Vollrath TW 27R Kurzanleitung

The Vollrath Company, L.L.C.

1236 North 18th Street

P.O. Box 611

Sheboygan, WI 53082-0611

Telephone 920 457-4851

Operating and Safety

Instructions

TW 27R & TSM 27

Model Numbers:

72028 - TW 27R, 1400 Watts, 120 Volts

72030 – TSM 27, 1400 Watts, 120 Volts

72031 – TSM 27, 1400 Watts, 120 Volts, With Canopy

72032 – TSM 27, 1470 Watts, 120 Volts, With Canopy and Lights

17784 3/03

TW 27R and TSM 2 7

TW 27 R & TSM 27

Thank you for purchasing this Vollrath food rethermalizer/warmer. Before operating this unit,

read and familiarize yourself with the following operating and safety instructions. SAVE

THESE INSTRUCTIONS FOR FUTURE REFERENCE.

WARNING

ELECTRIC SHOCK, FIRE OR BURN INJURIES CAN OCCUR IF

THIS EQUIPMENT IS NOT USED PROPERLY. TO REDUCE RISK OF INJURY:

• Plug only into grounded electrical outlets matching the nameplate rated voltage.

• Unit should only be used in a flat, level position.

• Unplug warmer and let cool before cleaning or moving.

• Do not spray controls or outside of unit with liquids or cleaning agents.

• Handle hot water carefully.

• Do not immerse

• Unplug warmer when not in use

• Do not operate unattended

IMPORTANT: Always operate this unit with water in the well

Function and Purpose:

This unit is intended to rethermalize containers of previously cooked food and hold containers of

hot food at a safe serving temperature. This unit is not intended or designed to cook raw food

product.

Installation:

This unit is to be used on a countertop. This unit is not designed be enclosed or built into any

area.

Operation :

1. Place the food merchandiser on a flat, level surface. This unit is not designed to be enclosed

or built in any area.

2. Fill each well with 1 quart of water. Do not overfill wells. Always maintain water in well.

WARNING

ELECTRICAL SHOCK HAZARD

Keep water level at approx. 1 quart. If level is too high, water

may overflow when the food container is inserted. The overflow could

enter the electrical compartment and cause a short circuit or electric shock.

17784 3/03

TW 27R and TSM 27

3. Plug power cord into grounded electrical outlet with the nameplate rated voltage.

WARNING

BURN HAZARD

Hot water and steam in the well can burn skin.

Use protective gloves, mitts or potholders when removing

food containers or covers. Hot food can also cause burns. Handle hot food carefully.

4. Operation of:

Hot Food Holding

1. Preheat the water in the wells by covering wells with empty food containers or

covers, and then setting the heat control to the maximum heat setting.

Preheat for15 minutes

2. Place container of hot food product into preheated food merchandiser. Reduce

heat setting and monitor food temperatures closely for food safety. (See food

safety precautionary note below)

3. Maintain water level at or near water level mark. Periodically (approximately

2 hours) remove container of food and check the water level. Add hot water if

needed.

Rethermalizing refrigerated food that has been previously cooked

1. Preheat the water in the wells by covering wells with empty food containers or

covers, and then setting the heat control to the maximum heat setting.

Preheat for 1 hour

2. Set the timer to 1 (one) hour for rethermalizing. (TW 27R Only)

3. During the rethermalization process, monitor food temperatures closely for

food safety. The United States Public Health Service recommends that the

entire food product reaches and maintains a minimum of 165°F (74°C) for at

least 15 seconds to be properly rethermalized. In addition, rethermalized food

must pass through the danger zone of 41°F (5°C) to 165°F (74°C) in less than

2 hours to prevent growth of organisms of public health concern. Do not add

cold food for rethermalizing while holding hot food; the merchandiser

will cool down and not hold the hot food at proper serving temperature.

To reach the required safe food temperature as quickly as possible, do not add

water or remove food pan during the rethermalization process.

17784 3/03

TW 27R and TSM 27

5. Reduce heat setting to a level that will maintain a safe holding temperature and maintain food

quality. (See Food Safety Precautionary Note)

FOOD SAFETY PRECAUTIONARY NOTE

Monitor food temperatures closely for food safety. The United States Public Health

Service recommends that food be held at a minimum of 140°F (60°C) to help prevent

bacteria growth. Maintain water level at approximately 1 quart. Water level MUST be

sufficient to completely submerse the element. Periodically (approx. 2 hours) remove

container of food and check the water level. Add hot water if needed.

Cleaning:

To maintain appearance and increase the service life, the food warmer should be cleaned at least

daily.

1. Before cleaning unplug the unit and let it and any liquid in the unit cool completely.

WARNING

BURN HAZARD

Hot water and hot parts can burn skin.

Allow hot wells and water to cool before handling.

2. Carefully empty water from the wells.

3. Wipe the entire well interiors with a clean, damp cloth.

4. To avoid damaging the finish, do not use abrasive materials, scratching cleaners or scouring

pads to clean water deposits from the wells.

5. If soap or chemical cleaners are used, be sure they are completely rinsed away with clear

water, immediately after cleansing. Chemical residue could corrode surface of unit.

WARNING

ELECTRICAL SHOCK HAZARD

Do not spray outside of unit or controls with liquid or cleaning

product. Liquid could enter the electrical compartment and cause a

short circuit or electric shock.

17784 3/03

TW 27R and TSM 27

Trouble Shooting:

Symptom Probable Cause

Unit operates on HIGH

continuously

When the timers are used to rethermalize cold food (TW 27R

only), the unit will operate on high and not respond to changes

in the thermostat. When the timers cycle off and

rethermalization is complete, the thermostat will then regulate

the temperature of the unit to the setting of the thermostat. The

timers should not be used for hot holding operation.

The pilot light turns off when the

unit should be working

The light indicates when there is power to the element. It will

cycle on and off with the element.

The lights on the TSM 27 do not

turn on

The lights have an independent ON/OFF Switch and power

cord that can be plugged into the back of the unit or into

another source. Be sure the lights are plugged in and the switch

is turned on.

Repair:

There are no user serviceable parts within this appliance. To avoid serious injury or damage,

never attempt to repair the food warmer/rethermalizer or replace a damaged power cord yourself.

Contact a qualified professional repair service.

17784 3/03

TW 27R and TSM 27

Exploded View TSM 27:

17784 3/03

TW 27R and TSM 27

Exploded View TW 27

17784 3/03

TW 27R and TSM 27

72031 Menu Board Assembly

Parts List:

1. Mounting bracket (Assembled to Menu Board, 4 places)

2. Menu Board with Decal

3. Decal (Not Shown), Affixed to Menu Board

4. Washer ¼”

5. Bolt ¼” x 20 x 1.5”

6. Straight Post

7. End Cap 4 pcs (Already Assembled)

Installation and Assembly:

1. Mount straight posts to warmer back with bolts and washers. Tighten bolts finger tight only.

2. Make sure there is no dirt, oil or grease on the posts. Remove backing from double sided tape that

is in the mounting bracket sections. Position menu board so top is slightly above the plastic caps on

the top end of the posts. Press menu board assembly to the posts securely.

3. Tighten bolts with wrench.

17784 3/03

TW 27R and TSM 27

72032 Lighted Canopy Assembly Instructions

Parts List:

1. Canopy Decal, Not Shown

2. Canopy

3. Light Bracket (Assembled to light and

canopy)

4. Halogen Light (Assembled to Bracket)

5. Menu Board Decal, Not Shown

6. Menu Board

7. Posts (2)

8. Mounting bracket (Assembled to menu

board, 4 places)

9. Post End Caps, (4) (Assembled to Posts)

10. Bolt, ¼” x 20 x 1.5”, (4)

11. Washer, ¼”, (4)

Assembly:

1. Assemble posts to back of warmer unit

with bolts and washers. Tighten finger

tight only.

2. Make sure there is no grease, oil or dirt

on the posts. Remove backing from

double sided tape from the inside of the

light bracket channels (2 places). Mount

canopy assembly to posts by pressing

bracket down over the posts. Position

canopy so front edge is closest to the post

end caps.

3. Remove the backing from the double

sided tape on the menu board. Position

menu board approximately 1” (25 mm)

above top edge of warmer. Press firmly

into place.

4. Tighten bolts from step #1 with wrench.

17784 3/03

TW 27R and TSM 27

17784 3/03

Warranty Policy for The Vollrath Co. L.L.C.

The Vollrath Company L.L.C. warranties all products it manufactures and distributes

against defects in materials and workmanship for a period of one year - except as listed

below, from the date of purchase to the original purchaser under normal use and service.

All warranties are void if the product has been damaged by accident, neglect, improper

use or other causes not arising out of defects in materials or workmanship.

 Refrigeration compressors – 5 year warranty

 Intrigue & Classic Select cookware – Limited lifetime warranty

 Replacement parts – 90 (ninety days) on the part only

 Fry pans and coated cookware – 90 (ninety days)

The Vollrath Company shall not be liable for loss of use of the product or other incidental

or consequential costs, expenses or damage incurred by the purchaser.

Warranty work must have prior approval from The Vollrath Company.

Warranty Procedure for Countertop Equipment

During the warranty period the food warmer will be replaced without charge to the original

purchaser when returned prepaid and insured, with proof of purchase date, to the dealer who

originally sold the unit. Should it become necessary to return this product to The Vollrath

Company, you must first obtain return authorization and shipping instructions from The

Vollrath Company Customer Service Department. Please have model number and serial

number information available when calling.

 Carefully pack the item in its original carton or other suitable box to avoid shipping

damage.

 Attach a tag to the item before packing with your name, complete address and phone

number, model and serial number, purchase information and an explanation of the

problem. Include RETURN AUTHORIZATION PACKING SLIP.

 We recommend you insure the package, as shipping damage is not covered under

warranty.

Mailing address:

The Vollrath Company L.L.C.

1236 N. 18th Street

Sheboygan, WI 53081

PLEASE ALLOW 30 – 45 DAYS FOR REPLACEMENT WARMER

RETURNS WITHOUT PRIOR AUTHORIZATION WILL NOT BE ACCEPTED

Dieses Handbuch passt für folgende Modelle

Inhaltsverzeichnis

Andere Vollrath Speisenwärmer Handbücher

Vollrath

Vollrath Mirage 74701DW Bedienungsanleitung

Vollrath

Vollrath User Instructions Bedienungsanleitung

Vollrath

Vollrath Mirage 74705DW Bedienungsanleitung

Vollrath

Vollrath CAYENNE 2000 Bedienungsanleitung

Vollrath

Vollrath 71001 Bedienungsanleitung

Vollrath

Vollrath 38002 Bedienungsanleitung

Vollrath

Vollrath FC-6IH-01120 Bedienungsanleitung

Vollrath

Vollrath 5950145 Bedienungsanleitung

Vollrath

Vollrath MIRAGE 74702D Bedienungsanleitung

Vollrath

Vollrath 36460 Kurzanleitung

Vollrath

Vollrath 72788 Bedienungsanleitung

Vollrath

Vollrath Cayenne CM-24 Bedienungsanleitung

Vollrath

Vollrath Cayenne 72789 Bedienungsanleitung

Vollrath

Vollrath Cayenne 3001 Bedienungsanleitung

Vollrath

Vollrath 36460 Bedienungsanleitung

Vollrath

Vollrath Cayenne 1001 Bedienungsanleitung

Vollrath

Vollrath Mirage 74704DW Bedienungsanleitung

Vollrath

Vollrath Cayenne Heat 'N Serve HS-7 Bedienungsanleitung

Vollrath

Vollrath Mirage 59502 Bedienungsanleitung

Vollrath

Vollrath CAYENNE 2000 Bedienungsanleitung

Vollrath

Vollrath CAYENNE Bedienungsanleitung

Vollrath

Vollrath Drop-In Hot Wells Kurzanleitung

Vollrath

Vollrath Cayenne PC-21 Bedienungsanleitung

Vollrath

Vollrath 5950275 Bedienungsanleitung

Beliebte Speisenwärmer Handbücher anderer Marken

ARREDO

ARREDO Illusion 1000 Bedienungsanleitung

Moffat

Moffat BKRW3 Service-Handbuch

Hupfer

Hupfer SPTW-2/EBF Bedienungsanleitung

Kontour

Kontour K1043E Bedienungsanleitung

Hatco

Hatco Glo-Ray GRMW-3 Anwendungshandbuch

HATO

HATO Macho Nacho FST-1-MN Bedienungsanleitung

Wittco

Wittco 500-CW Bedienungsanleitung

Wells

Wells SS-276ULT Bedienungsanleitung

Kerbl

Kerbl FastHeat Bedienungsanleitung

Johnson

Johnson Kaldino Bedienungsanleitung

Wells

Wells BMW206ULRTD/AF Bedienungsanleitung

KRATOS

KRATOS 29М-008 Bedienungsanleitung

Wells

Wells M227 Series Bedienungsanleitung

Henny Penny

Henny Penny HCS-2 Bedienungsanleitung

Amba

Amba RADIANT RSWH-P Bedienungsanleitung

Homecraft

Homecraft BS15BS Bedienungsanleitung

Hatco

Hatco PW Series Bedienungsanleitung

Schaerer

Schaerer Cup warmer Bedienungsanleitung