WaterLogic WL290 Betriebsanleitung

WL290Manual Page57Revision9‐3‐2019

HOTWATERTROUBLESHOOTINGINDEX



1. HotWaterisnotHot85°C(185°+/‐5°F)



IncludedinthissectionaretheTwoResettableHotTankOverloads(HighLimitSafety)

Instructions.



1. HotWaterisnotHot85°C(185°+/‐5°F)



TheHottemperaturesetpointis85°C(185°F)andiscontrolledbyathermistorinthewellof

theHotTank.



TherearetwoHotTankOverloadDevices(HighSafetyLimit)onthesideoftheHotTankthat

willtriptopreventdamagetotheunitifthetankisdryheated(turnedonwithoutwaterin

it).



Ittypicallytakes10minutesforthe500Wtoheatthe1.6Literofroomtemperature

(ambient)watertothe85°C(185°F)setpoint.



PossibleReason Solution

Nopowertoheaterelements

CheckthattheRedHeaterandCompressor

switchison.



TurnRedHeaterandCompressorSwitchon.

I=ON

HotTankOverloadDevices

(HighSafetyLimit)tripped



HotTankOverloadDevices

(HighSafetyLimit)isasafety

featuretoensurethetankdoes

notoverheat.

HotTankOverloadDevices(HighSafetyLimit)will“click”

whenpushed.TheHotTankOverloadDevices(High

SafetyLimit)areautomaticallyresetwhenpressed.



SeeResetting HotTankOverloadDevices(HighSafety

Limit)Instructionsthatareincludedfurtherbelowinthis

TroubleshootingSection

HotTankOverloadDevices

(HighSafetyLimit)“open”on

HotTank

TurnPoweroff.



CheckOHM’sresistanceacrossterminalsoneachofthe

HotTankOverloadDevices(HighSafetyLimit)separately.

Goodcomponentswillindicateaclosedcircuitorzero

OHM’sonthemeter.



Replacecomponentsasnecessary.

Looseorimproperlyconnected

wire(s)totheheatingelement/

hottank.

Visuallyinspectwireleadsgongtothehottank;confirm

properconnectionstotheheatingelements.



Hottanklifeis3‐5years,dependingonusage.



WL290Manual Page58Revision9‐3‐2019

*Typically,dealersswapoutthehottankatsite,takeback

totheshoptorepair.

HeatingCoilNotWorking

TurnPoweroff;Drainhottank;Usemulti‐metertocheck

heaterelementforapproximately26OHM’sresistance.



Hottankmustbeemptyifyouarecheckingforcontinuity.



ReplaceHotTankasnecessary.





WL290Manual Page59Revision9‐3‐2019

RESETTINGTHETWOHOTTANKOVERLOADDEVICES(HIGHLIMITSAFETY)



 

1.



TurnoffRedHeaterandCompressorPowerSwitchO=OFFonrearofunit.

2. UnplugthePowerCordfromrearofunit. 

3.



Remove4PhillipScrewsfromtheAccessPanelonrearofunit

andLowerAccessPanel. 

4.



LocateprotectivemetalboxonrearofHotTank.Pushdownontopofmetalboxto

accessthetwoOverloadResetDevices.



5.

PresstheOverloadResetDevices.



6. Reattachthemetalboxbydepressingthetopflapofthemetalboxsoitsnapsbackinto

itsoriginalpositionontheHotTank.

WL290Manual Page60Revision9‐3‐2019

7.



ReplacetheAccessPaneland4Philipsscrews. 

8. PluginthePowerCord.

9. MakesurethehotandcoldtanksarefilledwithwaterBEFOREturningontheRed

HeaterandCompressorPowerSwitch



CAUTION!NEVERTURNONHEATERBEFOREFILLINGHOTTANK.

RedHeaterandCompressorPowerSwitchmustbeintheO=OFFposition

whiletheHotTankisempty.Damagecouldoccurwithinoneminuteand

theoverload(highlimit)willrequiremanualresetifheateristurnedon

withanemptyHotTank.



10. Verifythecoolerisfullyoperationalbeforeinstallingitatthecustomers’site.





Andere Handbücher für WL290

Inhaltsverzeichnis

Andere WaterLogic Wasserspender Handbücher

WaterLogic

WaterLogic WL270 Betriebsanleitung

WaterLogic

WaterLogic WL3 Firewall Bedienungsanleitung

WaterLogic

WaterLogic WL2000IT Bedienungsanleitung

WaterLogic

WaterLogic NIAGARA IB Bedienungsanleitung

WaterLogic

WaterLogic WL900 Bedienungsanleitung

WaterLogic

WaterLogic WL100 Handbuch

WaterLogic

WaterLogic WL900 Bedienungsanleitung

WaterLogic

WaterLogic WL200 Bedienungsanleitung

WaterLogic

WaterLogic WL250 Betriebsanleitung

WaterLogic

WaterLogic WL250 Handbuch

WaterLogic

WaterLogic WL800 - MAX II Handbuch

WaterLogic

WaterLogic WL200 Referenzhandbuch

WaterLogic

WaterLogic WL7 Bedienungsanleitung

WaterLogic

WaterLogic WL400 Series Referenzhandbuch

WaterLogic

WaterLogic WL350 Betriebsanleitung

WaterLogic

WaterLogic infiniti Handbuch

WaterLogic

WaterLogic CUBE Referenzhandbuch

WaterLogic

WaterLogic WL500 - Sparkling Bedienungsanleitung

WaterLogic

WaterLogic ICE 900 Bedienungsanleitung

WaterLogic

WaterLogic WL350 Betriebsanleitung

WaterLogic

WaterLogic WL290 Bedienungsanleitung

WaterLogic

WaterLogic WL 1000 GF Bedienungsanleitung

WaterLogic

WaterLogic 4 Firewall Bedienungsanleitung

WaterLogic

WaterLogic WL4 Firewall Bedienungsanleitung

Beliebte Wasserspender Handbücher anderer Marken

Monarch Water

Monarch Water ULTIMATE MINI AQUA HE Bedienungsanleitung

Haier

Haier HLM-109B Bedienungsanleitung

abc

abc Fleck 5600SXT Bedienungsanleitung

GE GXOF18G Betriebsanleitung

Kenmore

Kenmore 625.385560 UltraFilter 650 Bedienungsanleitung

Innova

Innova CEV+ Kurzanleitung

Aries

Aries Hydra DI Handbuch

GE GNCF02H Bedienungsanleitung

ProFlo

ProFlo PFB Series Bedienungsanleitung

Hydrotech

Hydrotech 89DF HIM Bedienungsanleitung

A.O. Smith

A.O. Smith FREZYA 300S Bedienungsanleitung

Frakco

Frakco Travelsoft RV 2400HD Bedienungsanleitung

GE GXSF30V Betriebsanleitung

Avanti

Avanti WD31EC Bedienungsanleitung

Avanti

Avanti WD360 Bedienungsanleitung

BRIO

BRIO CLCTTL520 Benutzerhandbuch

3M HCD-1 Bedienungsanleitung

Elkay

Elkay EFHFA8_2CJO Installationshandbuch