Whirlpool Commercial Dryer Bedienungsanleitung

INSTALLATION INSTRUCTIONS

Commercial Dryer

Gas (120-Volt, 60-Hz) or

Electric (120/240-Volt, 60-Hz)

www.whirlpoolcommerciallaundry.com8563800D

TABLE OF CONTENTS

Page

Dryer Safety ......................................................................... 2

Tools & Parts ........................................................................ 5

Dimensions/Clearances ...................................................... 6

Locaon Requirements ....................................................... 8

Gas Dryer Electrical Requirements ...................................... 9

Gas Requirements ............................................................ 10

Electric Dryer Electrical Requirements .............................. 11

Dryer Venng Requirements ............................................. 13

Gas Supply Connecon ..................................................... 15

Installing Leveling Legs, Coin Slide, and Coin Box ............... 17

Electric Dryer Electrical Connecons ................................. 18

Leveling ............................................................................. 22

Complete Installaon ........................................................ 23

Changing to a 30- or 60-Minute Timing Cam ...................... 24

Maintenance Instrucons .................................................. 25

If You Need Assistance ....................................................... 25

DRYER SAFETY

■It is recommended that the owner post, in a prominent locaon, instrucons for the customer’s use in the event the customer

smells gas. This informaon should be obtained from your gas supplier.

■Post the following warning in a prominent locaon.

DRYER SAFETY

IMPORTANT: When discarding or storing your old clothes dryer, remove the door.

DRYER SAFETY

■Clean dryer lint screen before or aer each load.

■ Do not use this dryer without the lint screen in place.

■ Do not repair or replace any part of the dryer or aempt

any servicing unless specically recommended in this

Installaon Instrucons or in published user-repair

instrucons that you understand and have the skills

to carry out.

■ Do not use fabric soeners or products to eliminate stac

unless recommended by the manufacturer of the fabric

soener or product.

■ Do not use heat to dry arcles containing foam rubber or

similarly textured rubber-like materials.

■ The nal part of a tumble dryer cycle occurs without heat

(cool-down cycle) to ensure that the arcles are le at

a temperature that ensures that the items will not be

damaged.

■WARNING: Never stop a tumble dryer before the end of

the drying cycle unless all items are quickly removed and

spread out so that the heat is dissipated. (Avoids risk of

spontaneous combuson).

■ Keep area around the exhaust opening and adjacent

surrounding areas free from the accumulaon of lint,

dust, and dirt.

■ The interior of the dryer and dryer exhaust vent should

be cleaned periodically by qualied service personnel.

■ See “Electrical Requirements” secon for grounding

instrucons.

IMPORTANT SAFETY INSTRUCTIONS

WARNING: To reduce the risk of re, electric shock, or injury to persons when using the dryer, follow basic precauons,

including the following:

SAVE THESE INSTRUCTIONS

■ Read all instrucons before using the dryer.

■ This dryer is intended only for drying clothes and texles

that have been washed in water. Do not use for any

other purpose.

■WARNING: If you smell gas, do not use the dryer or any

electrical equipment nearby. Warn other people to clear

the area. Contact the dryer owner immediately.

■ Do not place items exposed to cooking oils in your dryer.

Items contaminated with cooking oils may contribute to

a chemical reacon that could cause a load to catch re.

■ Do not dry arcles that have been previously cleaned

in, washed in, soaked in, or spoed with gasoline,

dry-cleaning solvents, other ammable, or explosive

substances as they give o vapors that could ignite

or explode.

■Do not dry unwashed items in the dryer.

■ Do not allow children to play on or in the dryer. Close

supervision of children is necessary when the dryer is

used near children.

■ Before the dryer is removed from service or discarded,

remove the doors to the dryer compartment.

■ Do not reach into the dryer if the drum is moving.

■ Do not open door while dryer is in operaon. It will stop.

■Do not install or store the dryer where it will be exposed

to the weather.

■Do not tamper with controls.

Tools Needed:

8" (200 mm) 8" (200 mm) or 10" (250 mm) flat-blade screwdriver phillips screwdriver

or 10" (250 mm) adjustable wrench

pipe wrench that opens to 1" (25 mm)

Torx®† T-20 security 1" (25 mm) hex-head 5⁄16" (8 mm) socket wrench pliers (that open to

screwdriver or bit socket wrench 19/16" [39 mm])

level utility knife 1/4" (6 mm) nut driver 27" (686 mm)

wood block

caulk gun and caulk vent clamps pipe-joint compound putty knife

(for installing new exhaust vent) suitable for gas type

flashlight (optional) 1" (25 mm) ruler or measuring tape

open-end wrenches

TOOLS & PARTS

†® TORX is a registered trademark of Saturn Fasteners, Inc.

Parts Supplied:

leveling legs (4) security cone 5/16" hex head –

18 x 21⁄2" security bolt

3-pin 60-minute ming cam 6-pin 30-minute ming cam

DIMENSIONS/CLEARANCES

Front View Side View

Dimensions – 29" (737 mm) model

Bottom exhaust

35"

(889 mm)

Non-coin-operated

models:

71/8"

(181 mm)

Coin-operated

models:

77/8"

(200 mm)

(25 mm)

251/2"

(648 mm)

31/4"

(83 mm)

101/4"

(260 mm)

29"

(737 mm)

427/8"

(1089 mm)

(25 mm)

Back View

43/4"

(121 mm)

141/4"

(362 mm)

Electric

Gas

29"

(737 mm)

11/4"

(32 mm)

315/8"

(803 mm)

4" dia

(102 mm)

20"

(508 mm)

143/4"

(375 mm)

DIMENSIONS/CLEARANCES

Front View Side View

Dimensions – 27" (686 mm) model

Clearances

Recessed front view Closet side view

Bottom exhaust

35"

(889 mm)

Non-coin-operated

models:

71/8"

(181 mm)

Coin-operated

models:

77/8"

(200 mm)

(25 mm)

261/2"

(673 mm)

31/4"

(83 mm)

101/4"

(260 mm)

27"

(737 mm)

427/8"

(1089 mm)

(25 mm)

15"

(381 mm)

(0 mm)

14"

(356 mm)

(25 mm)

(0 mm)

Back View

11/4"

(32 mm)

53/8"

(137 mm)

16"

(406 mm)

37"

(940 mm)

(gas models)

131/2"

(343 mm)

Electric

Gas

27"

(686 mm)

31/4"

(83 mm)

4" dia

(102 mm)

13"

(330 mm)

315/8"

(803 mm)

(electric models)

Your dryer can be installed in a basement, laundry room, or

recessed area.

Companion appliance locaon requirements should also be

considered.

IMPORTANT: Do not install or store the dryer where it

will be exposed to the weather. Proper installaon is your

responsibility.

You will need:

■ A grounded electrical outlet located within 6 . (1.8 m) of

where the power cord is aached to the back of the dryer.

See “Electrical Requirements.”

■ A level oor with a maximum slope of 1" (25 mm) under

enre dryer. Installing the dryer on so oor surfaces,

such as carpets or surfaces with foam backing, is not

recommended.

Dryer installation clearances

■ The locaon must be large enough to allow the dryer door

to be fully opened.

■Addional spacing should be considered for ease of

installaon and servicing. The door opens more than 180°.

■Addional clearances might be required for wall, door, and

oor moldings.

■ Addional spacing of 1" (25 mm) on all sides of the dryer is

recommended to reduce noise transfer.

When installing a gas dryer:

IMPORTANT: Observe all governing codes and ordinances.

■Check code requirements: Some codes limit or do not

permit installaon of clothes dryers in garages, closets, or

sleeping quarters. Contact your local building inspector.

■ Make sure that lower edges of the cabinet, plus the back

and boom sides of the dryer, are free of obstrucons to

permit adequate clearance of air openings for combuson

air. See “Recessed Area and Closet Installaon Instrucons”

below for minimum spacing requirements.

LOCATION REQUIREMENTS

Recessed Area and Closet Installation Instructions

This dryer may be installed in a recessed area or closet. For

recessed area and closet installaons, minimum clearances

can be found on the warning label on the rear of the dryer

or in “Dimensions/Clearances.”

The installaon spacing is in inches and is the minimum

allowable. Addional spacing should be considered for ease

of installaon, servicing, and compliance with local codes and

ordinances.

If closet door is installed, the minimum unobstructed air

opening in the top and boom is required. Louvered doors

with equivalent air openings are acceptable.

The dryer must be exhausted outdoors.

No other fuel-burning appliance may be installed in the same

closet as the dryer.

24 in.2

(155 cm2)

48 in.2

(310 cm2)3"

(76 mm)

Closet

door

Front

View

closet

door

front

view

Gas Dryer Grounding

IMPORTANT: The dryer must be electrically grounded in

accordance with local codes and ordinances or, in the absence

of local codes, with the Naonal Electrical Code, ANSI/NFPA 70,

latest edion, or Canadian Electrical Code, CSA C22.1. If codes

permit and a separate ground wire is used, it is recommended

that a qualied electrical installer determine that the ground

path is adequate.

A copy of the above code standards can be obtained from:

Naonal Fire Protecon Associaon

One Baerymarch Park, Quincy, MA 02269

CSA Internaonal

8501 East Pleasant Valley Road

Cleveland, Ohio 44131-5575

■Do not ground to a gas pipe.

■Do not have a fuse in the neutral or ground circuit.

■ A 120 volt, 60 Hz, AC only, 15- or 20-amp, fused electrical

circuit is required. A me-delay fuse or circuit breaker is

also recommended. It is recommended that a separate

circuit serving only this dryer be provided.

■This dryer is equipped with a power supply cord having a

3-prong grounding plug.

■ To minimize the possibility of shock, the cord must be

plugged into a mang, 3 prong, grounding-type outlet,

grounded in accordance with local codes and ordinances.

If a mang outlet is not available, it is the personal

responsibility and obligaon of the customer to have the

properly grounded outlet installed by a qualied electrician.

■ If codes permit and a separate ground wire is used, it is

recommended that a qualied electrician determine that

the ground path is adequate.

■ Check with a qualied electrician if you are not sure the

dryer is properly grounded.

GAS DRYER ELECTRICAL REQUIREMENTS

IMPORTANT: Observe all governing codes and ordinances.

This installaon must conform with all local codes and

ordinances. In the absence of local codes, installaon must

conform with American Naonal Standard, Naonal Fuel Gas

Code ANSI Z223.1/NFPA 54 or CAN/CSA B149.

A copy of the above code standards can be obtained from:

Naonal Fire Protecon Associaon

One Baerymarch Park, Quincy, MA 02269

CSA Internaonal

8501 East Pleasant Valley Road

Cleveland, Ohio 44131-5575

The design of this dryer has been cered by CSA Internaonal

for use at altudes up to 10,000 feet (3048 m) above sea level

at the B.T.U. rang indicated on the model/serial plate. Burner

input adjustments are not required when the dryer is operated

up to this elevaon.

When installed above 10,000 feet (3048 m), a four percent

(4%) reducon of the burner B.T.U. rang shown on the model/

serial plate is required for each 1,000 foot (305 m) increase in

elevaon. For assistance when converng to other gas types

and/or installing above 10,000 feet (3048 m) elevaon, contact

your local service company.

Gas Supply

GAS REQUIREMENTS

Inhaltsverzeichnis

Andere Whirlpool Trockner Handbücher

Whirlpool

Whirlpool LE781OXP Bedienungsanleitung

Whirlpool

Whirlpool WGD9470WW Stücklistenhandbuch

Whirlpool

Whirlpool FFT M22 8X2BS BE Bedienungsanleitung

Whirlpool

Whirlpool Duet Steam Bedienungsanleitung

Whirlpool

Whirlpool LEB6400KQ1 Bedienungsanleitung

Whirlpool

Whirlpool LE5200XTW0 Bedienungsanleitung

Whirlpool

Whirlpool YWED72HEDW Bedienungsanleitung

Whirlpool

Whirlpool GGW9250PW Bedienungsanleitung

Whirlpool

Whirlpool LE4900XM Bedienungsanleitung

Whirlpool

Whirlpool WGD97HEDC0 Bedienungsanleitung

Whirlpool

Whirlpool LER4624BW2 Bedienungsanleitung

Whirlpool

Whirlpool WGD8300SB1 Bedienungsanleitung

Whirlpool

Whirlpool WGD9250WR - Duet Cranberry - Gas Dryer Bedienungsanleitung

Whirlpool

Whirlpool WED4800X Bedienungsanleitung

Whirlpool

Whirlpool CSP2761TQ Bedienungsanleitung

Whirlpool

Whirlpool LDR3822HQ0 Bedienungsanleitung

Whirlpool

Whirlpool WGD6600VU Bedienungsanleitung

Whirlpool

Whirlpool WED5200T Bedienungsanleitung

Whirlpool

Whirlpool LE3300XPWO Bedienungsanleitung

Whirlpool

Whirlpool WGD9500TC1 Bedienungsanleitung

Whirlpool

Whirlpool 7MWGD1750EQ Bedienungsanleitung

Whirlpool

Whirlpool WED5100HW Bedienungsanleitung

Whirlpool

Whirlpool 3979171 Bedienungsanleitung

Whirlpool

Whirlpool W10529641A Bedienungsanleitung

Beliebte Trockner Handbücher anderer Marken

Bosch

Bosch WTA79200GB Bedienungsanleitung

Amana

Amana W10233410A Bedienungsanleitung

Miele

Miele TWH 780 WP Bedienungsanleitung

Asko

Asko T760 Bedienungsanleitung

Alliance Laundry Systems

Alliance Laundry Systems 25 Series Bedienungsanleitung

Bosch

Bosch Logixx 10 WTB76556GB Technisches Datenblatt

STIEBEL ELTRON

STIEBEL ELTRON Ultronic S Bedienungsanleitung

Electrolux

Electrolux EW2H328R2 Bedienungsanleitung

Beko

Beko DS8433RX1M Bedienungsanleitung

Dawlance

Dawlance Spinner DS 6000 C Bedienungsanleitung

Electrolux

Electrolux TP5080TW Bedienungsanleitung

AEG

AEG TR838P4OB Bedienungsanleitung

Indesit

Indesit IDV 75 Bedienungsanleitung

Infiniton

Infiniton SD-DG85C Bedienungsanleitung

BOMANN

BOMANN WT 5019 Bedienungsanleitung

Alliance Laundry Systems

Alliance Laundry Systems TMB795C Bedienungsanleitung

Asko

Asko T793C Bedienungsanleitung

Kenmore

Kenmore 8041 - 5.8 cu. Ft. Capacity Electric Dryer Bedienungsanleitung