Volvo S60 - ANNEXE 931 Bedienungsanleitung

Instruction No Version Part. No.

8622899 1.0

Cruise control

M3903270

Instruction No Version Part. No.

8622899 1.0

Cruise control

M3903270

Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden

Page 1 / 10

Equipment

A0000162 A0801178 A0000161

M8802509

Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden

Page 2 / 10

R8802817

Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden

Page 3 / 10

INTRODUCTION

Read through all of the instructions before starting installation.

Notifications and warning texts are for your safety and to

minimise the risk of something breaking during installation.

Ensure that all tools stated in the instructions are available

before starting installation.

Certain steps in the instructions are only presented in the form

of images. Explanatory text is also given for more complicated

steps.

In the event of any problems with the instructions or the

accessory, contact your local Volvo dealer.

Note!

This accessory requires software unique to the car

A8800136

Preparations

Turn the ignition key to position “0”. Remove the ignition key

from the ignition switch

Disconnect the battery negative lead.

Note!

Wait at least five minutes before disassembling the connectors

or removing other electrical equipment.

Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden

Page 4 / 10

M6400668

Disassembling, the steering wheel

Turn the steering wheel a quarter turn so that the holes on the

reverse of the steering wheel are accessible.

M6400670

Insert a screwdriver in the hole (2) on the reverse of the steering

wheel, at right angles to the rear surface of the steering wheel.

Insert a screwdriver as far as possible to determine the position

of the end of the spring clip (1)

Position the end of the screwdriver on the top of the spring clip

as illustrated

Pry the screwdriver upwards towards the upper edge of the hole

(2) so that the end of the screwdriver presses the spring clip

down (1) until one side of the steering wheel module springs out

and releases from the mounting

Turn the steering wheel a half turn in the opposite direction.

Carry out the same operation on the other side

Turn the steering wheel to the neutral position.

Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden

Page 5 / 10

M3903271

Fold the steering wheel module out

Remove the two connectors (1) for the ignition cables for the

airbag. First press in the catches on the sides. Then pull the

connectors straight out.

Note!

The connectors are tightly secured. However, tools must not

be used when removing.

Place the steering wheel module to one side.

M6400671

Remove the screw (1). Remove the ground lead

Disconnect the connector (2) for the horn and the keypads

Remove the three screws (3). Lift the horn out (4).

Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden

Page 6 / 10

M3903317

Applies to cars with pre-routed wiring

Press in the catch (1) on the connectors for the left dummy

button. Remove the connectors.

M3903278

Applies to all cars

Remove the screw (1) in the dummy button on the left hand side

of the horn

Press in the catch (2). At the same time pull the dummy button

from its socket. Place the dummy button to one side. If there is

existing wiring: continue with point 10.

Note!

If there is no existing wiring the horn must be replaced. A new

horn is in the kit. Carry out points 8- 9.

Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden

Page 7 / 10

M3903276

Applies to cars without existing wiring

Remove the screw (1) in the dummy button on the right hand

side of the horn

Press in the catch (2). At the same time pull the dummy button

from its socket.

Note!

Take care of the dummy button, it will be reused.

Place the old horn to one side. The horn will not be reused.

M3903280

Applies to cars without existing wiring

Install the new horn in position

Insert the right dummy button into the groove until the catch

engages

Install the screw. Tighten the dummy button

Connect the connector to the dummy button.

Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden

Page 8 / 10

M3903273

Installing, the keypad for the cruise control

Applies to all cars

Insert the new keypad for the cruise control into the grooves until

the catch engages

Install the screw. Tighten the keypad

Connect both the connectors to the keypad.

Reinstall the horn. See point 5. Ensure that the three springs are

positioned correctly. Check that the ground lead is not trapped

Tighten the screws crosswise. Tighten to 6.5 Nm (5 lbf. ft.)

Reinstall the ground lead using the screw. Tighten the ground

lead

Connect the connector for the horn and the keypads

Check the function of the horn. Press the horn all the way

around its circumference. (A metallic noise should be heard).

M6400669

Check that the two springs (1) are in position

Connect the two connectors for the ignition cables for the

steering wheel module

Insert the two pins on the reverse of the steering wheel module

in the two springs. Ensure that the ignition cables are not

trapped

Press the steering wheel module into the mountings (two clicks

should be heard).

Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden

Page 9 / 10

A8800137

Finishing work

Turn the ignition key to position “II”.

Connect the battery negative lead

Program the software according to the service information in

VIDA.

Installation instructions, accessories Volvo Car Corporation Gothenburg, Sweden

Page 10 / 10

Andere Handbücher für S60 - ANNEXE 931

Andere Volvo Automobil Handbücher

Volvo

Volvo 850 AWD Bedienungs- und Wartungsanleitung

Volvo

Volvo XC90 RECHARGE Bedienungsanleitung

Volvo

Volvo XC90 PREMIER Kurzanleitung

Volvo

Volvo S90 2019 Bedienungsanleitung

Volvo

Volvo XC 60 Bedienungsanleitung

Volvo

Volvo 2009 V70 R-DESIGN Kurzanleitung

Volvo

Volvo S80 - Bedienungsanleitung

Volvo

Volvo XC40 Twin Engine Bedienungsanleitung

Volvo

Volvo S80 - Bedienungsanleitung

Volvo

Volvo 240 1975 Bedienungsanleitung

Volvo

Volvo V70 SPORT Bedienungsanleitung

Volvo

Volvo S60 - ANNEXE 931 Kurzanleitung

Volvo

Volvo 2011 S60 Bedienungsanleitung

Volvo

Volvo C70 Bedienungsanleitung

Volvo

Volvo S60 - ANNEXE 931 Bedienungsanleitung

Volvo

Volvo S40 - ANNEXE 244 Kurzanleitung

Volvo

Volvo XC40 Twin Engine Bedienungsanleitung

Volvo

Volvo V90 CROSS COUNTRY Bedienungsanleitung

Volvo

Volvo CROSS COUNTRY 2011 Bedienungsanleitung

Volvo

Volvo V60 RECHARGE 2021 Bedienungsanleitung

Volvo

Volvo V70 SPORT Kurzanleitung

Volvo

Volvo S60 2012 Kurzanleitung

Volvo

Volvo V60 TWIN ENGINE 2019 Bedienungsanleitung

Volvo

Volvo XC60 - ANNEXE 541 Bedienungsanleitung

Beliebte Automobil Handbücher anderer Marken

Toyota

Toyota 2000 Tundra Bedienungsanleitung

CITROËN

CITROËN DS4 DSign Bedienungsanleitung

Cadillac

Cadillac CTS 2008 Bedienungsanleitung

Porsche

Porsche Boxster S Bedienungsanleitung

KIAM

KIAM SPORTAGE 2014 Stücklistenhandbuch

GMC

GMC 2013 Terrain Montageanleitung

Lexus

Lexus 2015 CT 200h Bedienungsanleitung

GMC

GMC T-Series 1999 Bedienungsanleitung

Mercury

Mercury 1998 Mystique Bedienungsanleitung

Mercury

Mercury 2007 Mariner Bedienungsanleitung

Mazda

Mazda 2007 Mazdaspeed 3 Leitfaden

Mazda

Mazda 2014 CX-5 Bedienungsanleitung

GMC

GMC Chevrolet Express 2022 Bedienungsanleitung

GMC

GMC 1997 Jimmy Bedienungsanleitung

Chevrolet

Chevrolet 2012 Malibu Bedienungsanleitung

Skoda

Skoda FABIA RS - ANNEXE 118 Bedienungsanleitung

Seat

Seat toledo Bedienungsanleitung

PEUGEOT

PEUGEOT 206 CC Bedienungsanleitung