U-Line WINE CAPTAIN 2115R Bedienungsanleitung

www.U-LineService.com

Phone (414) 354-0300 • FAX (414) 354-7905

Service & Parts Tech Lines Phone (800) 779-2547 • FAX (414) 354-5696

[email protected]

04/2006

Custom 1/4" Door Panel

Preparation and Installation

Instructions for

Models 2175, 2115 and CLR2160

™

www.U-LineService.com 204/2006

™

Custom 1/4'' Door Panel Insert

Door Panel Preparation

A custom door panel can be inserted into the doorframe.

Custom door panels can be flat or raised, as long as the

maximum panel thickness where inserted into the door

reveal (channel) is 1/4"-thick. For raised panels, the depth

of the reveal is 1/4" on all four sides.

IMPORTANT

Raised panels will reduce the door’s 90° swing/zero

clearance if the unit is installed next to a wall or similar

type of structure.

For 2175 models cut the panel insert to the following

dimensions.

Custom 1/4" Dimensions:

Width: 23-1/32"

Height: 27-11/16"

For 2115 & CLR2160 models cut the panel insert to the

following dimensions.

Custom 1/4" Dimensions:

Width: 14-1/32"

Height: 27-11/16"

The door panel must not weigh more than 20 lbs.

Door Panel Installation

Install the insert as follows:

CAUTION

Use care when handling the insert. Insert edges may be

sharp.

1. Remove top hinge screw pin (using a Phillips

screwdriver, see Figure 1). Remove door by tilting

forward and lifting off bottom hinge pin.

2. Pull door gasket out of groove (top edge of door only).

Start in the middle and pull outward, moving toward

the edge (see

Figure 2

). This may take some force.

3. Remove two outside screws holding door handle.

Slightly separate door handle from door (see

Figure 3

4. Pull handle up and off.

5. Remove and discard

existing panel and

cardboard spacer.

6. Slide custom door panel

insert into 1/4-inch

channel in door front.

7. Holding door gasket out

of the way, replace handle

on door, making sure it is

seated properly on insert

and that screw holes line up.

8. Install two small screws removed in Step 3.

9. Starting at the corners and working inward, push door

gasket into place on door.

10. Place door on bottom hinge pin and install upper hinge

screw.

ULIN_0133a_

Figure 1 Figure 2

Figure 3

04/2006 3www.U-LineService.com

™

Checking Door Alignment

The unit’s door is aligned at the factory before shipment.

However, its alignment could have been disturbed during

shipment or during door panel installation.

IMPORTANT

Properly aligned, the door should be 1/8" below the top of

the unit’s cabinet, NOT flush with the top (see

Figure 4

1. Compare the top edge of the door to the top edge of

the cabinet.

2. If the door edge is 1/8" below and parallel to the top of

the cabinet, the door is aligned. If it is not, note

whether the side opposite the hinge needs to be moved

UP or DOWN, and use the following procedure.

Adjusting Door Alignment

1. Remove top hinge screw

pin (using a Phillips

screwdriver, see Figure

5). Remove door by tilting

forward and lifting off

bottom hinge pin.

2. With door upside-down,

loosen but do not remove

the two screws on the

door’s bottom hinge plate.

3. See

Figure 6

. If the top far edge of the door needs to

move UP, move the hinge plate toward the outside of

the door and retighten screws. If the top far edge of the

door needs to move DOWN, move the hinge plate

toward the inside of the door and retighten screws.

4. Mount the door to recheck alignment and repeat Steps

2 and 3 if further adjustment is necessary.

5. When top edge of door is parallel to top edge of

cabinet, remove the door and ensure the two screws

are secure.

6. Remove the door closers from the bottom hinge, clean

thoroughly and lubricate the mating surfaces with

petroleum jelly.

7. Reinstall the closers, lining

up the bosses with holes in

hinge and hinge plate (see

Figure 7

8. Mount the door and install

top hinge pivot pin.

1/8"

Figure 4

Figure 5

Notch

(must face toward

center of door)

Slotted

Mounting

Holes

Raise

Outside

Door Edge

Lower

Outside

Door Edge

Figure 6

Door

Closer

Inserts

Boss

Figure 7

™

Publication No. 30154E

04/2006 Rev. A

U-Line Corporation, located in Milwaukee, WI, is a family operated manufacturer of built-in

undercounter icemakers, Combo®icemaker/refrigerators, Wine Captain®wine storage units,

refrigerators, refrigerated drawers and refrigerator/freezers.

For more than four decades, U-Line has distinguished itself as the leader in built-in

undercounter ice making, refrigeration and wine storage appliances.

Who to Call

Service Information

If the need for service arises, contact the dealer from

whom the unit was purchased. State the Model Number

and Serial Number and explain the problem. The Model

and Serial Number plate is located inside unit at upper

right hand corner.

If you need to locate a service company, you can go online

at www.U-LineService.com and search for a service

company by zip code.

Andere Handbücher für WINE CAPTAIN 2115R

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere U-Line Kühlschrank Handbücher

U-Line

U-Line 3018RGL Bedienungsanleitung

U-Line

U-Line UHRE124-IG81A Installationshandbuch

U-Line

U-Line UORE124-SS31A Installationshandbuch

U-Line

U-Line Echelon CO2075FF Bauanleitung

U-Line

U-Line 1224SOD Bedienungsanleitung

U-Line

U-Line Echelon CO2075FF Bedienungsanleitung

U-Line

U-Line Combo CO29 Bedienungsanleitung

U-Line

U-Line U-1024RS-00A Installationshandbuch

U-Line

U-Line UMRI121-WS01A Installationshandbuch

U-Line

U-Line UCRE518 Installationshandbuch

U-Line

U-Line 3000 SERIES Installationshandbuch

U-Line

U-Line Combo U-CO29FB-00A Bedienungsanleitung

U-Line

U-Line 2245RDC Bedienungsanleitung

U-Line

U-Line U-1224FZRINT-00A Installationshandbuch

U-Line

U-Line UCBR552-SG01A Installationshandbuch

U-Line

U-Line Echelon 2075R Bedienungsanleitung

U-Line

U-Line Wine Captain UHWD524IS01A Installationshandbuch

U-Line

U-Line Outdoor UOKR124SS01A Installationshandbuch

U-Line

U-Line 1000 SERIES Bedienungsanleitung

U-Line

U-Line Origins 1175BEVS00 Bedienungsanleitung

U-Line

U-Line 2115RSOD Bedienungsanleitung

U-Line

U-Line Outdoor Series Installationshandbuch

U-Line

U-Line pmn Bedienungsanleitung

U-Line

U-Line BrightShield HRE524 Bedienungsanleitung

Beliebte Kühlschrank Handbücher anderer Marken

Bonnet Neve

Bonnet Neve SKYVIEW PLUS Bedienungsanleitung

Zanussi Electrolux

Zanussi Electrolux ZERB 8441 Bedienungsanleitung

Sharp

Sharp SJ-BA31IEXW2-EU Bedienungsanleitung

CORBERO

CORBERO CC2300MCW Bedienungsanleitung

KitchenAid

KitchenAid 2205264 Bedienungsanleitung

Stengel

Stengel KU 1101 A++ Bedienungsanleitung

NEFF

NEFF KI181 Series Bedienungsanleitung

Hoshizaki

Hoshizaki Reach-In Bedienungsanleitung

Amana

Amana ASD2524VES00 Bedienungsanleitung

BOMANN

BOMANN KGC 213 Bedienungsanleitung

Danby

Danby DAR044A1SLDD Montageanleitung

Samsung

Samsung RF323TE Bedienungsanleitung

Beko

Beko CSA31022 Bedienungsanleitung

IKEA

IKEA FROSTIG C 185 E Bedienungsanleitung

Electrolux

Electrolux ER 6821 D Bedienungsanleitung

True

True TS-28 Bedienungsanleitung

Frigidaire

Frigidaire FSC23R5DW9 Bedienungsanleitung

Beko

Beko LSP4579W Bedienungsanleitung