True Food Prep TFP-32-12M-D-2 Bedienungsanleitung

............ www.truemfg.com ............

TABLE OF CONTENTS

Safety Information

Safety Precautions 1

Proper Disposal 2

Connecting Electricity 3

Adapter Plugs 3

Installation / Operation Instructions

Ownership 4

Required Tools 4

Uncrating 4

Locating & Lid Installation 5

Leveling & Castor Adjusting 6

Storage Bins 7

Drawer Alignment 7

Drawer Removal and Installation 8

Electrical Instructions 8

Wire Gauge Chart 9

Sequence of Operation 10

Startup 10

Temperature Control Location 10

Maintenance, Care & Cleaning

Cleaning Condenser Coil 11-12

Stainless Steel Equipment Care & Cleaning 13-14

Composite Cutting Board Maintenance 14

Warranty (U.S.A. & Canada Only!) 15

INSTALLATION MANUAL FOR TRUE FOOD PREP MODELS

TRUE FOOD PREP MODELS

TRUE FOOD SERVICE EQUIPMENT, INC.

2001 East Terra Lane • O’Fallon, Missouri 63366-4434

(636)-240-2400 • FAX (636)272-2408 • INT’L FAX (636)272-7546 • (800)325-6152

Parts Department (800)424-TRUE • Parts Department FAX# (636)272-9471

CONGRATULATIONS!

You have just purchased the finest commercial

refrigerator available. You can expect many years of

trouble-free operation.

TFP-32-12M-D-2

#954377

True Food Service Equipment, Inc.

............ www.truemfg.com ............

True Food Service Equipment, Inc.

............ www.truemfg.com ............

SAFETY INFORMATION

• Thisrefrigeratormustbeproperlyinstalled

andlocatedinaccordancewiththeInstallation

Instructionsbeforeitisused.

• Donotallowchildrentoclimb,standorhangonthe

shelvesintherefrigerator.Theycoulddamagethe

refrigeratorandseriouslyinjurethemselves.

• Donottouchthecoldsurfacesintherefrigerator

compartmentwhenhandsaredamporwet.Skin

maysticktotheseextremelycoldsurfaces.

• Donotstoreorusegasolineorotherflammable

vaporsandliquidsinthevicinityofthisoranyother

appliance.

• Keepfingersoutofthe“pinchpoint”areas;

clearancesbetweenthedoorsandbetweenthedoors

andcabinetarenecessarilysmall;becarefulclosing

doorswhenchildrenareinthearea.

NOTE

We strongly recommend that any servicing be preformed by

a qualified individual.

• Unplugtherefrigeratorbeforecleaningand 

 makingrepairs.

• Settingtemperaturecontrolstothe0positiondoes

notremovepower.

WARNING!

Use this appliance for its intended purpose as described in

this Owner Manual.

This cabinet contains fluorinated greenhouse gas covered by the Kyoto Protocol

(please refer to cabinet’s inner label for type and volume,

GWP of 134a= 1,300. R404a= 3,800).

How to Maintain Your Unit to

Receive the Most Efficient and

Successful Operation

You have selected one of the finest commercial refrigeration units made. It is manufactured

under strict quality controls with only the best quality materials available. Your TRUE cooler

when properly maintained will give you many years of trouble-free service.

SAFETY PRECAUTIONS

When using electrical appliances, basic safety precautions should be followed, including the following:

True Food Service Equipment, Inc.

............ www.truemfg.com ............

SAFETY INFORMATION

PROPER DISPOSAL OF THE REFRIGERATOR

DANGER!

RISK OF CHILD ENTRAPMENT

USE OF EXTENSION CORDS

NEVER USE AN EXTENSION CORD! TRUE will not warranty any refrigerator that has been connected to an extension cord.

Childentrapmentandsuffocationarenotproblems

ofthepast.Junkedorabandonedrefrigeratorsarestill

dangerous…eveniftheywillsitfor“justafewdays.”If

youaregettingridofyouroldrefrigerator,pleasefollow

theinstructionsbelowtohelppreventaccidents.

Before You Throw Away Your Old Refrigerator or

Freezer:

• Takeoffthedoors.

• Leavetheshelvesinplacesothatchildrenmaynot

easilyclimbinside.

Refrigerant Disposal

Youroldrefrigeratormayhaveacoolingsystem

thatuses“OzoneDepleting”chemicals.Ifyouare

throwingawayyouroldrefrigerator,makesurethe

refrigerantisremovedforproperdisposalbya

qualifiedservicetechnician.Ifyouintentionally

releaseanyrefrigerantsyoucanbesubjectto

finesandimprisonmentunderprovisionsofthe

environmentalregulations.

REPLACEMENT PARTS

• Componentpartsshallbereplacedwithlikecomponents.

• Servicingshallbedonebyauthorizedservicepersonnel,tominimizetheriskofpossibleignitionduetoincorrect

 partsorimproperservice.

• Lampsmustbereplacedbyindenticallampsonly.

• Ifthesupplycordisdamaged,itmustbereplacedbyaspecialcordorassemblyavailablefromthemanufactureror

 itsserviceagent.

True Food Service Equipment, Inc.

Thepowercordfromthisapplianceisequippedwith

agroundingplugwhichminimizesthepossibilityof

electricshockhazard.

Havethewalloutletandcircuitcheckedbyaqualified

electriciantomakesuretheoutletisproperlygrounded.

Iftheoutletisastandard2-prongoutlet,itisyour

personalresponsibilityandobligationtohaveitreplaced

withtheproperlygroundedwalloutlet.

Therefrigeratorshouldalwaysbepluggedintoit’sown

individualelectricalcircuit,whichhasavoltagerating

thatmatchestheratingplate.

Thisprovidesthebestperformanceandalsoprevents

overloadingbuildingwiringcircuitswhichcouldcausea

firehazardfromoverheatedwires.

Neverunplugyourrefrigeratorbypullingonthepower

cord.Alwaysgripplugfirmlyandpullstraightoutfrom

theoutlet.

Repairorreplaceimmediatelyallpowercordsthathave

becomefrayedorotherwisedamaged.Donotuseacord

thatshowscracksorabrasiondamagealongitslengthor

ateitherend.

Whenremovingtherefrigeratorawayfromthewall,be

carefulnottorolloverordamagethepowercord.

HOW TO CONNECT ELECTRICITY

Do not, under any circumstances, cut or remove the ground prong from the power cord.

For personal safety, this appliance must be properly grounded.

WARNING!

USE OF ADAPTER PLUGS

NEVER USE AN ADAPTER PLUG! Because of potential safety hazards under certain conditions, we strongly recommend

against the use of an adapter plug.

............ www.truemfg.com ............

SAFETY INFORMATION

(North America Use Only!)

NEMAplugs

TRUEusesthesetypesofplugs.If

youdonothavetherightoutlethave

acertifiedelectricianinstallthecorrect

powersource.

Theincomingpowersourcetothecabinetincludingany

adaptersusedmusthavetheadequatepoweravailable

andmustbeproperlygrounded.Onlyadapterslisted

withULshouldbeused.

True Food Service Equipment, Inc.

............ www.truemfg.com ............

INSTALLATION / OPERATION INSTRUCTIONS

Toensurethatyourunitworksproperlyfromthefirst

day,itmustbeinstalledproperly.Wehighlyrecommend

atrainedrefrigerationmechanicandelectricianinstall

yourTRUEequipment.Thecostofaprofessional

installationismoneywellspent.

BeforeyoustarttoinstallyourTRUEunit,carefully

inspectitforfreightdamage.Ifdamageisdiscovered,

immediatelyfileaclaimwiththedeliveryfreightcarrier.

TRUE is not responsible for damage incurred during

shipment.

OWNERSHIP

• 3/8”SocketWrench

• PhillipsHeadScrewdriver

• Level

REQUIRED TOOLS

Thefollowingprocedureisrecommendedforuncratingtheunit:

A. Removetheouterpackaging,(cardboardandbubblesorstyrofoamcornersandclearplastic).Inspectforconcealed

damage.Again,immediatelyfileaclaimwiththefreightcarrierifthereisdamage.

B. Moveyourunitasclosetothefinallocationaspossiblebeforeremovingthewoodenskid.

NOTE

Keys for coolers with door locks are located in warranty packets.

UNCRATING

INSTALLATION / OPERATION INSTRUCTIONS

REMOTE UNITS (This section applies to remotes only!)

• Remotecabinetsmustbeorderedasremote. 

 Wedonotrecommendconvertingforastandard

 selfcontainedtoremotesystem.

• Allremotecabinetsmustbehardwired.

• Nocastorsavailable.

• Allremotecabinetscomestandardusing404A 

 refrigerant.

• Allremoteunitscomestandardwithexpansion 

 valve,liquidlinesolenoid,heatedcondensatepan,

 anddefrosttimerwhenapplicable.

• ContactTRUETechnicalServiceforBTU 

 requirements.

• Nowiringnecessarybetweencabinetand 

 condensingunit.

• Allremotecondensingunitspurchasedfrom 

 TRUEare208/230voltssinglephase.

If you have any questions regarding this section, please

call TRUE at 1-(800)-325-6152.

REMOTE UNITS

True Food Service Equipment, Inc.

............ www.truemfg.com ............

INSTALLATION / OPERATION INSTRUCTIONS

A. Placepackingmaterialbehindcabinetasacushion.

WARNING:

Make sure all bins, bin support bars, and lid are

removed from unit before placing unit on its back.

 Carefullylaytheunitonitsbacktoremoveskid.

When lifting unit remember to

leave the cabinet upright for 24 hours before

plugging into power source.

B. Removeskidbyunscrewingallbaserailanchor

brackets.Placeskidtotheside.

C. Carefullyliftcabinetupright.

D. Applicancetestedaccordingtotheclimateclasses5

and7fortemperatureandrelativehumidity.

LOCATING

Removing

skid from

bottom of

cabinet.

CUTTING BOARD

A. Removethumbscrewsfromcuttingboardbrackets.

(Seefigure1).

B. Removebracketsfrombothsidesoftheboard.

C. Carefullyliftcuttingboard.

Figure 1.

ANCHORING THE TFP HOOD COVER

TFP Hood Installation Instruction

A. ThisisTRUE’srecommendedprocedurefor

installingthelidtothehood.

 Seetheillustration.

Assembly

1.Locatethelid,(packagedwithinthecardboard

containerontopoftheunit),andpositionunderthe

hood.

2.Placelidintofinalposition,(beneathhood),align

hoodhingepinwithanchorholeonlid.

3.Repeatprocedureforotherendofhood.

TSSU Hood Installation Instruction

ecommended

equired

the sandwich salad hood cover to the hood.

See callout #1 on the illustration.

, (packaged within

the cardboard container on top of the salad

position

thumb

the factory

slotted thumb screw. See diagram of slotted

into

hood

cover

humb

4. Repeat procedure for both ends of hood.

Anchoring the TSSU

Hood Cover

LID

HINGE PIN

HOOD

True Food Service Equipment, Inc.

............ www.truemfg.com ............

INSTALLATION / OPERATION INSTRUCTIONS

LEVELING AND CASTOR ADJUSTING

A. Setunitinitsfinallocation.Besurethereisadequate

ventilationinyourroom.Underextremeheat

conditions,(100°F+,38°C+),youmaywanttoinstall

anexhaustfan.

WARNING

Warranty is void if ventilation is insufficient.

B. ProperlevelingofyourTRUEunitiscriticalto

operatingsuccess(fornon-mobilemodels).Effective

condensateremovalanddrawer/dooroperationwill

beeffectedbyleveling.

C. Theunitshouldbeleveledfromtopofthecabinet.

Placealevelonthetopoftheunitfronttobackand

sidetoside.

D. Ensurethatthedrainhoseorhosesarepositionedin

thepan.

E. Freeplugandcordfrominsidethelowerrearofthe

cooler(donotplugin).

F. Theunitshouldbeplacedcloseenoughtothe

electricalsupplysothatextensioncordsarenever

used.

WARNING

Cabinet warranties are void if OEM power cord is tampered

with. TRUE will not warranty any units that are connected to

an extension cord.

Adjusting Castors for Proper Leveling

Levelunit.Ifunitisnotlevelshimsarerequired.

Followtheseinstructionstoinstallshims.

1.Removefrontandreargrilldependinguponwhich

castorneedsadjusting.Locatethecastorbox.(See

image1).

2.Layunitonit’sback.Usesoftpackingmaterialand

becarefulnottoscratchtheunit.Removepansand

lidandplacethemtothesidebeforelayinguniton

it’sback.

3.Loosencastorwithtoolprovided.(Seeimage3).

4.Installthedesirednumberofshims,makingsurethe

slotoftheshimisincontactwiththethreadedstem

ofthecastor.(Seeimage4).Ifmorethanoneshim

isused,turntheslotata90°anglesotheyarenotin

line.

5. Eachunithasonecastorboxdifferentfromthe

others.Thisboxistotallyinclosed.Removethis

castorboxfrombottomofunit.Backoutfour

screwsanchoringthebox.Youwillneeda1/4”hex

headnutdrivertodisassemblethiscastorbox.(See

image4).

6.Afteradjustingcastorreassembleandreinstallcastor

box.Thencarefullyuprightunitandreinstallpans

andlid.

2 3

Locate castor box One castor box on each unit is

fully inclosed.

Loosen castor. Install shims.

Castor Box

Anchor

Screws

True Food Service Equipment, Inc.

............ www.truemfg.com ............

A. Binscanbearrangedindifferentlayoutsforpreferred

placement.

B. Removebinsandadjustcrossbarsfordesired

placement.(Seeimages1-2).

STORAGE BINS

INSTALLATION / OPERATION INSTRUCTIONS

Image 1 Image 2

A. Fordrawerfacealignmentfourscrewsarelocatedon

thebackofthedrawerface.(Seeimage3).

B. Loosenthesefourscrewsandadjustthedrawerface

aligningwiththerestofthedrawers.Anchorthe

fourscrewsoncealignmentisachieved.

DRAWER ALIGNMENT

Image 3

............ www.truemfg.com ............ 88

True Food Service Equipment, Inc.

INSTALLATION / OPERATION INSTRUCTIONS

A. Beforeyournewunitisconnectedtoapowersupply,

checktheincomingvoltagewithavoltmeter.If

anythinglessthan100%oftheratedvoltagefor

operationisnoted,correctimmediately.

B. Allunitsareequippedwithaservicecord,andmust

bepoweredatproperoperatingvoltageatalltimes.

Refertocabinetdataplateforthisvoltage.

TRUE requires that a sole use circuit be dedicated for the

unit. Failure to do so voids warranty.

WARNING

Compressor warranties are void if compressor burns out

due to low voltage.

WARNING

Power supply cord ground should not be removed!

WARNING

Do not use electrical appliances inside the food storage

compartments of the appliances unless they are of the

type recommended by the manufacturer.

NOTE

To reference wiring diagram - Remove front louvered grill,

wiring diagram is positioned on the inside cabinet wall.

ELECTRICAL INSTRUCTIONS

Removal

A. Opendrawercompletely.Rollerclipswillbeinthedownposition.(seeimage1&2)

B. Whileholdingthesidesofthedrawer,useyourfingertorotatetheclipsupward.(seeimage3)

C. Liftdrawerandremovefromchannel.(seeimage4)

DRAWER REMOVAL AND INSTALLATION

Image 1 Image 3 Image 4

Rotate clip

upward.

Image 2

Installation

A. Lowerrearrollersintochannelslots.(seeimage1)

B. Withtherollerclipsintheupwardposition,lowerfrontrollersintochannel.(seeimage2)

C. Makesurerollerclipsareinthedownposition.(seeimage3)

Image 1 Image 3Image 2

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere True Kühlschrank Handbücher

True

True TUC-60 Bedienungsanleitung

True

True T-23 Bedienungsanleitung

True

True TA1RRI89-1S Bedienungsanleitung

True

True TSD-33 Bedienungsanleitung

True

True TGU-3-HC Bedienungsanleitung

True

True TA2RRI-2S Bedienungsanleitung

True

True TCM-78-AC Bedienungsanleitung

True

True TCGG-72-S Bedienungsanleitung

True

True TG1R-1S Bedienungsanleitung

True

True T-49DT-4 Bedienungsanleitung

True

True TUC-72 Bedienungsanleitung

True

True TA2DT-4HS Bedienungsanleitung

True

True T-72G-6 Bedienungsanleitung

True

True GDM-10-58 Bedienungsanleitung

True

True TRCB-52 Bedienungsanleitung

True

True TSD-69G Bedienungsanleitung

True

True TA1R-1S Bedienungsanleitung

True

True TCGD-50 Bedienungsanleitung

True

True TWT-60-32D-2 Bedienungsanleitung

True

True TA1DT-2HS Bedienungsanleitung

True

True TM-74G Bedienungsanleitung

True

True GDM-35SL-RF Bedienungsanleitung

True

True TUC-67D-4 Bedienungsanleitung

True

True GDM-5 Bedienungsanleitung

Beliebte Kühlschrank Handbücher anderer Marken

Bonnet Neve

Bonnet Neve SKYVIEW PLUS Bedienungsanleitung

Zanussi Electrolux

Zanussi Electrolux ZERB 8441 Bedienungsanleitung

Sharp

Sharp SJ-BA31IEXW2-EU Bedienungsanleitung

CORBERO

CORBERO CC2300MCW Bedienungsanleitung

KitchenAid

KitchenAid 2205264 Bedienungsanleitung

NEFF

NEFF KI181 Series Bedienungsanleitung

Hoshizaki

Hoshizaki Reach-In Bedienungsanleitung

Amana

Amana ASD2524VES00 Bedienungsanleitung

BOMANN

BOMANN KGC 213 Bedienungsanleitung

Danby

Danby DAR044A1SLDD Montageanleitung

Beko

Beko CSA31022 Bedienungsanleitung

IKEA

IKEA FROSTIG C 185 E Bedienungsanleitung

Electrolux

Electrolux ER 6821 D Bedienungsanleitung

Frigidaire

Frigidaire FSC23R5DW9 Bedienungsanleitung

Beko

Beko LSP4579W Bedienungsanleitung

Teledyne

Teledyne 6712FR and Betriebsanleitung

Matsui

Matsui MTT50W12E Bedienungsanleitung

Siemens

Siemens KI81RAFE0 Bedienungsanleitung