wiring coming from grommet.

Figure 6: Threading wires through knockout.

SKU# 22150052_060323-28

100005917 6

6. Remove the electrical connection compartment cover and feed all four lights wires through the opening.

The lights wiring will connect to the wiring that supplies the re place power (Figure 7).

7. Connect the wires to a switched 120 VAC, 60Hz, 3A power supply, one pair made up of one wire from the

left and one wire from the right light set to the “HOT” incoming line. The remaining pair to the “Neutral”

incoming line. See “Lights Wiring Diagram” on page 25. Reinstall the electrical connection compart-

ment cover.

8. Return to the rebox and secure the two secondary oor panels with four T20 screws for each of the two

panels.

9. From the REAR of the replace, position one of the two burners on an angle and attach the pilot assembly

to the burner leg using two Robertson screws provided (Figure 8). Note that the pilot will be positioned on

an angle.

Figure 7: Bringing wires through front plate.

SKU# 22150015_060323-28 100005917

Figure 8: Attaching the pilot assembly to the burner leg.

10. Slip the gas burner venturi over the orice and screw the burner leg to the secondary oor panel using a

T20 screw (Figure 9).

11. Place the second burner in the rebox so that its venturi ts over the second orice. Secure the leg to the

secondary oor panel.

Figure 9: Securing the burner leg to the secondary oor panel.

3/16” Open for Propane Gas

Fully closed for Natural Gas

Figure 10: Shutter gap settings.

SKU# 22150052_060323-28

100005917

NOTE: Check air shutter for correct fuel setting before proceeding further. Both burner shutters

are to be set the same. Fully closed for NATURAL GAS and 3/16” open for LIQUID PROPANE.

CAUTION: The burners should be tightly butted up against each other at the center to ensure

correct operation.

13. Insert both side panels (Figure 13).

Side panel

retainer clips

Figure 11: Side panel retainer clips location.

12. Remove the panel retainer clips from both sides of the upper rebox in preparation for side panel installa-

tion (Figure 11). There are two clips on each side of the rebox.

Figure 12: Side panel. Figure 13: Side panel installation.

SKU# 22150015_060323-28 100005917

Reinstalled

Side panel

retainer clips

Figure 14: Reinstalled side panel retainer clips.

14. Reinstall the side panel retainer clips (Figure 14) .

15. Place glass media tray over top of the burners so that its legs rest on the secondary oor. The side of the

tray with the mesh strip crossing over from one side to the other must be positioned over top of the pilot

assembly. Screw down the ends of the tray to the ledge of the side panels - two on each side (Figure 15).

Mesh cross-over must be positioned

over the pilot assembly

Figure 15: Glass media tray.

SKU# 22150052_060323-28

100005917 10

Inhaltsverzeichnis

Andere Town & Country Fireplaces Kaminzubehör Handbücher

Town & Country Fireplaces

Town & Country Fireplaces 22150017 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC42 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCWS.38NG08C Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces 22080040 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC30 Black Diamond Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC42 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC30 Black Diamond Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces 22150051 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC30 Black Diamond Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces 22150019 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCVT.PVCV Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCWS.54LOGDW Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCWS.38CE2 Technisches Handbuch

Town & Country Fireplaces

Town & Country Fireplaces TC54 SERIES DMODULAR Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces 22150012 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC30 Black Diamond Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC42 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCWS.38CE2 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces 22150014 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TCWS.54NGST03D Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces 22150050 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC30 Black Diamond Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC42 Bedienungsanleitung

Town & Country Fireplaces

Town & Country Fireplaces TC42 Bedienungsanleitung

Beliebte Kaminzubehör Handbücher anderer Marken

Valor

Valor L2 1700K Bedienungsanleitung

Exodraft

Exodraft Xzense Bedienungsanleitung

Whalen

Whalen Ruso MNFP62BF23-6 Bedienungsanleitung

Lopi

Lopi Hearthview 864 Bedienungsanleitung

Woodstock Soapstone

Woodstock Soapstone Fireview 201 Bedienungsanleitung

EdilKamin

EdilKamin SERBATOIO 250 Kurzanleitung

Bronpi

Bronpi KIT-1 Bedienungsanleitung

Travis Industries

Travis Industries 33 DVI Bedienungsanleitung

Superior

Superior ASD3628-TI Bedienungsanleitung

pleasant hearth

pleasant hearth OFP28WG Bedienungsanleitung

IHP

IHP Astria Series Bedienungsanleitung

Firegear

Firegear FG-H-2110SS Bedienungsanleitung

Nibe

Nibe Contura C i31 Bedienungsanleitung

kozy heat

kozy heat KZK-052 Bedienungsanleitung

SimpliFire

SimpliFire SF-WM36 Bedienungsanleitung

Bluegrass Living

Bluegrass Living BC18NR Kurzanleitung

pleasant hearth

pleasant hearth IRIS SCROLL Bedienungsanleitung

Cooke

Cooke Glass Wind Guard Bedienungsanleitung