Winmate P Series Bedienungsanleitung
Please read this instructions before operating the device and retain them for future reference.
IP69K Stainless P-Series
Panel PC with Conduit Pipe
Intel®Core™i5-7200U Kaby Lake, 2.5 GHz
15”/ 19”/ 21.5”/ 23.8”
Model No. R15IK3S-SPC369-P
R19IK3S-SPM169-P
W22IK3S-SPA369-P
W24IK3S-SPA269-P
Quick Start Guide
Document Version 1.0
Document Part No. 91521110104R
2
IP69K Stainless P-Series Panel PC Quick Start Guide
Contents
Chapter 1: Introduction 6
1.1 Overview 6
1.2 Features 6
1.3 Package Content 7
1.4 Product Overview 8
1.5 Physical Buttons 10
1.6 Air Vent Valve 10
1.7 Wi-Fi Antenna 11
1.8 Connector Description 12
Chapter 2: Installation 13
2.1 Mounting 13
2.1.1 VESA Mount 13
2.1.2 Yoke Mount 14
2.1.3 Panel Mount 14
2.2 I/O Cover and Conduit Pipe Installation 15
2.3 Conduit Pipe Removal 17
2.4 Wiring Requirements 17
2.5 Wiring Diagram 18
2.6 Connector Pin Assignments 19
2.6.1 Power Connector 19
2.6.2 HDMI Connector 19
2.6.3 RJ45 Connector 20
2.6.4 USB Connector 20
2.6.5 Serial Port Connector 20
Chapter 3: Getting Started 21
3.1 Connecting to Power Source 21
3.1.1 Connecting to AC Power Source 21
3.1.2 Connecting to DC Power Source (Optional) 22
3.2 Turning On/ Off the Device 22
3.3 How to Enable Watchdog 23
Chapter 4: Maintenance and Troubleshooting 24
4.1 Cleaning the Monitor 24
4.2 Basic Troubleshooting 24
Appendix 25
Appendix A: Hardware Specifications 25
Appendix B: Winmate Software Development Kit 26
Appendix C: Yoke Mount Stand Kit Dimensions 26
3
Chapter 1: Introduction
FCC Statement
This device complies with part 15 FCC rules.
Operation is subject to the following two conditions:
This device may not cause harmful interference.
This device must accept any interference received
including interference that may cause undesired
operation.
This equipment has been tested and found to comply with the limits for a class "B" digital
device, pursuant to part 15 of the FCC rules. These limits are designed to provide reasonable
protection against harmful interference when the equipment is operated in a commercial
environment. This equipment generates, uses, and can radiate radio frequency energy and, if
not installed and used in accordance with the instruction manual, may cause harmful
interference to radio communications. Operation of this equipment in a residential area is likely
to cause harmful interference in which case the user will be required to correct the interference
at him own expense.
European Union
Electromagnetic Compatibility Directive (2014/30/EU)
EN55024: 2010/ A1: 2015
oIEC61000-4-2: 2009
oIEC61000-4-3: 2006+A1: 2007+A2: 2010
oIEC61000-4-4: 2012
oIEC61000-4-5: 2014
oIEC61000-4-6: 2014
oIEC61000-4-8: 2010
oIEC61000-4-11: 2004
EN55032: 2012/AC:2013
EN61000-3-2:2014
EN61000-3-3:2013
Low Voltage Directive (2014/35/EU)
EN 60950-1:2006/A11:2009/A1:2010/A12:2011/ A2:2013
This equipment is in conformity with the requirement of the following EU legislations and
harmonized standards. Product also complies with the Council directions.
4
IP69K Stainless P-Series Panel PC Quick Start Guide
Copyright Notice
No part of this document may be reproduced, copied, translated, or transmitted in any form or
by any means, electronic or mechanical, for any purpose, without the prior written permission
of the original manufacturer.
Trademark Acknowledgement
Brand and product names are trademarks or registered trademarks of their respective owners.
Disclaimer
Winmate Inc. reserve the right to make changes, without notice, to any product, including
circuits and/or software described or contained in this manual in order to improve design
and/or performance. We assume no responsibility or liability for the use of the described
product(s) conveys no license or title under any patent, copyright, or masks work rights to
these products, and make no representations or warranties that these products are free from
patent, copyright, or mask work right infringement, unless otherwise specified. Applications
that are described in this manual are for illustration purposes only. We make no representation
or guarantee that such application will be suitable for the specified use without further testing
or modification.
Warranty
Winmate Inc. warranty guarantees that each of its products will be free from material and
workmanship defects for a period of one year from the invoice date. If the customer discovers
a defect, we will, at his/her option, repair or replace the defective product at no charge to the
customer, provide it is returned during the warranty period of one year, with transportation
charges prepaid. The returned product must be properly packaged in its original packaging to
obtain warranty service. If the serial number and the product shipping data differ by over 30
days, the in-warranty service will be made according to the shipping date. In the serial
numbers the third and fourth two digits give the year of manufacture, and the fifth digit means
the month (e. g., with A for October, B for November and C for December).
For example, the serial number 1W17Axxxxxxxx means October of year 2017.
Customer Service
We provide a service guide for any problem by the following steps: First, visit the website of
our distributor to find the update information about the product. Second, contact with your
distributor, sales representative, or our customer service center for technical support if you
need additional assistance.
You may need the following information ready before you call:
Product serial number
Software (OS, version, application software, etc.)
Description of complete problem
The exact wording of any error messages
In addition, free technical support is available from our engineers every business day. We are
always ready to give advice on application requirements or specific information on the
installation and operation of any of our products.
5
Chapter 1: Introduction
Advisory Conventions
Four types of advisories are used throughout the user manual to provide helpful information or
to alert you to the potential for hardware damage or personal injury. These are Notes,
Important, Cautions, and Warnings. The following is an example of each type of advisory.
Note:
A note is used to emphasize helpful information
Important:
An important note indicates information that is important for you to know.
Caution A Caution alert indicates potential damage to hardware and explains how to
avoid the potential problem.
Attention Une alerte d’attention indique un dommage possible à l’équipement et
explique comment éviter le problème potentiel.
Warning! An Electrical Shock Warning indicates the potential harm from electrical
hazards and how to avoid the potential problem.
Avertissement! Un Avertissement de Choc Électrique indique le potentiel de chocs
sur des emplacements électriques et comment éviter ces problèmes.
Safety Information
Warning! Always completely disconnect the power cord from your chassis whenever
you work with the hardware. Do not make connections while the power is on. Sensitive
electronic components can be damaged by sudden power surges. Only experienced
electronics personnel should open the PC chassis.
Avertissement ! Toujours débrancher le cordon d’alimentation du chassis lorsque
vous travaillez sur celui-ci. Ne pas brancher de connections lorsque l’alimentation est
présente. Des composantes électroniques sensibles peuvent être endommagées par
des sauts d’alimentation. Seulement du personnel expérimenté devrait ouvrir ces
chassis.
Caution Always ground yourself to remove any static charge before touching the
CPU card. Modern electronic devices are very sensitive to static electric charges. As a
safety precaution, use a grounding wrist strap at all times. Place all electronic
components in a static-dissipative surface or static-shielded bag when they are not in
the chassis.
Attention Toujours verifier votre mise à la terre afin d’éliminer toute charge statique
avant de toucher la carte CPU. Les équipements électroniques moderns sont très
sensibles aux décharges d’électricité statique. Toujours utiliser un bracelet de mise à
la terre comme précaution. Placer toutes les composantes électroniques sur une
surface conçue pour dissiper les charge, ou dans un sac anti-statique lorsqu’elles ne
sont pas dans le chassis.
Alternating Current !The Protective Conductor Terminal (Earth Ground) symbol
indicates the potential risk of serious electrical shock due to improper grounding.
Mise à le terre ! Le symbole de Mise à Terre indique le risqué potential de choc
électrique grave à la terre incorrecte.
6
IP69K Stainless P-Series Panel PC Quick Start Guide
Chapter 1: Introduction
1.1 Overview
Congratulations on purchasing Winmate® IP69K Stainless P-Series Panel PC.
Winmate P-Series Panel PC features with a waterproof conduit pipe for added cable protection.
The IP69K series is built to withstand extensive wash downs with corrosion resistance against
cleaning agents, especially against close-range high-pressure, high temperature wash downs.
The level of protection allows for easy cleaning and sterilization using water with temperatures
of up to 80°C and pressure of up to 30 Bar. A custom-built waterproof conduit pipe was also
provided for the customer with a cover plate, allowing for an additional layer of protection for
the cables.
1.2 Features
The IP69K Stainless P-Series Display features:
15/ 19/ 21.5/ 23.8” LCD screen with projected capacitive multi-touch
Intel® Core™ i5-7200U Kaby Lake, 2.5 GHz
Full IP69K waterproof enclosure, good corrosion resistance
Conduit pipe for additional cable protection
Air vent valve
Sleek bezel design with round corners
SUS304 stainless steel for food and chemical industries
Multiple mounting options: panel mount, yoke and VESA
7
Chapter 1: Introduction
1.3 Package Content
Carefully remove the box and unpack your device. Please check if all the items listed below
are inside your package. If any of these items are missing or damaged contact us immediately.
Factory shipment list:
Panel PC
Quick Start Guide
(Hardcopy)
AC Adapter
Varies by product specifications
Part No. 91521110104R
50W: 90PO12800000
Open Wire Cable for
Phoenix Connector
(Optional for 9~36V DC)
Waterproof
Conduit 1.5m
Conduit Elbow
Part No. 94EL03L030E1
Part No. 9B000000011I
Part No. 9B000000011J
Yoke Mount Stand Kit
(Optional)
D-sub to RJ45 adapter
15" Part No. 98K015A0000D
19" Part No. 98K019A00002
21.5" Part No.98K021A00001
23.8" Part No.98K023A00001
D-sub 9pin (M) to RJ45
Part No. 601100090000
D-sub 9pin (F) to RJ45
Part No. 601200090001
8
IP69K Stainless P-Series Panel PC Quick Start Guide
1.4 Product Overview
This section contains mechanical drawing of the IP69K Stainless P-Series Panel PC. Notice
that this is a simplified drawing and some components are not marked in detail.
Note 1: Yoke mount stand kit is an optional accessory.
Note 2: Wi-Fi antenna is an optional feature
15”, R15IK3S-SPC369-P Unit: mm
Dimensions: 356 x 280 x 56 mm
19”, R19IK3S-SPM169-P Unit: mm
Dimensions: 445 x 370 x 56 mm
9
Chapter 1: Introduction
21.5”, W22IK3S-SPA369-P Unit: mm
Dimensions: 531 x 322 x 56 mm
23.8”, W24IK3S-SPA269-P Unit: mm
Dimensions: 600 x 369 x 56 mm
10
IP69K Stainless P-Series Panel PC Quick Start Guide
1.5 Physical Buttons
The P-Series Panel PC has one Power physical button located on the rear side. Press the Power
button to power on or power off the device.
1.6 Air Vent Valve
The P-Series Panel PC has an air vent valve that has an automatic mechanical system that
controls and maintains pressure without the assistance of an operator. The air vent valve is a
safety device that discharges air in order to avoid air related problems.
Andere Handbücher für P Series
2
Dieses Handbuch passt für folgende Modelle
4
Inhaltsverzeichnis
Andere Winmate Touchscreen Handbücher
Winmate
Winmate W10IB3S-PCH2AC-PoE S-Series Bedienungsanleitung
Winmate
Winmate W04FA3S-EHT1 Bedienungsanleitung
Winmate
Winmate W07IB3S-POM1 Bedienungsanleitung
Winmate
Winmate PT Series Bedienungsanleitung
Winmate
Winmate W07FA3S-PCM1AC-PoE Bedienungsanleitung
Winmate
Winmate W19IB3S-CHA1 Bedienungsanleitung
Winmate
Winmate GC Series Bedienungsanleitung
Winmate
Winmate R10IB3S-67T2 Bedienungs- und Wartungsanleitung
Winmate
Winmate R10IBWS-MHP1 Bedienungsanleitung
Winmate
Winmate R15IB3S-PCC3-PoE Bedienungsanleitung
Winmate
Winmate R15IK3S-65C3 Bedienungsanleitung
Winmate
Winmate P-CAP SERIES Bedienungsanleitung
Winmate
Winmate R15IK3S-SPC3 Bedienungsanleitung
Winmate
Winmate W07FA3S-GCM1 Bedienungsanleitung
Winmate
Winmate IP69K Stainless P-Cap Bedienungsanleitung
Winmate
Winmate ATEX R19IHAT-66EX-T Bedienungsanleitung
Winmate
Winmate R05FA3S-OFD1HMHB Bedienungsanleitung
Winmate
Winmate G-WIN Bedienungsanleitung
Winmate
Winmate R15ID3S-65A1FTE Bedienungsanleitung
Winmate
Winmate R17IV3S-MRM1 Bedienungsanleitung
Beliebte Touchscreen Handbücher anderer Marken
IBASE Technology
IBASE Technology ASTUT-152-RE1S Bedienungsanleitung
YASKAWA
YASKAWA TP 610C Bedienungsanleitung
B&R
B&R Power Panel C Series Bedienungsanleitung
Beijer Electronics
Beijer Electronics X2 control Bedienungsanleitung
AXIOMTEK
AXIOMTEK GOT321W-521 Bedienungsanleitung
TRIDONIC.ATCO
TRIDONIC.ATCO x-touchBOX Bedienungsanleitung
