True TD-50-18-S-LT Bedienungsanleitung

............ www.truemfg.com ............

TABLE OF CONTENTS

Safety Information

Safety Precautions 1

Proper Disposal 2

Connecting Electricity 3

Adapter Plugs 3

Installation / Operation Instructions

Ownership 4

Required Tools 4

Uncrating 4

Location 5

Leveling Cabinet 5

Wire Gauge Cart 6

Sealing Cabinet to the floor 7

Electrical Instructions 8

Direct Draw Draft Arm Installation 8-9

Start-up and Light Switch Location 9

Temperature Control Adjustment 10

Shelving & Bin Divider Installation 11

Storage & Handling 11

Temperature/Pressure/Tapping 12

Draft Beer Problems 13

Maintenance, Care & Cleaning

Changing CO2Gas Cylinder 14

Cleaning Bar System 15

Cleaning the Condenser 16

Important Warranty Information 17

Stainless Steel Equipment Care & Cleaning 18-19

Lightbulb Replacement 20

Warranty (U.S.A. and Canada ONLY!) 21

UNDERBAR

REFRIGERATION

CONGRATULATIONS!

You have just purchased the finest commercial

refrigerator available. You can expect many years

of trouble-free operation.

TBB-3G-S

TBB-2

TD-50-18-S-LT

TDD-4

*Spanish, German, French, and Dutch versions included.

TDB-24-48-1-G-1

12/8/10 CR #894417

INSTALLATION MANUAL FOR

UNDERBAR REFRIGERATION

TRUE FOOD SERVICE EQUIPMENT, INC.

2001 East Terra Lane • O’Fallon, Missouri 63366-4434

(636)-240-2400 • FAX (636)-272-2408 • INT'L FAX (636)272-7546 • (800)-325-6152

Parts Department (800)-424-TRUE • Parts Department FAX# (636)-272-9471

............ www.truemfg.com ............

True Food Service Equipment, Inc.

............ www.truemfg.com ............

SAFETY INFORMATION

True Food Service Equipment, Inc.

• Thisrefrigeratormustbeproperlyinstalled

andlocatedinaccordancewiththeInstallation

Instructionsbeforeitisused.

• Donotallowchildrentoclimb,standorhang

ontheshelvesintherefrigerator.Theycould

damagetherefrigeratorandseriouslyinjure

themselves.

• Donottouchthecoldsurfacesinthefreezer

compartmentwhenhandsaredamporwet.

Skinmaysticktotheseextremelycoldsurfaces.

• Donotstoreorusegasolineorotherflammable

vaporsandliquidsinthevicinityofthisorany

otherappliance.

• Keepfingersoutofthe“pinchpoint”areas;

clearancesbetweenthedoorsandbetweenthe

doorsandcabinetarenecessarilysmall;becareful

closingdoorswhenchildrenareinthearea.

NOTE: We strongly recommend that any servicing

be preformed by a qualified individual.

• Unplugtherefrigeratorbeforecleaning

andmakingrepairs.

• Settingtemperaturecontrolstothe0position

doesnotremovepowertothelightcircuit,

perimeterheaters,orevaporatorfans.

WARNING!

Use this appliance for its intended purpose as described in this Owner Manual.

This cabinet contains fluorinated greenhouse gas covered by the Kyoto Protocol

(please refer to cabinet's inner label for type and volume,

GWP of 134a= 1,300. R404a= 3,800).

How to Maintain Your lkkkfdls

Unit to Receive the Most Efficient and

Successful Operation

You have selected one of the finest commercial refrigeration units made. It is manufactured

under strict quality controls with only the best quality materials available. Your TRUE cooler when

properly maintained will give you many years of trouble-free service.

SAFETY PRECAUTIONS

When using electrical appliances, basic safety precautions should be followed, including the following:

............ www.truemfg.com ............

True Food Service Equipment, Inc.

SAFETY INFORMATION

2 2

PROPER DISPOSAL OF THE REFRIGERATOR

DANGER!

RISK OF CHILD ENTRAPMENT

USE OF EXTENSION CORDS

NEVER USE AN EXTENSION CORD! TRUE will not warranty any refrigerator that has been connected to an extension cord.

Childentrapmentandsuffocationarenotproblems

ofthepast.Junkedorabandonedrefrigeratorsare

stilldangerous…eveniftheywillsitfor“justafew

days.”Ifyouaregettingridofyouroldrefrigerator,

pleasefollowtheinstructionsbelowtohelp

preventaccidents.

Before You Throw Away Your Old Refrigerator or Freezer:

• Takeoffthedoors.

• Leavetheshelvesinplacesothatchildrenmay

noteasilyclimbinside.

Refrigerant Disposal

Youroldrefrigeratormayhaveacoolingsystem

thatuses“OzoneDepleting”chemicals.Ifyou

arethrowingawayyouroldrefrigerator,makesure

therefrigerantisremovedforproperdisposalby

aqualifiedservicetechnician.Ifyouintentionally

releaseanyrefrigerantsyoucanbesubjecttofines

andimprisonmentunderprovisionsofthe

environmentalregulations.

Thepowercordofthisapplianceisequipped

witha3-prong(grounding)plugwhichmates

withastandard3-prong(grounding)walloutlet

tominimizethepossibilityofelectricshock

hazardfromthisappliance.

Havethewalloutletandcircuitcheckedbya

qualifiedelectriciantomakesuretheoutletis

properlygrounded.

Iftheoutletisastandard2-prongoutlet,itis

yourpersonalresponsibilityandobligationto

haveitreplacedwiththeproperlygrounded

3-prongwalloutlet.

Therefrigeratorshouldalwaysbepluggedinto

it’sownindividualelectricalcircuit,whichhas

avoltageratingthatmatchestheratingplate.

Thisprovidesthebestperformanceandalsoprevents

overloadingbuildingwiringcircuitswhichcould

causeafirehazardfromoverheatedwires.

Neverunplugyourrefrigeratorbypullingonthe

powercord.Alwaysgripplugfirmlyandpull

straightoutfromtheoutlet.

Repairorreplaceimmediatelyallpowercordsthat

havebecomefrayedorotherwisedamaged.Donot

useacordthatshowscracksorabrasiondamage

alongitslengthorateitherend.

Whenremovingtherefrigeratorawayfromthe

wall,becarefulnottorolloverordamagethe

powercord.

HOW TO CONNECT ELECTRICITY

Do not, under any circumstances, cut or remove the third (ground) prong from the power cord.

For personal safety, this appliance must be properly grounded.

WARNING!

USE OF ADAPTER PLUGS

NEVER USE AN ADAPTER PLUG! Because of potential safety hazards under certain conditions, we strongly recommend against

the use of an adapter plug.

............ www.truemfg.com ............

SAFETY INFORMATION

True Food Service Equipment, Inc.

115/60/1

NEMA-5-20R

115/208-230/1

NEMA-14-20R

115/60/1

NEMA-5-15R

208-230/60/1

NEMA-6-15R

NEMA plug conﬁgurations

T-Series and GDM Freezers

Spec Series same as T-Series

Back Bar

Milk Coolers

TSSU

TPP

TWT

TUC

TRCB

T-Series and GDM Refrigerators

Double Duty, Single Duty, Curved Glass

Horizontal Freezers

GDIM

TAC (Air Curtain)

(North America Use Only!)

NEMAplugs

TRUEusesthesetypesofplugs.

Ifyoudonothavetherightoutlet

haveacertifiedelectricianinstall

thecorrectpowersource.

............ www.truemfg.com ............

True Food Service Equipment, Inc.

INSTALLATION / OPERATION INSTRUCTIONS

4 4

Toinsurethatyourunitworksproperlyfromthe

firstday,itmustbeinstalledproperly.Wehighly

recommendatrainedrefrigerationmechanicand

electricianinstallyourTRUEequipment.Thecost

ofaprofessionalinstallationismoneywellspent.

BeforeyoustarttoinstallyourTRUEunit,

carefullyinspectitforfreightdamage.Ifdamage

isdiscovered,immediatelyfileaclaimwiththe

deliveryfreightcarrier.

TRUE is not responsible for damage incurred during shipment.

OWNERSHIP

• AdjustableWrench

• PhillipsHeadScrewdriver

• Level

REQUIRED TOOLS

Thefollowingprocedureisrecommendedfor

uncratingtheunit:

A. Removetheouterpackaging,(cardboard

andbubblesorstyrofoamcornersandclear

plastic).Inspectforconcealeddamage.Again,

immediatelyfileaclaimwiththefreightcarrier

ifthereisdamage.

B. Moveyourunitasclosetothefinallocationas

possiblebeforeremovingthewoodenskid.

C. Removedoorbracketonswingingglassdoor

models(seeimage1-2).

Note:Keys for coolers with door locks are located in

warranty packets.

UNCRATING

INSTALLATION / OPERATION INSTRUCTIONS

REMOTE UNITS (This section applies to remotes only!)

• Remotecabinetsmustbeorderedasremote.

Wedonotrecommendconvertingfora

standardselfcontainedtoremotesystem.

• Allremotecabinetsmustbehardwired.

• Nocastorsavailable.

• Allremotecabinetscomestandardusing404A

refrigerant.

• Allremoteunitscomestandardwithexpansion

valve,liquidlinesolenoid,heatedcondensate

pan,anddefrosttimerwhenapplicable.

• ContactTrueTechnicalServiceforBTU 

requirements.

• Nowiringnecessarybetweencabinet

andcondensingunit.

• Allremotecondensingunitspurchased

fromTRUEare208/230voltssinglephase.

If you have any questions regarding this section,

please call TRUE at 1-(800)-325-6152.

............ www.truemfg.com ............

INSTALLATION / OPERATION INSTRUCTIONS

True Food Service Equipment, Inc.

TOOLS REQUIRED:

•Phillipsscrewdriver

•3/8”socketor3/8”wrench

A. Useaphillipsscrewdiverandremovefour

screwsfromtheL-bracketconnectedtheunit

tothewoodskid(seeimage1).Thenusea3/8”

socketorwrenchandremovetheL-bracket

fromtheunit(seeimage2).

Whenliftingunitdonotusethecountertopas

aliftingpoint.Alsoremembertoleavecabinet

uprightfor24hoursbeforeplugging

intopowersource.

B. Removeskidbyunscrewingallbaserailanchor

brackets.Placeskidtotheside.

C. Carefullyuprightcabinet.

LOCATING

(Image 1)

Removing

bracket from

skid.

(Image 2)

Removing

bracket from

cabinet.

A. Setunitinitsfinallocation.Besurethere

isadequateventilationinyourroom.Under

extremeheatconditions,(100°F+,38°C+),

youmaywanttoinstallanexhaustfan.

Warning

Warranty is void if ventilation is insufficient.

B. ProperlevelingofyourTRUEcooleriscritical

tooperatingsuccess(fornon-mobilemodels).

Effectivecondensateremovalanddoor

operationwillbeeffectedbyleveling.

C. Thecoolershouldbeleveledfronttoback

andsidetosidewithalevel.

D. Ensurethatthedrainhoseorhosesare

positionedinthepan.

E. Freeplugandcordfrominsidethelowerrear

ofthecooler(donotplugin).

F. Theunitshouldbeplacedcloseenoughtothe

electricalsupplysothatextensioncordsare

neverused.

Warning

Compressor warranties are void if the unit is more than 7 ft.

(2.1m) from plug-in connection or an extension cord is used

to connect unit to a power supply.

LEVELING

............ www.truemfg.com ............

True Food Service Equipment, Inc.

6 6

CONDUCTORS AND CIRCUITS

Wire Gauge for 2% Voltage Drop in Supply Circuits.

115 Volt Distance In Feet To Center of Load

Amps 20 30 40 50 60 70 80 90 100 120 140 160

2 14 14 14 14 14 14 14 14 14 14 14 14

3 14 14 14 14 14 14 14 14 14 14 14 12

4 14 14 14 14 14 14 14 14 14 12 12 12

5 14 14 14 14 14 14 14 12 12 12 10 10

6 14 14 14 14 14 14 12 12 12 10 10 10

7 14 14 14 14 14 12 12 12 10 10 10 8

8 14 14 14 14 12 12 12 10 10 10 8 8

9 14 14 14 12 12 12 10 10 10 8 8 8

10 14 14 14 12 12 10 10 10 10 8 8 8

12 14 14 12 12 10 10 10 8 8 8 8 6

14 14 14 12 10 10 10 8 8 8 6 6 6

16 14 12 12 10 10 8 8 8 8 6 6 6

18 14 12 10 10 8 8 8 8 8 8 8 5

20 14 12 10 10 8 8 8 6 6 6 5 5

25 12 10 10 8 8 6 6 6 6 5 4 4

30 12 10 8 8 6 6 6 6 5 4 4 3

35 10 10 8 6 6 6 5 5 4 4 3 2

40 10 8 8 6 6 5 5 4 4 3 2 2

45 10 8 6 6 6 5 4 4 3 3 2 1

50 10 8 6 6 5 4 4 3 3 2 1 1

Wire Gauge for 2% Voltage Drop in Supply Circuits.

230 Volt Distance In Feet To Center of Load

Amps 20 30 40 50 60 70 80 90 100 120 140 160

5 14 14 14 14 14 14 14 14 14 14 14 14

6 14 14 14 14 14 14 14 14 14 14 14 12

7 14 14 14 14 14 14 14 14 14 14 12 12

8 14 14 14 14 14 14 14 14 14 12 12 12

9 14 14 14 14 14 14 14 14 12 12 12 10

10 14 14 14 14 14 14 14 12 12 12 10 10

12 14 14 14 14 14 14 12 12 12 10 10 10

14 14 14 14 14 14 12 12 12 10 10 10 8

16 14 14 14 14 12 12 12 10 10 10 8 8

18 14 14 14 12 12 12 10 10 10 8 8 8

20 14 14 14 12 10 10 10 10 10 8 8 8

25 14 14 12 12 10 10 10 10 8 8 6 6

30 14 12 12 10 10 10 8 8 8 6 6 6

35 14 12 10 10 10 8 8 8 8 6 6 5

40 14 12 10 10 8 8 8 6 6 6 5 5

50 12 10 10 8 6 6 6 6 6 5 4 4

60 12 10 8 6 6 6 6 6 5 4 4 3

70 10 10 8 6 6 6 5 5 4 4 2 2

80 10 8 8 6 6 5 5 4 4 3 2 2

90 10 8 6 6 5 5 4 4 3 3 1 1

100 10 8 6 6 5 4 4 3 3 2 1 1

INSTALLATION / OPERATION INSTRUCTIONS

............ www.truemfg.com ............

True Food Service Equipment, Inc.

Step 1 - Position Cabinet

Allowoneinchbetweenthewallandrearof

therefrigeratedBarEquipmenttoassureproper

ventilation.ForGlass&PlateChillers/Frosters

3inchesbetweenthewallandrearofthe

cabinetwillassureproperventilation.

Step 2 - Level Cabinet

Cabinetshouldbelevel,sidetosideandfrontto

back.Placeacarpenter’slevelintheinteriorfloor

infourplaces:

A. Positionlevelintheinsideflooroftheunit

nearthedoors.(Levelshouldbeparalleltocabinet

front).Levelcabinet.

B. Positionlevelattheinsiderearofcabinet.

(Againlevelshouldbeplacedparalleltocabinet

back).

C. PerformsimilarprocedurestostepsA&Bby

placingtheleveloninsidefloor(leftandright

sides-paralleltothedepthofthecooler).Level

cabinet.

Step 3

Drawanoutlineonthebaseonthefloor.

Step 4

Raiseandblockthefrontsideofthecabinet.

Step 5

Applyabeadof“NSFApprovedSealant”,(seelist

below),toflooronhalfinchinsidetheoutlinedrawn.

Thebeadmustbeheavyenoughtosealtheentire

cabinetsurfacewhenitisdownonthesealant.

Step 6

Raiseandblocktherearofthecabinet

Step 7

Applysealantonfloorasoutlined

inStep5onotherthreesides.

Step 8

Examinetoseethatcabinetissealedtofloor

aroundentireperimeter.

Note:

Asphaltfloorsareverysusceptibletochemical

attack.Alayeroftapeonthefloorpriorto

applyingthesealantwillprotectthefloor.

NSF Approved Sealants:

1.MinnesotaMining#ECU800Caulk

2.MinnesotaMining#ECU2185Caulk

3.MinnesotaMining#ECU1055Bead

4.MinnesotaMining#ECU1202Bead

5.ArmstrongCork-RubberCaulk

6.ProductsResearchCo.#5000RubberCaulk

7.G.E.SiliconeSealer

8.DowCorningSiliconeSealer

SEALING CABINET TO FLOOR

INSTALLATION / OPERATION INSTRUCTIONS

............ www.truemfg.com ............

True Food Service Equipment, Inc.

8 8

INSTALLATION / OPERATION INSTRUCTIONS

A. Beforeyournewunitisconnectedtoapower

supply,checktheincomingvoltagewitha

voltmeter.Ifanythinglessthan100%ofthe

ratedvoltageforoperationisnoted,correct

im mediately.

B. Allunitsareequippedwitha7ft.(2.1m)service

cord,andmustbepoweredatproperoperating

voltageatalltimes.Refertocabinetdataplate

forthisvoltage.

TRUErecommendsthatasoleusecircuitbe

dedicatedfortheunit.

WARNING

Compressor warranties are void if compressor burns out due

to low voltage.

WARNING

Power supply cord ground should not be removed!

NOTE

To reference wiring diagram - Remove front louvered grill,

wiring diagram is positioned on the inside cabinet wall.

ELECTRICAL INSTRUCTIONS

Ondirectdraws,thedrainislocatedatthe

frontofthecabinet.Toplumbinthedrain,

connect3⁄4"(2cm)P.V.C.pipetothe3⁄4"(2cm)

barbedfittingsupplieswiththeunit.

CO2PRESSURE

Mobiletapsters,toretaincompletemobility,

theCO2tank(uptofivepoundsinsize)can

beplacedinsidethecooler(strapholders

furnished).

CAUTION

Filled CO2tanks are potentially dangerous because

of the pressure they contain. If you are unfamiliar

with their use or the use of the CO2regulator, seek

information from your local distributor, or your local

beverage man before proceeding.

INSTALL DRAFT ARM

Placerubberwasheroverdraftarmmounting

holesincabinet,putbeerlineconnector

downthroughhole.Next,securedraftarm

withfourscrews.(Seeimages1-6)

DIRECT DRAW DRAFT ARM INSTALLATION

CONTINUED ON

NEXT PAGE...

Draft arm install contents.

(Draft arm not shown)

Beer line

connector.

Thread beer line connector to draft arm and secure draft

arm to cabinet with rubber gasket under the draft arm.

Thread

beer draft

arm handle

onto the

draft arm.

3 4 5

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere True Kühlschrank Handbücher

True

True TUC-72 Bedienungsanleitung

True

True TS-72-6 Bedienungsanleitung

True

True T-35 Bedienungsanleitung

True

True GDM-10RF Bedienungsanleitung

True

True TSD-47 Bedienungsanleitung

True

True TBB-4G Bedienungsanleitung

True

True TG1R-1S Bedienungsanleitung

True

True TCGG-72 Bedienungsanleitung

True

True TUC-48 Bedienungsanleitung

True

True TDD-2-HC Bedienungsanleitung

True

True TCGDZ-50 Bedienungsanleitung

True

True TWT-67 Bedienungsanleitung

True

True TSID Series Bedienungsanleitung

True

True T-23DT Bedienungsanleitung

True

True TAC-30 Bedienungsanleitung

True

True TGU-2 Bedienungsanleitung

True

True T-23-HC Bedienungsanleitung

True

True T-23-2 Bedienungsanleitung

True

True TMC-49-HC Bedienungsanleitung

True

True TDB-24-48-1-G-1 Bedienungsanleitung

True

True T-23DT Bedienungsanleitung

True

True TCGD-59 Bedienungsanleitung

True

True TG2DT-2S Bedienungsanleitung

True

True TUC-27 Bedienungsanleitung

Beliebte Kühlschrank Handbücher anderer Marken

Bonnet Neve

Bonnet Neve SKYVIEW PLUS Bedienungsanleitung

Zanussi Electrolux

Zanussi Electrolux ZERB 8441 Bedienungsanleitung

Sharp

Sharp SJ-BA31IEXW2-EU Bedienungsanleitung

CORBERO

CORBERO CC2300MCW Bedienungsanleitung

KitchenAid

KitchenAid 2205264 Bedienungsanleitung

Stengel

Stengel KU 1101 A++ Bedienungsanleitung

NEFF

NEFF KI181 Series Bedienungsanleitung

Hoshizaki

Hoshizaki Reach-In Bedienungsanleitung

Amana

Amana ASD2524VES00 Bedienungsanleitung

BOMANN

BOMANN KGC 213 Bedienungsanleitung

Danby

Danby DAR044A1SLDD Montageanleitung

Samsung

Samsung RF323TE Bedienungsanleitung

Beko

Beko CSA31022 Bedienungsanleitung

IKEA

IKEA FROSTIG C 185 E Bedienungsanleitung

Electrolux

Electrolux ER 6821 D Bedienungsanleitung

Frigidaire

Frigidaire FSC23R5DW9 Bedienungsanleitung

Beko

Beko LSP4579W Bedienungsanleitung

Teledyne

Teledyne 6712FR and Betriebsanleitung